Академический Документы
Профессиональный Документы
Культура Документы
"#$
%%%%%%%%%%%%%%%%Automatic Cle&'
%%%%%%%%%%%%%%%%%%(&)*+%#,-),..*+%
%
%
%%%%%Owners Manual
%
%
%
%
%
%%%%%%%%%%%%%%%%%%%%%
%
%
%
%%%%%%%%%%%%%%%%%%%%%%%%1 / Ringwell Drive. Unit 1
%%%%%%%%%%%%%%%%%%%%%%%%Newmarket, Ontario L3Y 012
%%%%%%%%%%%%%%%%%%%%%%%Canada
%%%%%%%%%%%%%%%%%%%%%www.distilled-water.com
%Phone (905) 657-5128 %%13..%4+**%5!0$$! 06! 776
%%%%%%%%%%%%%%%%%%%%%Fax (905) 657-5131
Contents:
Introduction…………………………………………………………………..1
Available Options……………………………………………………………2
Preparation……………………………………………………………………3
Installation…………………………………………………………………….4
Trouble Shooting……………………………………………………………..7
Maintenance…………………………………………………………………..8
!"#$%%&'($)*$+,,,,,,,,,,,,,,,,,,,,,,,,--.
&
/$*#"&-------------------,,,,,,,,,,,,,,,,,,,,,,,-01
!"##"$%&'''''''''''''''''''''''''''''''''''''''''''''''''''''''''''''''''''''''''''''''''''''''''''''''''((&
ATTENTION:
IMPORTANT INFORMATION
Please Note:
If you are on a well,
you will require a Inline 5 Micron Filter
& 550ml Flo Restrictor.
ATTENTION:
Installation Instructions
Introduction to the D3
!"#$%&'(")#*+#',-".#/&'0&1"2#',-/%"3"#&42#)"&25#6,)#(4.3&%%&3(,47## !")"#&)"#
"8#94(:9"#(3"-.#3!&3#.!,9%2#;"#&22)".."2#;"6,)"#(4.3&%%&3(,4#;"1(4.7####
#
!"#$%&'(")#*+#8(%%#,4%5#,/")&3"#8!(%"#&33&'!"2#3,#3!"#<=>*#?@ AB#%(4"7##@3C
3&'!(41#3!"#94(3#3,#3!"#!,3#8&3")#%(4"#8(%%#-&0"#(3#(4,/")&;%"7####
#
!"#$%&'(")#*+#(.#&#."%6C'%"&4(41#94(37## !(.#-"&4.#3!&3#3!"#*+#8(%%#2,#&#;&'0#
8&.!#3,#3!"#;,(%")#"&'!#3(-"#3!"#6%,&3#%"D"%#(4#3!"#.3,)&1"#3&40#)"&'!".#(3E.#!(1!
8&3")#-&)07## !(.#/)"D"43.#3!"#;9(%2#9/#,6#."2(-"43#&42#',43&-(4&3".#(4#3!"#
;,(%")F#&%%,8(41#6,)#;"33")#/")6,)-&4'"#&42#%,41")#%(6"#,6#3!"#94(37#@%3!,91!#3!"#
*+#(.#."%6C'%"&4(41F#(3#2,".#)":9()"#&#-&49&%#'%"&4#&449&%%57# !"#'%"&4(41#(4C
.3)9'3(,4.#'&4#;"#6,942#,4#G&1"#H7###
#
!"#$%&'(")#*+F#&.#&3")C',,%"2#94(3F#"%(-(4&3".#-,.3#,6#3!"#!"&3#4,)-&%%5#
&..,'(&3"2#8(3!#2(.3(%%&3(,47## !")"6,)"#(4.3&%%&3(,4.#(4#'&;(4"3.#&42#'%,."3.#&)"#
/,..(;%"7##I&45#94(3.#&)"#&%.,#(4.3&%%"2#,4#.!"%D(41#,)#',943")#3,/.#(4#,93#,6#
3!"#8&5#&)"&.7#
Remember there are three (3) necessary items needed for installation:
Unpacking the D3
Available Options:
Evaluate the location in which you wish to install the Glacier Water Dis-
tiller. Remember that there are, three needed items:
If drainage is below the level of the Glacier boiler when installed, an op-
tional drain valve solenoid MUST be used. The automatic clean cycle is
a gravity feed to either the drain pump (provided with all units), or to the
optional solenoid.
For drainage above the boiler the drain pump must be used.
For drainage below the boiler the SOLENOID must be used.
Approximately
15-20 minutes
later, the boiler
will be making
steam. At this
time check the
Automatic-Drain
(A.D.) system.
The A.D. system won't engage until
the temperature in the boiler reaches 195
degrees. A good indicator is when the steam
tube gets hot.
Demand pump runs Leak in lines from pump Check all fittings and lines
constantly
Pump out of adjustment Adjust pump with 5/64 Allen wrench
Adjustment is at the center of pump
head. Turn clockwise until the pump
stops.
Boiler not hot No electricity to boiler Check reset thermostat on the front
of the boiler. Push to reset.
Maintenance
Although the Glacier D3-AD distiller is self-cleaning it is recommended that the boiler be de-
scaled at least once per year.
6. Remove corner acorn nuts and open cover of boiler. (be gentle with
gasket)
7. Clean inside of boiler tank. Remove excess sediment with small putty
knife (being careful around element). If difficult use vinegar and water, no
chemicals recommended.
9. Reattach boiler to distiller and put main power switch to the on position.
3 6
4
1
3
2
"
*+,($2)!3$-)&+,$4536$7/81
)" -)&+,
("
!" &"
!#$% '#(%
-)&+,$*+,($./01
!"#$%&'()$*+,(
4!C'$2+"'()
9'(&3$:5;(
+"
'"
9A5'@!BB
!"#$%&'()*'"(
=!+"()
4)(@2+"'()
4!<()$ !)#
*"
'("
9'!)&>($:&,?
-)&+,$4536
-./012234516718349!:4
#$
!"#$7#8&992)#:&2;)# !"#$<#=#$>#4/&!1#.2&56-#
!"#$%# &'()*#
!"#$3#4/&!1#+'56#
+/)? !2*)/
2,?@)-*/!(*,/#
+,-*#.&/0,1# !2*)/#
##
Lifetime Guarantee
Glacier Water Treatment Systems guarantees this unit to be
free from defects in materials and workmanship and to prod-
uce high quality water of low mineral content and high clarity
for a period of two years(Residential) / one year(Commercial)
from the date of purchase. All stainless steel parts are guar-
anteed for life.
GUARANTEE VSerSALIDATIORD
Service GLACIER
only by Glacier Approved Service DISTILLER
Center
Replacement Parts use ony authorized Glacier Parts
Serial Number
Original Proof of Purchase must accompany all work to be considered for warranty
Purchaser Purchase Date
Address
Serial Number
Address
Submit To: