Академический Документы
Профессиональный Документы
Культура Документы
Tags:
Glutes
Back
Powerlifting & Strength
Before lifters learned the term "posterior chain" they used to just say they
were doing "back work." It was what strength athletes did to create balance
and stability for the competitive lifts. They did rows, lat pulldowns, work for the
spinal erectors and rear delts, etc. All good stuff.
But simply throwing in rows, pulldowns, and face-pulls won't cut it. When you
look at the kinetic chain and the muscles that help stabilize each part of it, you
should know what each of those muscle groups do and how to strengthen
them for maximum stability.
Calves
Most people don't put enough effort into calf training. They say, "You're either
born with big calves or not. It's all genetics." Yes, calves are stubborn. But so
is your girlfriend, and you haven't given up on her yet.
It's not your muscle belly length or insertion points. It's that you don't know
how to train your calves in a way that'll get them to respond. The calves play a
part in helping the hamstrings with knee flexion. The lesser-known muscles of
the deep flexor group also work to maintain the medial arch and prevent
pronation of the ankle which (along with a weak glute medius) can contribute
to "knee cave" or valgus collapse.
When that happens, the hips and glutes play a smaller role in the squat, and
adductors end up taking the brunt of the tension to perform the movement.
Ideally, you'd get all of those muscle groups involved. That way the load is
distributed throughout a larger area and adequate tension distribution is
achieved. But if the ankles over-pronate or if they come off the floor, then a
tight Achilles tendon and inflexible calves are usually part of the problem. So
you need to increase flexibility in the calves, strengthen them, and get them to
grow.
What to Do
Use the standing calf raise. Oh, you tried that already? Probably not the right
way. For starters, the Achilles tendon is the thickest tendon in the body and is
built for dynamic/explosive movement. So when you get on a standing calf
raise machine and bounce up and down, the Achilles has no problem
performing that work, taking most of the tension off the calves. In order to shift
that work to the calves, you need to remove as much of the stretch reflex as
possible and focus on maximally lengthening and shortening the muscles.
Try 4 sets of 12 reps, rotating through different calf exercises each time you
work them. Do this at least twice a week.
If you've been a bouncing all this time, then be prepared to actually feel your
calves working for the first time ever. Also be prepared for a tremendous
amount of soreness. The extended time in the stretch position will also help
take care of a tight Achilles.
Hamstrings
Most people only do two movements for the hammies: leg curls and stiff-
legged deadlifts. While this is a great combination, it's limiting. It only trains
them in the sagittal plane. That may be okay for someone who's only focused
on aesthetics, but if we're talking about performance and building stabilization
then the hams should be worked in the transverse plane.
The hamstrings bend and stabilize the knee, among other things. They also
play a major role in reducing and controlling force and the deceleration of a
movement. They're predominantly fast twitch, and thus respond very positively
to eccentric-based training (negatives). In fact, a lack of eccentric strength in
the hams is the main culprit for hamstring injuries, not just the strength
imbalance between them and the quads.
The factors that need to be addressed here are knee flexion in the sagittal
plane with full hip extension, and the transverse plane to address deceleration
strength and stability. Both require an emphasis on the eccentric.
What to Do
Don't allow your hips to come up off the bench. It negates a complete
shortening of the hamstrings. To distribute the greatest amount of tension
directly onto the hamstrings, you must have hip extension into the leg curl pad
so that the hams can reach a fully contracted state in the top position. So
push your hips as hard as possible into the pad to make sure this is
happening.
An easy way to increase the eccentric loading (without having to get someone
to push down on the leg curl during the negative part of the rep), is to do the
concentric or lifting part of the rep with both legs, then the lowering part with
one leg. After you hit failure with the single-leg eccentrics, continue the set by
using both legs and a controlled negative.
Another Option
For hamstrings, also do "10 and 2" stationary lunges. You can put a barbell on
your back for these, but start with bodyweight at first. If you're weak moving
through this range of motion then you could end up straining any one of the
muscle groups involved.
Pretend you're standing on a clock. Step with your left leg to the 10 o'clock
position and perform a controlled eccentric and powerful concentric on each
rep. Then with the right leg, step to 2 o'clock and do the same. Do 4 sets of 10
reps for each leg.
Glutes
The glutes are made up of the gluteus maximus, medius, and minimus. All
three perform a function in stabilizing the hip and pelvis. The gluteus max is
mainly responsible for hip extension. The medius and minimus are
responsible for hip abduction, which also helps with stabilization at the knee
and ankle. The glute max's primary function involves movement of the hip,
while the glute medius and minimus work together to help stabilize the hip.
What to Do
Since the hamstrings work with the gluteus maximus for hip extension, it's
important to choose a movement where they perform synergistically to create
balance. The banded good morning does the job.
Why not use a bar? First, it's easy to do wrong. You see guys load the bar
with back-breaking weights, then barely bend over and squat down slightly.
This sucks because the hamstrings don't lengthen enough in this position, and
hip flexion is minimal.
Second, with a barbell the resistance is high at the bottom quarter of the
movement and minimal at the top quarter. Ideally you'd want the resistance to
increase as the concentric is performed so that tension doesn't diminish as
much during the completion of hip extension. Banded good mornings fix the
problem.
You can put bands around the end of the bar, but I like to attach one to the
rack so that it's providing resistance at the waist during the movement. It also
acts as a cue to "get your hips through."
Keep your knees barely bent during this movement, and use a controlled
eccentric and a somewhat powerful concentric for each rep. You need to think
about pushing your butt out and into the wall behind you while maintaining this
"soft knee" position.
Hold the top portion of the movement for a second before starting the next
rep. You shouldn't look like you're dry humping the band. Do 4 sets of 12 reps.
These muscles help abduct the hip and act as a stabilizer for the pelvis,
allowing the glute max to perform the dynamic portions of a movement, like
when you're doing something on one leg. And don't say you're not into
unilateral work. Otherwise you'd never walk, sprint, or lunge.
Perform a split squat, rear leg on a bench behind you, then only come about
3/4ths of the way up. Hold that position for 3 seconds before lowering again.
You can use a dumbbell or bodyweight only. That all depends on your level of
strength/development. However, I'd recommend using progressive overload
and working your way up to using the heaviest dumbbell you can while
maintaining great form. Do 3 sets of 8 reps with a 3 second isometric hold.
Erectors
While the erectors can get thicker and stronger through isometric contractions
in movements that are hip dominant, to make them as strong as possible they
also need additional work.
What to Do
Ideally you'd perform back raises on equipment that supports the abs so that
you can roll the spine over it safely in the eccentric portion of the movement,
before performing the concentric phase.
Back Raise
Allow your lower back to round slightly, then go into the concentric phase up
to the point where you're back into a neutral spine position. Don't hyperextend
the spine. Do 3 sets of 10-12 reps once a week using light weight. Sound too
easy? Well, this area already gets an enormous amount of isometric work
during other exercises, so don't overdo it.
Lower Traps
A weak lower trapezius can be the culprit for many issues related to pain or
poor movement. The lower traps aid in lifting and stabilizing the shoulder
through its entire 180 degrees of flexion.
But scapular depression is required to initiate and activate the traps, and
lifters tend to do more exercises that emphasis scapular retraction. Low bar
squatting? Retract the scaps. Bench pressing? Retract the scaps. Rowing?
Retract the scaps. Then we sit all day in a hunched position allowing the lower
traps to become stretched and weak. Bad combination.
Weak lower traps mean that the upper traps will hog most of the work. Plus if
the lower traps can't do their job, the lumbars will also jump in and help
provide stability. This makes you more likely to get in lumbar extension to
make up for the inability to hold good position.
What to Do
You don't need a lot of weight for this. The point here is to get them to fire and
create stability in that area of the muscular chain so that they can do their job.
Do 4 sets of 12 reps.
Despite the fact that lots of guys do rows, their execution limits the amount of
tension this area gets. Even many bodybuilders lack back development
despite doing a ton of work for it.
The initiation of the exercise plays a huge role in tension distribution. So if you
start a row with elbow flexion first, you're not having the mid-back do the brunt
of the work. There's very little movement happening in either scapula, but a
heck of a lot of elbow flexion going on.
This particular muscular group can be strengthened at the same time you do
other back work. The middle traps and rhomboids tend to work during
scapular retraction. This is important for strength athletes because these
muscles work isometrically to hold the scapula in retraction during movements
like deadlifts and farmers walks.
To get the mid traps and rhomboids to do the work and get stronger in their
role as thoracic stabilizers, initiate rowing movements by emphasizing
scapular retraction first. Then hold that position isometrically before bringing
elbow flexion into play to finish shortening those muscles in the contracted
position.
What to Do
Do scap rows. You can do them with virtually any row set up. Ideally you'd do
it with a chest-supported row so that your focus can be on what the scapula
are doing without using energy to hold the torso in position.
Scap Rows
Start by retracting the scapula and holding that isometric position for a few
seconds, then finish the movement by pulling with the arms and getting spinal
extension. Arch your back as you complete the movement.
Do these regularly and you should be able to go back to doing rows without
the isometric hold before elbow flexion. You'll have trained that movement
pattern so that you naturally start rowing by initiating with scapular retraction
rather than elbow flexion. Do 5 sets of 8 reps.
Developing posterior chain strength won't just come from rows and pulldowns.
It requires the strength for stability and mobility. Weak points can't really be
addressed until you hone your technique first.
If you're struggling with locking out your deadlift, then doing a ton of back work
may be futile if your real problem is that you can't get your hips through due to
lack of external hip rotation. So even if you address mobility and weak points,
if you've spent years performing movements in a particular fashion you'll need
to re-learn proper technique.
What to Do
For the lats, do rack pull-ups.
Rack Pull-Ups
For rear delts do 100-rep band pull-aparts.
BAND PULL-APARTS
These will help with mobility, weak points, technique, and re-patterning.
Programming
You can do all of these movements together on a different day than squats
and deadlifts, or you can do them after those movements. You can even split
them up across two different training sessions for the week (upper body
dominant and lower body dominant). What's most important is to actually go
through all of them and identify the ones you're weakest at. This will tell you
what you need to work on.