Академический Документы
Профессиональный Документы
Культура Документы
Conduct Inspection:
Conducted by QA/QC base on standard criteria to ensure quality of RC structure,
compliance of specification and work procedure.
Witness by representative engineer (COW/RE)
Inspection criteria:
Dimension:
i. As per specified in drawing
ii. Squareness
iii. Dimension for opening services
Alignments, plumb and levelness:
i. Verticality with 10mm tolerance
ii. RC wall alignment with 6mm tolerance
iii. Flatness surface
Exposed surface condition (Observation):
i. Honeycomb, crack-line, bulging or wavy
ii. Cold joint surface
iii. Free from piece of formwork, nails, etc after removing formwork
Position of embedment
i. Starter bar position for column, beam, wall, etc
Any wall tie holes to be filled using approved grout materials and method.
Method of curing as per specified
Rectification Work
Quality Inspection
Defects rectification work
Allowed for
must be by specification / subsequent activity
Fail
approved method
Pass
End