0 оценок0% нашли этот документ полезным (0 голосов)
138 просмотров1 страница
This document provides preflight, takeoff, cruise, and landing checklists and procedures for the Felis AN-24RV simulation. Key steps include: opening all covers and inserting gear blocks; starting both engines and setting navigation devices; taxiing and taking off with flaps, gear and lights configured appropriately; climbing with gear up to cruise altitude and configuring power levers; beginning descent with appropriate speeds, vertical rate and power settings; and preparing for landing with configurations such as gear and flaps down and lights on.
This document provides preflight, takeoff, cruise, and landing checklists and procedures for the Felis AN-24RV simulation. Key steps include: opening all covers and inserting gear blocks; starting both engines and setting navigation devices; taxiing and taking off with flaps, gear and lights configured appropriately; climbing with gear up to cruise altitude and configuring power levers; beginning descent with appropriate speeds, vertical rate and power settings; and preparing for landing with configurations such as gear and flaps down and lights on.
This document provides preflight, takeoff, cruise, and landing checklists and procedures for the Felis AN-24RV simulation. Key steps include: opening all covers and inserting gear blocks; starting both engines and setting navigation devices; taxiing and taking off with flaps, gear and lights configured appropriately; climbing with gear up to cruise altitude and configuring power levers; beginning descent with appropriate speeds, vertical rate and power settings; and preparing for landing with configurations such as gear and flaps down and lights on.
ALL COVERS REMOVE LIGHTS EXTEND AS REQ GEAR BLOCKS INSERT RADAR SWITCH ON LANDING LIGHTS AS REQ GROUNDING CABLE CONNECT RADAR MODE METEO DOORS OPEN LANDING WEIGHT AND FUEL LOAD NAVIGATION SPEED 300 KMH GROUNDING CABLE REMOVE DME ON, SET GEAR DOWN BOTH VOR ON, SET FLAPS 15 START OF ENGINES BOTH ADF ARK-11 ON, SET SPEED 250 KMH POWER SOURCE ACF FLAPS 38 INVERTOR PO750 ON / UP TAXI SPEED 210 KMH INVERTOR PT1000 ON / UP CONTROLS CHECK TOUCHDOWN MAIN DOORS CLOSE TRANSPONDER STANDBY TOUCHDOWN NOSE FIRE SYSTEM ON GEAR BLOCKS REMOVE RELEASE PROPS OFF NAV LIGHTS ON NOSEWHEEL MODE TAXI BRAKES AS REQ POWER LEVER RV19 10% LIGHTS EXTEND AS REQ RIGHT FUEL PUMPS ON TAXI LIGHTS AS REQ TAXI RIGHT FUEL VALVE OPEN PARKING BRAKE RELEASE NOSEWHEEL MODE TAXI FUEL AND FLOW METERS ON TAXIING < 30 KMH TRANSPONDER OFF FUEL STATUS CHECK BRAKES, GYROS CHECK LANDING LIGHTS OFF RV19 FIRE VALVE OPEN TAXI LIGHTS AS REQ RV19 MAIN SWITCH ON HOLDING POINT SPEED <30 KMH RV19 START SWITCH START TRANSPONDER MODE C FLAPS UP RV19 GROUND COVER OPEN LIGHTS EXTEND AS REQ PRESSURIZATION DUMP RV19 START BUTTON PRESS TAXI LIGHTS OFF ICING SIGNALING OFF DC GENERATOR GS-24 ON LANDING LIGHTS AS REQ LEFT FUEL PUMPS ON ON STAND LEFT FUEL VALVE OPEN ON RUNWAY PARKING BRAKE ON IV41 ON RELEASE PROPS ON MID LIGHTS TAXI OFF POWER LEVERS IDLE SET GYRO LIGHTS EXTEND OFF COVER OF START PANEL OPEN FLAPS 15 GENERATORS OFF START TYPE GROUND NOSEWHEEL MODE TAKEOFF ENG STOP SWITCHES ON START MODE START ELECTRICAL DEVS OFF START ENGINE LEFT TAKEOFF FUEL PUMPS OFF START BUTTON PRESS BRAKES ON FUEL VALVES CLOSE LEFT DC GENERATOR ON POWER LEVERS 80-100% INVERTOR PT1000 OFF LEFT GO GENERATOR ON BRAKES OFF INVERTOR PO750 OFF REPEAT AGAIN FOR RIGHT ENGINE ROTATION VR 190 KMH POWER SOURCE OFF START MODE FAKE GEAR BLOCKS ON START TYPE AIR CLIMB DOORS OPEN START ENGINE OFF GEAR UP COVER OF START PANEL CLOSE GEAR NEUTRAL DC GENERATOR GS-24 OFF NOSEWHEEL OFF RV19 MAIN SWITCH OFF POWER LEVERS 65% RV19 START SWITCH FAKE VERTICAL SPEED 3-7 M/S RV19 GROUND COVER CLOSE SPEED 250 KMH RV19 FIRE VALVE CLOSE FLAPS UP SPEED 300 KMH AFTER START LANDING LIGHTS OFF RELEASE PROPS ON MID LIGHTS EXTEND OFF POWER LEVERS 30% AUTOFEATHER TEST CRUISE POWER LEVERS 0% POWER LEVERS 52% RELEASE PROPS OFF SPEED 350 - 400 HYDRAULIC PRESS 120 kgcm2 AGD BOTH ON DESCENT AGB ON VERTICAL SPEED 5-6 M/S BKK ON SPEED 450 KMH GIK ON POWER LEVERS MINIMUM GPK ON BUZZER OFF ABS ON BOTH UVID AND PRESS SET BEFORE LANDING ICING SIGNALING ON BLEED AIR OFF WND, PITOT, AOA HEAT ON ALTIMETER PRESSURE SET BLEED AIR AUTO RADIO ALTIMETER SET