Академический Документы
Профессиональный Документы
Культура Документы
What is Superpave?
SUPERPAVE is the result of a $50 million research project conducted by the Strategic Highway
Research Program (SHRP) of the Federal Highway Administration between 1987 and 1993. This
effort was undertaken to develop better tools for designing longer lasting asphalt pavements. The
primary concerns were permanent deformation (e.g. rutting, fatigue cracking) and low temperature
cracking. When SHRP completed its research, Superpave had developed into a system of three
related components:
Perhaps the most important product of the Superpave research was the development of Performance
Graded (PG) asphalt binders. This system classifies binders (asphalts) into grades based on their
performance for pavement temperatures typically encountered. For example, a PG 64-22 binder will
o o
meet performance criteria at pavement temperatures as high as 64 C and as low as -22 C. Using
the Superpave system, mix designers now select asphalt binders to suit the climate and traffic
volumes for specific pavements. All Hot Mix Asphalt producers in New York State use PG binders
for all of their production!
Superpave’s volumetric mix design system balances aggregates, asphalt and voids with the ultimate
goal of producing durable mixes that resist rutting. To do so, designers volumetrically proportion
aggregates and PG asphalts, and then examine mix compaction using a Superpave gyratory
compactor. The gyratory compactor is intended to help predict pavement performance by
simulating the effect of traffic on asphalt pavement in the laboratory. At the same time, the
compacted samples yield information about the volumetric properties of the mix – a strong predictor
of on-grade performance.
While the gyratory compactor is a key tool for predicting pavement performance, other test
equipment and methods are under development. These tests, in combination with sophisticated
modeling software, suggest that further improvements to the Superpave system will evolve over the
coming years.
NYSDOT considered dropping the Marshall Hot Mix Asphalt specifications from the 2002
Standard Specifications since they intend to only specify Superpave designs. Through a mutual
agreement between the industry and DOT, the older mixes will be in the new specification, but only
on a transitional basis. The mixes you’ve been ordering for years will ultimately be discontinued.
Consequently, local governments need to learn more about Superpave and work toward the
development of Superpave designs suited to local pavements.
To this end, this is the first of a series of QUICK BITES information sheets intended to help the
transition from Marshall to Superpave. The sheets will be placed on the CLRP web site
(www.clrp.cornell.edu) and are available from the Cornell Local Roads Program (phone: 607-255-
8033).
Part of the Cornell Local Roads Program’s QUICK BITES Information Sheets
Co-produced by the New York State Department of Transportation (NYSDOT), Cornell Local Roads Program (CLRP)
and New York Construction Materials Association (NYMaterials).
Mix Definitions
Explanation and examples of the terminology used to describe Superpave.
9Friction
Explanation of the different friction demands and requirements of various levels of traffic.
Truck Tickets and the Mix Codes
Explains how to know what is in the truck when it arrives on site.
Tack coat
Describes the importance of and proper use of tack coat.
Segregation
Defines the problem of segregated mix and provide some solutions.
Tenderness
Defines the problem of tenderness during construction and provides some solutions.
Compaction
Explains the importance of good compaction and the different ways to monitor density.
Joints
Explain the importance of good joint construction, joint density and the use of the wedge joint.