Академический Документы
Профессиональный Документы
Культура Документы
Ali
IQRA
University
BS
telecom
Reg #
9222
s.ubaidali@h
Patch Antenna
● Fourth level
● Fifth level
Shape of patch antenna
the patch is generally square, rectangular,
circular, triangular, elliptical or some other
common shape as shown below
Feed Techniques
These methods can be classified into two
categories
Contacting
non-contacting
Proximity coupling
Advantages and
disadvantages
Advantages
Light weight
low volume
Low fabrication cost
Good effiency
Disadvantages
Narrow bandwidth
Non omnidirectional patterns
Degisn a patch antenna
FR 4 substrate Er = 4.4
• Select none
Click to edit Master text styles
Second level
Click Layout ● Third level
● Fourth level
● Fifth level
• Then select
layers >stackup
• Click Addlayer
• Name>groung
• Type>metalizedsi
gnal
• Click >ok
Click to edit Master text styles
Click Addlayer Second level
● Third level
● Fourth level
● Fifth level
Name >signal
Type>signal
Click >ok
Change
material to FR
4 substrate
With thickness
Now click Click to edit Master text styles
project>insert circuit Second level
design ● Third level
● Fourth level
● Fifth level
Then select >none
Click
>schematic>layer>
stackup
And repeat the step as
done in EM planer
design
Now select
circuit>add model
data>add substrate
Select
Circuit >TRL>microstrip>single>
Then select FR 4 then click OK
Zo=82.46
E=90
Frequency=2.45
Click on synthesis
Click next
Select F then click Edit
Select linear count
2 to 3 Ghz 10 count
Then click Add
Then ok and then click finish
Click to edit Master text styles
Second level
● Third level
● Fourth level
● Fifth level
Click on Analysis
Right click on
Then select
Then click ok
Click to edit Master text styles
Second level
● Third level
● Fourth level
● Fifth level
Now go EM planer design
Then DRAW a rectangle double click on rectangle
Uncheck the 2 pt discription
Then click ok
Again double click on rectangle
Place the value of width and height
Which we have find earlier
W=37.26mm
H=28.60mm
Click to edit Master text styles
Second level
● Third level
● Fourth level
● Fifth level
Then DRAW a rectangle double click on
rectangle
W=1.13847
P=17.2786
Click to edit Master text styles
Second level
● Third level
● Fourth level
● Fifth level
Click edit>select edges
then click on one side of transmission line
Then add a port throw
Excitation>add port
● Fourth level
● Fifth level
Right click on analysis>setup 1>sweep1>analyze
Right click on
● Fourth level
● Fifth level
Click to edit Master text styles
Second level
● Third level
● Fourth level
● Fifth level
The End