Академический Документы
Профессиональный Документы
Культура Документы
Course Outline:
Spur, Helical, Bevel and Worm Gears (10 Sessions)
Geometry and nomenclature of Spur, Helical, Bevel and Worm Gears
Forces in Spur, Helical, worm and Bevel gears.
Stress calculations in spur, helical and bevel gears.
Material strength calculations for gears.
Rating method in Wormsets.
Design of Flywheels (3 Sessions)
Energy variations in a rotating system
Determining the flywheel inertia
Stresses in flywheels
Failure criteria
Rolling Element Bearings (3 Sessions)
Types of Rolling Element Bearings.
Failure of Rolling Element Bearings.
Selection of Rolling Element Bearings.
• Basic dynamic load rating
• Basic static load rating
• Combined radial and thrust loads
• Calculation procedures
Sliding Contact Bearings (4 Sessions)
Full-Film Lubrications
Boundary Lubrications
Hydrodynamic Theory of Lubrication
Design of Hydrodynamic Bearings
Design of Clutch / Brakes (5 Sessions)
Different types of clutches and designing concepts
Different types of brakes and designing concepts
Design of Power Screws (3 Sessions)
Introduction to power screws
Stresses in power screws
Efficiency of power screws
Applications of power screws
Page 1 of 2
Capital University of Science & Technology
Department of Mechanical Engineering (Updated 2019 curriculum)
After the successful completion of this course, students would be able to:
Page 2 of 2