Академический Документы
Профессиональный Документы
Культура Документы
Items Needed
Starts at 1:26 in video
Directions
● Set (2) of the 2x3x21-3/4 boards 5 ft apart with the 2" side facing down.
(Starts at 2:53 in video)
● Lay (4)1"x6"x5' boards across the Set (2) of the 2x3x21-3/4 boards (Starts at
3:01 in video)
● Check that everything is square and flush with the top of the 2x3s. Note,
there will be a small overhang at one end, this is for the bottom assembly to
meet up with it (Starts at 3:04 in video)
● Drill the pilot holes, then screw to attach. (Starts at 3:08 in video)
● Add the third 2x3x21-3/4, centering it on the 5' boards (starts at 3:17 in
video)
● Set (2) of the 2x3x22s about 3' apart with the 3" side facing down. (Starts at
3:28 in video)
● Lay down the other (4) 5' boards across. (Starts at 3:38 in video)
● Check that everything is square and flush
● Drill the pilot holes and screw the boards together
● On the short sides, measure 2-1/2" in and mark on both sides. There should
be a 17" gap between the marks (Starts at 3:41 in video)
● Lineup (1) 2x3x17 with the marks, drill the pilot hole and screw to attach.
(Starts at 3:48 in video)
● Measure and mark 2-1/2" with the other 2x3x17 on the other side.
The bottom section of the frame is complete.
Garden Answers DIY Garden Bed
Visit Garden Answer Youtube Channel
Watch DIY: Garden Bed Video
● Flip the bottom piece to attach the back piece. (Starts at 3:48 in video)
● Line up the back piece to the bottom piece, making sure everything is square
and flush.
● Where the 5' board of the back meets the 2x3s, drill the pilot hole, then
screw together. (Starts at 3:59 in video)
● Flip the frame and drill the pilot hole and screw through the 5' boards into
the 2x3s. (Starts at 4:04 in video)
● With the frame right-side up, begin attaching the 5'1-1/2" boards. (Starts at
4:41 in video)
● Square and flush, then drill the pilot holes and screw to attach, using the
2x3s as the attaching point.
● Flip the box, and attach the feet/casters to the bottom four corners per the
accessories's instructions.
● Staple the liner to the inside edges of the boxes, then trim to fit. (Starts at
6:07 in video)
● Push the liner through the drain holes, then pierce to allow drainage. (Starts
at 6:17 in video)