Академический Документы
Профессиональный Документы
Культура Документы
MSP
Medium Static Pressure
Slim Line
Ceiling Concealed Ducted Split Systems
53QDMT 12-18-24-30-36-42-48-60
Heat Pump
Rev.(0)
(0)- -2014
2014
ISO 9001 : 2008 ISO 14001 : 2004 BS OHSAS 18001 : 2007
03500000 Certificate No.: QS-5519HH Certificate No : 12 104 30334 TMS Certificate No : 12 116 30334 TMS Rev.
TABLE OF CONTENTS
PAGE NO.
1. KEY FEATURES 1
3. UNIT MODELS 8
5. TECHNICAL SPECIFICATIONS 10
7. PHYSICAL DATA 15
8. REFRIGERATION CYCLES 25
0
1. Key Features
1
Key Features (Cont.)
2
Key Features (Cont.)
3
Key Features (Cont.)
4
Key Features (Cont.)
1 2 3 4 5 6 7
The display panel id indoor unit contains the following function indicators :
1 MANUAL Button
* This button is used to operate the unit temporarily in case you misplace
the remote control or its batteries are exhausted.
* Once you push temporary button, the air conditioner will run in such order :
Auto, Forced cool, off and back to Auto
AUTO
The OPERATION lamp is lit, and the air conditioner will run under AUTO mode.
The remote controller operation is enabled to operate according to the received signal.
FORCED COOL
The OPERATION lamp flashes, the air conditioner will turn to AUTO after it is enforced to cool
with a wind speed of HIGH for 30 minutes. The remote controller operation is disabled.
OFF
The OPERATION lamp goes off. The air conditioner is OFF while the remote controller operation
is enabled.
5
Key Features (Cont.)
The electronic printed circuit board in the indoor unit is equipped with
smart self diagnostic function which automatically stops the operation of
the air conditioner in case of a malfunction.
When the system is on and in a malfunction, leds status and error code on the display panel of
indoor unit ( all sizes ) refer to malfunction reason
EEPROM malfunction E7
Pump temperature sensor malfunction
( option ) E5
Water-level alarm malfunction E8
Refrigerant leak X X EC
= Light = Flash at 5Hz = OFF
Leds status on the PCB of outdoor unit only sizes 36K – 42K – 48K and 60K ( 3Ph ) refers to malfunction reason
Protection function operates if a malfunction happens in the outdoor unit as below by leds of PCB of outdoor unit as follows:
Defect LED 1 LED 2 LED 3
No defect off off on
Phase reversal on off on
Overload of current off on on
Phase loss on on on
NOTES
1- Prior to the malfunction repair, disconnect the electrical mains supply by moving the circuit breaker to OFF position.
2- After repairing the malfunction, connect the electrical main supply by moving the circuit breaker to ON position
and operate the air conditioner by using the wireless remote control or using wired room controller.
6
2. Unit Model Identification
53 Q D M T 18 - 7 1 8
Source
8 = Miraco Sourced Product
Control Type
1 = Standard Wired Control
Power Supply
7 = 220-240V / 1ph / 50Hz
5 = 380-420V / 3ph / 50Hz
Climate Type
T = High Ambient
Family Type
D = Ducted
System Type
Q = Heat Pump
Numeric Code
53 = Complete Split System
42 = Indoor Unit
38 = Outdoor Unit
7
3. Unit Models
8
4. Ducted Split System Description
9
5. Technical Specifications
System type Heat pump
System model 53QDMT12-718 53QDMT18-718 53QDMT24-718 53QDMT30-718
Indoor unit model 42QDMT12-718 42QDMT18-718 42QDMT24-718 42QDMT30-718
Outdoor unit model 38QDMT12-718 38QDMT18-718 38QDMT24-718 38QDMT30-718
Btu/hr 13000 20500 25700 30000
Cooling capacity
kW 3.81 6.01 7.53 8.79
Rated input - cooling W 1265 1985 2415 3515
Rated current - cooling A 5.9 9.2 11.2 16.3
Btu/wh 10.28 10.33 10.64 8.53
E.E.R. – Cooling
W/W 3.01 3.03 3.12 2.50
Heating capacity Btu/hr 12700 19000 23500 31000
kW 3.72 5.57 6.89 9.09
Power input (Outdoor + Indoor) - Heating W 1045 1695 2125 2755
Current input (Outdoor + Indoor)-Heating A 5.1 7.8 10.2 12.3
C.O.P - Heating W/W 3.56 3.28 3.24 3.30
Indoor unit 42QDMT12-718 42QDMT18-718 42QDMT24-718 42QDMT30-718
Nominal air flow (high/med/low) cfm 440 / 290 / 250 530 / 350 / 295 755 / 495 / 430 910 / 730 / 645
( @ 0 external static pressure ) 3
m /hr 678 / 492 / 424 898 / 593 / 500 1298 / 839 / 729 1542 / 1237 / 1093
in.wg 0.16 0.24 0.24 0.32
Indoor maximum external static pressure
Pa 40 60 60 80
Sound Pressure (high/med/low) dB(A) 38.1 / 29.4 / 25.6 42.4 / 33.0 / 29.2 44.9 / 39.0 / 38.0 46.8 / 42.4 / 40.8
Net Dimensions (W×H×D) mm 700 × 210 × 635 920 × 210 × 635 920 × 270 × 635 1140 × 270 × 775
Net Weight kg 20 24 28 41
Outdoor unit 38QDMT12-718 38QDMT18-718 38QDMT24-718 38QDMT30-718
Tropical compressor type Rotary Rotary Rotary Rotary
Refrigerant type / Coupler type R22 / Flare R22 / Flare R22 / Flare R22 / Flare
Sound pressure dB(A) 56 57 62 62
Net Dimensions (W×H×D) mm 780 × 540 × 250 760 × 590 × 285 860 × 570 × 350 860 × 570 × 350
Net Weight kg 34 42 57.8 62.4
Liquid 1/4" 1/4” 3/8” 3/8”
Pipe connection sizes ( inch )
Gas 1/2" 1/2” 5/8” 3/4”
Maximum pipe length m 10 20 20 25
Maximum height difference m 4 10 10 10
Condensate drain hose diameter mm 25 25 25 25
Power supply V/ph/Hz 220-240/1/50 220-240/1/50 220-240/1/50 220-240/1/50
* Cooling Capacity, Dehumidification and Energy Efficiency Ratio (EER) @ 35ºC ambient are based on EN 14511 / ISO 5151 Standards at
conditions :
27/19ºC db/wb Indoor Temperature. High Air Flow
230 volts power supply (for sizes 12K-18K-24K-30K).
* Systems work in cooling at high ambient temperature up to 52ºC
* Heating Capacity and Coefficient Of Performance (COP) are based on EN 14511 / ISO 5151 Standards at operating conditions :
20ºC db Indoor Temperature 7/6ºC db/wb Outdoor Temperature. High Air Flow
230 volts power supply (for sizes 12K-18K-24K-30K).
* For detailed air flow, static pressure and sound performance, see next pages
* For detailed cooling and heating performance, see next pages
* Carrier is committed to continuously improving its products according to national and international standards
to ensure the highest quality and reliability standards, and to meet market regulations and requirements.
All specifications subject to change without prior notice according to Carrier policy of continuous development.
10
Technical Specifications (Cont.)
System type Heat pump
System model 53QDMT36-718 53QDMT36-518 53QDMT42-718 53QDMT42-518
Indoor unit model 42QDMT36-718 42QDMT36-718 42QDMT42-718 42QDMT42-718
Outdoor unit model 38QDMT36-718 38QDMT36-518 38QDMT42-718 38QDMT42-518
Btu/hr 37300 37000 40000 40850
Cooling capacity
kW 10.92 10.84 11.72 11.97
Rated input - cooling W 4240 4105 4555 4245
Rated current - cooling A 21.2 7.2 22.5 7.2
Btu/wh 8.8 9.01 8.78 9.62
E.E.R. – Cooling
W/W 2.57 2.64 2.57 2.82
Heating capacity Btu/hr 38000 36000 37500 38950
kW 11.14 10.55 10.99 11.41
Power input (Outdoor + Indoor) - Heating W 3360 3200 3200 2975
Current input (Outdoor + Indoor)-Heating A 17.7 5.9 16.9 5.4
C.O.P - Heating W/W 3.3 3.30 3.43 3.83
Indoor unit 42QDMT36-718 42QDMT36-718 42QDMT42-718 42QDMT42-718
Nominal air flow (high/med/low) cfm 1080 / 730 / 645 1080 / 730 / 645 1370 / 880 / 715 1260 / 880 / 715
( @ 0 external static pressure ) 3
m /hr 1831/1237/1093 1831/1237/1093 2322/1492/1212 2136/1492/1212
in.wg 0.32 0.32 0.40 0.40
Indoor maximum external static pressure
Pa 80 80 100 100
Sound Pressure (high/med/low) dB(A) 48.6 / 42.4 / 40.8 48.6 / 42.4 / 40.8 48.2 / 40.6 / 38.4 44.1 / 40.6 / 38.4
Net Dimensions (W×H×D) mm 1140 × 270 × 775 1140 x 270 x 775 1200 × 300 × 865 1200 x 300 x 865
Net Weight kg 41 41 47 47
Outdoor unit 38QDMT36-718 38QDMT36-518 38QDMT42-718 38QDMT42-518
Tropical compressor type Reciprocating Scroll Reciprocating Scroll
Refrigerant type / Coupler type R22 / Flare R22 / Flare R22 / Flare R22 / Flare
Sound pressure dB(A) 65 65
Net Dimensions (W×H×D) mm 860 × 720 × 350 860 × 720 × 350
Net Weight kg 81 81
Liquid 3/8” 3/8” 3/8” 3/8”
Pipe connection sizes ( inch )
Gas 3/4” 3/4” 3/4” 3/4”
Maximum pipe length m 25 25 25 25
Maximum height difference m 10 10 10 10
Condensate drain hose diameter mm 25 25 25 25
Power supply V/ph/Hz 220-240/1/50 380-420/3/50 220-240/1/50 380-420/3/50
* Cooling Capacity, Dehumidification and Energy Efficiency Ratio (EER) @ 35ºC ambient are based on EN 14511 / ISO 5151 Standards at
conditions :
27/19ºC db/wb Indoor Temperature. High Air Flow
230 volts power supply (for sizes 36K-42K). 400 volts power supply (for sizes 36K-42K).
* Systems work in cooling at high ambient temperature up to 52ºC
* Heating Capacity and Coefficient Of Performance (COP) are based on EN 14511 / ISO 5151 Standards at operating conditions :
20ºC db Indoor Temperature 7/6ºC db/wb Outdoor Temperature. High Air Flow
230 volts power supply (for sizes 36K-42K). 400 volts power supply (for sizes 36K-42K).
* For detailed air flow, static pressure and sound performance, see next pages
* For detailed cooling and heating performance, see next pages
* Carrier is committed to continuously improving its products according to national and international standards
to ensure the highest quality and reliability standards, and to meet market regulations and requirements.
All specifications subject to change without prior notice according to Carrier policy of continuous development.
11
Technical Specifications (Cont.)
System type Heat pump
System model 53QDMT48-518 53QDMT60-518
Indoor unit model 42QDMT48-718 42QDMT60-718
Outdoor unit model 38QDMT48-518 38QDMT60-518
Btu/hr 44500 52300
Cooling capacity
kW 13.04 15.33
Rated input - cooling W 4200 4725
Rated current - cooling A 7.5 8.3
Btu/wh 10.59 11.07
E.E.R. – Cooling
W/W 3.10 3.24
Heating capacity Btu/hr 47500 55300
kW 13.92 16.21
Power input (Outdoor + Indoor) - Heating W 3795 4155
Current input (Outdoor + Indoor)-Heating A 6.7 7.6
C.O.P - Heating W/W 3.67 3.90
Indoor unit 42QDMT48-718 42QDMT60-718
Nominal air flow (high/med/low) cfm 1370 / 880 / 715 1470 / 1020 / 860
( @ 0 external static pressure ) 3
m /hr 2322 / 1492 / 1212 2492 / 1729 / 1458
in.wg 0.40 0.40
Indoor maximum external static pressure
Pa 100 100
Sound Pressure (high/med/low) dB(A) 48.2 / 40.6 / 38.4 50.4 / 44.3 / 41.5
Net Dimensions (W×H×D) mm 1200 × 300 × 865 1200 × 300 × 865
Net Weight kg 47 47
Outdoor unit 38QDMT48-518 38QDMT60-518
Tropical compressor type Scroll Scroll
Refrigerant type / Coupler type R22 / Flare R22 / Flare
Sound pressure dB(A) 68 69
Net Dimensions (W×H×D) mm 860 × 1150 × 350 860 × 1150 × 350
Net Weight kg 90 92
Liquid 3/8” 3/8”
Pipe connection sizes ( inch )
Gas 3/4” 3/4”
Maximum pipe length m 30 30
Maximum height difference m 15 15
Condensate drain hose diameter mm 25 25
Power supply V/ph/Hz 380-420/3/50 380-420/3/50
* Cooling Capacity, Dehumidification and Energy Efficiency Ratio (EER) @ 35ºC ambient are based on EN 14511 / ISO 5151 Standards at
conditions :
27/19ºC db/wb Indoor Temperature. High Air Flow
400 volts power supply (for sizes 48K-60K).
* Systems work in cooling at high ambient temperature up to 52ºC
* Heating Capacity and Coefficient Of Performance (COP) are based on EN 14511 / ISO 5151 Standards at operating conditions :
20ºC db Indoor Temperature 7/6ºC db/wb Outdoor Temperature. High Air Flow
400 volts power supply (for sizes 48K-60K).
* For detailed air flow, static pressure and sound performance, see next pages
* For detailed cooling and heating performance, see next pages
* Carrier is committed to continuously improving its products according to national and international standards
to ensure the highest quality and reliability standards, and to meet market regulations and requirements.
All specifications subject to change without prior notice according to Carrier policy of continuous development.
12
6. Dimensions & Weights
6.1 Ducted Indoor Units Dimensions (mm) & Weights
Weight Supply air Return air Size of
Indoor Unit Outline dimesions
opening size opening size Mounted lug
Model Kg
A B C D E F G H I J K L M
42QDMT12 20 700 210 635 570 65 493 35 119 595 200 80 740 350
42QDMT18 24 920 210 635 570 65 713 35 119 815 200 80 960 350
42QDMT24 28 920 270 635 570 65 713 35 179 815 260 20 960 350
42QDMT30 42 1140 270 775 710 65 933 35 179 1035 260 20 1180 490
42QDMT36 42 1140 270 775 710 65 933 35 179 1035 260 20 1180 490
42QDMT42 48 1200 300 865 800 80 968 40 204 1094 288 45 1240 500
42QDMT48 48 1200 300 865 800 80 968 40 204 1094 288 45 1240 500
42QDMT60 48 1200 300 865 800 80 968 40 204 1094 288 45 1240 500
Outline dimensions (mm)
Supply air opening size
G
H
B
E F D
A C
Back return air opening size
I Air Filter
Air Filter
13
Dimensions & Weights (Cont.)
6.2 Outdoor Units Dimensions & Weights
DIMENSIONS (mm)
860 305
38QDMT36 720 65
665 384
38QDMT42 720 65
665
371
350
860
Weight
Model Kg
38QDMT48 1150
91
38QDMT60 92
14
7. Physical Data
Outdoor Unit Model 38QDMT12-718
Indoor Unit Model 42QDMT12-718
Power supply Ph-V-Hz 1Ph, 220-240V∼, 50Hz
Btu/h 13000
Capacity
Kw 3.81
Input W 1265
Cooling
Rated current A 5.9
Btu/wh 10.28
EER
W/W 3.01
Btu/h 12700
Capacity
Kw 3.72
Heating Input W 1045
Rated current A 5.1
COP W/W 3.56
Model PH210M2A-4FTS1
Type Rotary Tropical
Brand GMCC / Toshiba
Capacity ( @ 220/240V ) ± 5% Btu/h 12760 / 12860
Input ( @ 220/240V ) ± 5% W 1181 / 1280
Compressor Rated current ( @ 220/240V ) ± 5% A 5.62 / 6.16
Locked rotor Amp( + 10% ) A 33.6
Thermal protector position Internal
Capacitor uF / V 35 uF / 370 V
Refrigerant oil SUNISO 4G5D or NM56EP or Eqv
oil charge ml 440
Model YDK24-6-12
Brand Welling
Outdoor fan motor Input W 1/10
Capacitor uF / V 2.5 uF / 450 V
Speed r/min 865
a.Number of rows 1
b.Tube pitch(a)× row pitch(b) mm 21 x 13.37
c.Fin spacing mm 1.6
Outdoor coil d.Fin type (code) Uncoated Aluminum
e.Tube outside dia.and type mm Ø 7, inner groove tube
f.Coil length × height × width mm 750 x 518 x 13.37
g.Number of circuits 2
Restrictor Size Cool / Heat C 0.041 / H 0.035
3
Outdoor air flow cfm (m /h) 1062 ( 1800 )
Outdoor noise level dB(A) 56
Dimension (W*H*D) mm 780 x 540 x 250
Outdoor unit Packing (W*H*D) mm 875 x 560 x 310
Net/Gross weight Kg 34 / 37
Model YSK24-4C
Brand Welling
Indoor fan motor Input W 62 / 42 / 36
Capacitor uF 2 uF / 450 V
Speed(Hi/Mi/Lo) r/min 1180 / 830 / 730
a.Number of rows 3
b.Tube pitch(a)× row pitch(b) mm 21 x 13.37
c.Fin spacing mm 1.5
Indoor coil d.Fin type (code) Precoated Hydrophilic Aluminum
e.Tube outside dia.and type mm Ø 7, inner groove tube
f.Coil length × height × width mm 515 x 252 x 40.11
g.Number of circuits 4
cfm 440 / 290 / 250
Indoor air flow (Hi/Mi/Lo) @ 0 external static pressure 3
m /hr 678 / 492 / 424
Indoor maximum external static pressure Pa 40
Indoor noise level (Hi/Mi/Lo) dB(A) 38.1 / 29.4 / 25.6
Dimension (W*H*D) (body) mm 700 x 210 x 635
Indoor unit Packing (W*H*D) (body) mm 915 x 290 x 655
Net/Gross weight (body) kg 20 / 25
Refrigerant type / quantity g R22 / 760
Design pressure MPa 2.94 / 1.0
Liquid side/ Gas side mm(inch) Ø 6.35 / Ø 12.7 ( 1/4" / 1/2" )
Refrigerant piping Max. refrigerant pipe length m 10
Max. difference in level m 4
Drainage water pipe outside diameter mm ODØ 25
Control type Wired Control / Wireless Remote Control
Operation temperature Ԩ 17 ~ 30
Ambient temperature (cooling/heating) Ԩ 21 ~ 52 / 2 ~ 24
15
Physical Data (Cont.)
Outdoor Unit Model 38QDMT18-718
Indoor Unit Model 42QDMT18-718
Power supply Ph-V-Hz 1Ph, 220-240V∼, 50Hz
Btu/h 20500
Capacity
Kw 6.01
Input W 1985
Cooling
Rated current A 9.2
Btu/wh 10.33
EER
W/W 3.03
Btu/h 19000
Capacity
Kw 5.57
Heating Input W 1695
Rated current A 7.8
COP W/W 3.28
Model PH340X3C-4KTS1
Type Rotary Tropical
Brand GMCC / Toshiba
Capacity ( @ 220/240V ) ± 5% Btu/h 20640 / 20860
Input ( @ 220/240V ) ± 5% W 1890 / 2050
Compressor Rated current ( @ 220/240V ) ± 5% A 8.75 / 9.30
Locked rotor Amp( + 10% ) A 53
Thermal protector position Internal
Capacitor uF / V 60 / 440
Refrigerant oil SUNISO 4GSD or NM56EP or Eqv
Oil charge ml 620
Model YDK48-6H (A)
Brand Welling
Outdoor fan motor Output HP 1/10
Capacitor uF / V 3 / 450
Speed r/min 890
a.Number of rows 2
b.Tube pitch(a)× row pitch(b) mm 21 x 13.37
c.Fin spacing mm 1.8
Outdoor coil d.Fin type (code) Uncoated Aluminum
e.Tube outside dia.and type mm Ø 7, inner groove tube
f.Coil length × height × width mm 846 x 561 x 26.7
g.Number of circuits 4
Restrictor Size Cool / Heat C 0.052 / H 0.041
3
Outdoor air flow cfm (m /h) 1475 ( 2500 )
Outdoor noise level dB(A) 57
Dimension (W*H*D) mm 760 x 590 x 285
Outdoor unit Packing (W*H*D) mm 870 x 600 x 340
Net/Gross weight Kg 42 / 46
Model YSK68-4P
Brand Welling
Indoor fan motor Input W 107 / 65 / 52
Capacitor uF 3.5 / 450
Speed(Hi/Mi/Lo) r/min 1150 / 800 / 700
a.Number of rows 3
b.Tube pitch(a)× row pitch(b) mm 21×13.37
c.Fin spacing mm 1.5
Indoor coil d.Fin type (code) Hydrophilic aluminum
e.Tube outside dia.and type mm Ф7, inner groove tube
f.Coil length × height × width mm 735×252×40.11
g.Number of circuits 4
cfm 530 / 350 / 295
Indoor air flow (Hi/Mi/Lo) @ 0 external static pressure 3
m /hr 898 / 593 / 500
Indoor maximum external static pressure Pa 50
Indoor noise level (Hi/Mi/Lo) dB(A) 42.8 / 33.4 / 29.6
Dimension (W*H*D) (body) mm 920 x 210 x 635
Indoor unit Packing (W*H*D) (body) mm 1135 x 290 x 655
Net/Gross weight (body) kg 24 / 29
Refrigerant type / quantity g R22 / 1000
Design pressure MPa 2.94 / 1.0
Liquid side/ Gas side mm(inch) Ф6.35 / Ф12.7 ( 1/4" / 1/2" )
Refrigerant piping Max. refrigerant pipe length m 20
Max. difference in level m 10
Drainage water pipe outside diameter mm ODØ 25
Control type Wired Control / Wireless Remote Control
Operation temperature Ԩ 17 ~ 30
Ambient temperature (cooling/heating) Ԩ 21 ~ 52 / 2 ~ 24
16
Physical Data (Cont.)
Outdoor Unit Model 38QDMT24-718
Indoor Unit Model 42QDMT24-718
Power supply Ph-V-Hz 1Ph, 220-240V∼, 50Hz
Btu/h 25700
Capacity
Kw 7.53
Input W 2415
Cooling
Rated current A 11.2
Btu/wh 10.64
EER
W/W 3.12
Btu/h 23500
Capacity
Kw 6.89
Heating Input W 2125
Rated current A 10.2
COP W/W 3.24
Model 2V40S225BUB
Type Rotary Tropical
Brand Panasonic
Capacity ( @ 220/240V ) ± 5% Btu/h 23130 / 23235
Input ( @ 220/240V ) ± 5% W 2255 / 2370
Compressor Rated current ( @ 220/240V ) ± 5% A 10.5 / 10.5
Locked rotor Amp( + 10% ) A 79
Thermal protector position Internal
Capacitor uF / V 60 / 440
Refrigerant oil ATMOS NM56M or SUNISO 4GDID
Oil charge ml 750
Model YDK75-6T
Brand Welling
Outdoor fan motor Output HP 1/10 ( 75 )
Capacitor uF / V 5 uF / 370 V
Speed r/min 860
a.Number of rows 2
b.Tube pitch(a)× row pitch(b) mm 25.4 x 22
c.Fin spacing mm 1.8
Outdoor coil d.Fin type (code) Uncoated Aluminum
e.Tube outside dia.and type mm Ø 9.52, inner groove tube
f.Coil length × height × width mm 832 x 561 x 44
g.Number of circuits 3
Restrictor Size Cool / Heat C 0.062 / H 0.052
3
Outdoor air flow cfm (m /h) 1390 ( 2355 )
Outdoor noise level dB(A) 62
Dimension (W*H*D) mm 860 x 575 x 350
Outdoor unit Packing (W*H*D) mm 960 x 600 x 415
Net/Gross weight Kg 57.7 / 61.7
Model YSK74-4P
Brand Welling
Indoor fan motor Input W 163/93/75
Capacitor uF 3.5uF/450V
Speed(Hi/Mi/Lo) r/min 1000/750/680
a.Number of rows 4
b.Tube pitch(a)× row pitch(b) mm 21×13.37
c.Fin spacing mm 1.5
Indoor coil d.Fin type (code) Precoated Hydrophilic Aluminum
e.Tube outside dia.and type mm Ф7, inner groove tube
f.Coil length × height × width mm 735 x 252 x 53.48
g.Number of circuits 6
cfm 755 / 495 / 430
Indoor air flow (Hi/Mi/Lo) @ 0 external static pressure 3
m /hr 1298 / 839 / 729
Indoor maximum external static pressure Pa 50
Indoor noise level (Hi/Mi/Lo) dB(A) 45.3 / 39.4 / 38.4
Dimension (W*H*D) (body) mm 920 x 270 x 635
Indoor unit Packing (W*H*D) (body) mm 1135 x 350 x 655
Net/Gross weight (body) kg 28 / 33
Refrigerant type / quantity g R22 / 1500
Design pressure MPa 2.94 / 1.0
Liquid side/ Gas side mm(inch) Ф9.52 / Ф15.9 ( 3/8" / 5/8" )
Refrigerant piping Max. refrigerant pipe length m 20
Max. difference in level m 10
Drainage water pipe outside diameter mm ODØ 25
Control type Wired Control / Wireless Remote Control
Operation temperature Ԩ 17 ~ 30
Ambient temperature (cooling/heating) Ԩ 21 ~ 52 / 2 ~ 24
17
Physical Data (Cont.)
Outdoor Unit Model 38QDMT30-718
Indoor Unit Model 42QDMT30-718
Power supply Ph-V-Hz 1Ph, 220-240V∼, 50Hz
Btu/h 30000
Capacity
Kw 8.79
Input W 3515
Cooling
Rated current A 16.3
Btu/wh 8.53
EER
W/W 2.50
Btu/h 31000
Capacity
Kw 9.09
Heating Input W 2755
Rated current A 12.3
COP W/W 3.30
Model NHT52VBET
Type Rotary Tropical
Brand Mitsubishi
Capacity ( @ 220/240V ) ± 5% Btu/h 31800 / 32070
Input ( @ 220/240V ) ± 5% W 9320 / 9400
Compressor Rated current ( @ 220/240V ) ± 5% A 14.1 / 14.1
Locked rotor Amp( + 10% ) A 86 / 94
Thermal protector position Internal
Capacitor uF / V 60 uF / 440 V
Refrigerant oil Diamond MS 56 or Eqv
Oil charge ml 1300
Model YDK75-6T
Brand Welling
Outdoor fan motor Output HP 1/10 ( 75 )
Capacitor uF / V 5 uF / 370 V
Speed r/min 860
a.Number of rows 2
b.Tube pitch(a)× row pitch(b) mm 25.4 x 22
c.Fin spacing mm 1.8
Outdoor coil d.Fin type (code) Uncoated Aluminum
e.Tube outside dia.and type mm Ø 9.52, inner groove tube
f.Coil length × height × width mm 832 x 561 x 44
g.Number of circuits 3
Restrictor Size Cool / Heat C 0.082 / H 0.057
3
Outdoor air flow cfm (m /h) 1390 ( 2355 )
Outdoor noise level dB(A) 62
Dimension (W*H*D) mm 860 x 575 x 350
Outdoor unit Packing (W*H*D) mm 960 x 600 x 415
Net/Gross weight Kg 61.4 / 65.4
Model YSK140-4P
Brand Welling
Indoor fan motor Input W 168 /
Capacitor uF 10 uF / 450 V
Speed(Hi/Mi/Lo) r/min 790 / 210 / 640
a.Number of rows 4
b.Tube pitch(a)× row pitch(b) mm 21 x 13.37
c.Fin spacing mm 1.5
Indoor coil d.Fin type (code) Precoated Hydrophilic Aluminum
e.Tube outside dia.and type mm Ø 7, inner groove tube
f.Coil length × height × width mm 955 x 336 x 53.48
g.Number of circuits 8
cfm 910 / 730 / 645
Indoor air flow (Hi/Mi/Lo) @ 0 external static pressure 3
m /hr 1542 / 1237 / 1093
Indoor maximum external static pressure Pa 80
Indoor noise level (Hi/Mi/Lo) dB(A) 46.8 / 42.4 / 40.8
Dimension (W*H*D) (body) mm 1140 x 270 x 775
Indoor unit Packing (W*H*D) (body) mm 1355 x 350 x 795
Net/Gross weight (body) kg 42 / 46
Refrigerant type / quantity g R22 / 1650
Design pressure MPa 2.94 / 1.0
Liquid side/ Gas side mm(inch) Ф9.52 / Ф19 ( 3/8" / 3/4" )
Refrigerant piping Max. refrigerant pipe length m 20
Max. difference in level m 10
Drainage water pipe outside diameter mm ODØ 25
Control type Wired Control / Wireless Remote Control
Operation temperature Ԩ 17 ~ 30
Ambient temperature (cooling/heating) Ԩ 21 ~ 52 / 2 ~ 24
18
Physical Data (Cont.)
Outdoor Unit Model 38QDMT36-718
Indoor Unit Model 42QDMT36-718
Power supply Ph-V-Hz 1Ph, 220-240V∼, 50Hz
Btu/h 37600
Capacity
Kw 11.02
Input W 4195
Cooling
Rated current A 20.9
Btu/wh 8.96
EER
W/W 2.63
Btu/h 37500
Capacity
Kw 10.99
Heating Input W 3220
Rated current A 16.8
COP W/W 3.41
Model CR47KQM-PFZ
Type Reciprocating Tropical
Brand Copeland
Capacity ( @ 220V ) ± 5% Btu/h 40700
Input ( @ 220V ) ± 5% W 3950
Compressor Rated current ( @ 220V ) ± 5% A 20
Locked rotor Amp ( @ 220V ) A 110
Thermal protector position Internal
Capacitor uF / V 60 uF / 440 V
Refrigerant oil Mineral
Oil charge ml 1330
Model YDK150-4H
Brand Welling
Outdoor fan motor Output HP 1/6 ( 127 )
Capacitor uF / V 7.5 uF / 440 V
Speed r/min 1030
a.Number of rows 2
b.Tube pitch(a)× row pitch(b) mm 25.4 x 19.05
c.Fin spacing mm 1.7
Outdoor coil d.Fin type (code) Uncoated Aluminum
e.Tube outside dia.and type mm Ф9.52,inner grooved tube
f.Coil length × height × width mm 832 x 713 x 38.1
g.Number of circuits 4
Restrictor Size Cool / Heat C 0.071 / H 0.058
3
Outdoor air flow cfm (m /h) 2080 ( 3526 )
Outdoor noise level dB(A) 65
Dimension (W*H*D) mm 860 x 720 x 350
Outdoor unit Packing (W*H*D) mm 960 x 745 x 415
Net/Gross weight Kg 80 / 84
Model YSK140-4P
Brand Welling
Indoor fan motor Input W 291 / 168 / 138
Capacitor uF 10 uF / 450 V
Speed(Hi/Mi/Lo) r/min 1070 / 790 / 710
a.Number of rows 4
b.Tube pitch(a)× row pitch(b) mm 21 x 13.37
c.Fin spacing mm 1.5
Indoor coil d.Fin type (code) Precoated Hydrophilic Aluminum
e.Tube outside dia.and type mm Ф7,Inner grooved tube
f.Coil length × height × width mm 955 x 336 x 53.48
g.Number of circuits 8
cfm 1080 / 730 / 645
Indoor air flow (Hi/Mi/Lo) @ 0 external static pressure 3
m /hr 1831 / 1237 / 1093
Indoor maximum external static pressure Pa 80
Indoor noise level (Hi/Mi/Lo) dB(A) 48.6 / 42.4 / 40.8
Dimension (W*H*D) (body) mm 1140 x 270 x 775
Indoor unit Packing (W*H*D) (body) mm 1355 x 350 x 795
Net/Gross weight (body) kg 42 / 46
Refrigerant type / quantity g R22 / 1800
Design pressure MPa 2.94/1.0
Liquid side/ Gas side mm(inch) Ф9.52 / Ф19 ( 3/8" / 3/4" )
Refrigerant piping Max. refrigerant pipe length m 25
Max. difference in level m 10
Drainage water pipe outside diameter mm ODØ 25
Control type Wired Control / Wireless Remote Control
Operation temperature Ԩ 17 ~ 30
Ambient temperature (cooling/heating) Ԩ 21 ~ 52 / 2 ~ 24
19
Physical Data (Cont.)
Outdoor Unit Model 38QDMT36-518
Indoor Unit Model 42QDMT36-718
Power supply Ph-V-Hz 3Ph, 380-420V∼, 50Hz
Btu/h 37000
Capacity
Kw 10.83
Input W 4105
Cooling
Rated current A 7.2
Btu/wh 9.01
EER
W/W 2.64
Btu/h 36000
Capacity
Kw 10.55
Heating Input W 2100
Rated current A 5.9
COP W/W 3.30
Model C-SB303H8A
Type Scroll Tropical
Brand Sanyo
Capacity ( @ 220V ) ± 5% Btu/h 40260
Input ( @ 220V ) ± 5% W 3650
Compressor Rated current ( @ 220V ) ± 5% A 6.5
Locked rotor Amp ( @ 220V ) A 48
Thermal protector position Internal
Capacitor uF / V SAY56T
Refrigerant oil 1700 / 1600
Oil charge ml YDK150-4H
Model YDK150-4H
Brand Welling
Outdoor fan motor Output HP 1/6 ( 127 )
Capacitor uF / V 7.5 uF / 440 V
Speed r/min 1030
a.Number of rows 2
b.Tube pitch(a)× row pitch(b) mm 25.4 x 19.05
c.Fin spacing mm 1.7
Outdoor coil d.Fin type (code) Uncoated Aluminum
e.Tube outside dia.and type mm Ф9.52,inner grooved tube
f.Coil length × height × width mm 832 x 713 x 38.1
g.Number of circuits 4
Restrictor Size Cool / Heat C 0.088 / H 0.064
3
Outdoor air flow cfm (m /h) 2080 ( 3526 )
Outdoor noise level dB(A) 65
Dimension (W*H*D) mm 8
Outdoor unit Packing (W*H*D) mm 960 x 745 x 415
Net/Gross weight Kg 80 / 84
Model YSK140-4P
Brand Welling
Indoor fan motor Input W 291 / 168 / 138
Capacitor uF 10 uF / 450 V
Speed(Hi/Mi/Lo) r/min 1070 / 790 / 710
a.Number of rows 4
b.Tube pitch(a)× row pitch(b) mm 21 x 13.37
c.Fin spacing mm 1.5
Indoor coil d.Fin type (code) Precoated Hydrophilic Aluminum
e.Tube outside dia.and type mm Ф7,Inner grooved tube
f.Coil length × height × width mm 955 x 336 x 53.48
g.Number of circuits 8
cfm 1080 / 730 / 645
Indoor air flow (Hi/Mi/Lo) @ 0 external static pressure 3
m /hr 1831 / 1237 / 1093
Indoor maximum external static pressure Pa 80
Indoor noise level (Hi/Mi/Lo) dB(A) 48.6 / 42.4 / 40.8
Dimension (W*H*D) (body) mm 1140 x 270 x 775
Indoor unit Packing (W*H*D) (body) mm 1355 x 350 x 795
Net/Gross weight (body) kg 42 / 46
Refrigerant type / quantity g R22 / 1800
Design pressure MPa 2.94/1.0
Liquid side/ Gas side mm(inch) Ф9.52 / Ф19 ( 3/8" / 3/4" )
Refrigerant piping Max. refrigerant pipe length m 25
Max. difference in level m 10
Drainage water pipe outside diameter mm ODØ 25
Control type Wired Control / Wireless Remote Control
Operation temperature Ԩ 17 ~ 30
Ambient temperature (cooling/heating) Ԩ 21 ~ 52 / 2 ~ 24
20
Physical Data (Cont.)
Outdoor Unit Model 38QDMT42-718
Indoor Unit Model 42QDMT42-718
Power supply Ph-V-Hz 1Ph, 220-240V∼, 50Hz
Btu/h 40000
Capacity
Kw 11.72
Input W 4555
Cooling
Rated current A 22.5
Btu/wh 8.78
EER
W/W 2.57
Btu/h 37500
Capacity
Kw 10.98
Heating Input W 3200
Rated current A 16.9
COP W/W 3.43
Model CR47KQM-PFZ
Type Reciprocating Tropical
Brand Copeland
Capacity ( @ 220V ) ± 5% Btu/h 40700
Input ( @ 220V ) ± 5% W 3950
Compressor Rated current ( @ 220V ) ± 5% A 20
Locked rotor Amp ( @ 220V ) A 110
Thermal protector position Internal
Capacitor uF / V 60 uF / 440 V
Refrigerant oil Mineral
Oil charge ml 1330
Model YDK150-4H
Brand Welling
Outdoor fan motor Output HP ( W ) 1/6 ( 127 )
Capacitor uF / V 7.5 uF / 440 V
Speed r/min 1030
a.Number of rows 2
b.Tube pitch(a)× row pitch(b) mm 25.4 x 19.05
c.Fin spacing mm 1.7
Outdoor coil d.Fin type (code) Uncoated Aluminum
e.Tube outside dia.and type mm Ф9.52,inner grooved tube
f.Coil length × height × width mm 832 x 713 x 38.1
g.Number of circuits 4
Restrictor Size Cool / Heat C 0.077 / H 0.066
3
Outdoor air flow cfm (m /h) 2080 ( 3526 )
Outdoor noise level dB(A) 65
Dimension (W*H*D) mm 860 x 720 x 350
Outdoor unit Packing (W*H*D) mm 960 x 745 x 415
Net/Gross weight Kg 81 / 85
Model YSK170-4P
Brand Welling
Indoor fan motor Input W 356/201/152
Capacitor uF 10uF/450V
Speed(Hi/Mi/Lo) r/min 1070/750/650
a.Number of rows 4
b.Tube pitch(a)× row pitch(b) mm 21×13.37
c.Fin spacing mm 1.5
Indoor coil d.Fin type (code) Precoated Hydrophilic Aluminum
e.Tube outside dia.and type mm Ф7,Inner grooved tube
f.Coil length × height × width mm 1030×378×53.48
g.Number of circuits 8
cfm 1370 / 880 / 715
Indoor air flow (Hi/Mi/Lo) @ 0 external static pressure 3
m /hr 2322 / 1492 / 1212
Indoor maximum external static pressure Pa 100
Indoor noise level (Hi/Mi/Lo) dB(A) 48.2 / 40.6 / 38.4
Dimension (W*H*D) (body) mm 1200 x 300 x 865
Indoor unit Packing (W*H*D) (body) mm 1385 x 373 x 920
Net/Gross weight (body) kg 48 / 56
Refrigerant type / quantity g R22 / 1850
Design pressure MPa 2.94 / 1.0
Liquid side/ Gas side mm(inch) Ф9.52 / Ф19 ( 3/8" / 3/4" )
Refrigerant piping Max. refrigerant pipe length m 30
Max. difference in level m 15
Drainage water pipe outside diameter mm ODØ 25
Control type Wired Control / Wireless Remote Control
Operation temperature Ԩ 17 ~ 30
Ambient temperature (cooling/heating) Ԩ 21 ~ 52 / 2 ~ 24
21
Physical Data (Cont.)
Outdoor Unit Model 38QDMT42-518
Indoor Unit Model 42QDMT42-718
Power supply Ph-V-Hz 3Ph, 380-420V∼, 50Hz
Btu/h 43000
Capacity
Kw 12.60
Input W 4424
Cooling
Rated current A 7.6
Btu/wh 9.72
EER
W/W 2.85
Btu/h 41000
Capacity
Kw 12.02
Heating Input W 3092
Rated current A 5.7
COP W/W 3.89
Model C-SB303H8A
Type Scroll Tropical
Brand Sanyo
Capacity ( @ 220V ) ± 5% Btu/h 40260
Input ( @ 220V ) ± 5% W 3650
Compressor Rated current ( @ 220V ) ± 5% A 6.5
Locked rotor Amp ( @ 220V ) A 48
Thermal protector position Internal
Capacitor uF / V SAY56T
Refrigerant oil 1700 / 1600
Oil charge ml 1330
Model YDK150-4H
Brand Welling
Outdoor fan motor Output HP ( W ) 1/6 ( 127 )
Capacitor uF / V 7.5 uF / 440 V
Speed r/min 1030
a.Number of rows 2
b.Tube pitch(a)× row pitch(b) mm 25.4 x 19.05
c.Fin spacing mm 1.7
Outdoor coil d.Fin type (code) Uncoated Aluminum
e.Tube outside dia.and type mm Ф9.52,inner grooved tube
f.Coil length × height × width mm 832 x 713 x 38.1
g.Number of circuits 4
Restrictor Size Cool / Heat C 0.079 / H 0.068
3
Outdoor air flow cfm (m /h) 2080 ( 3526 )
Outdoor noise level dB(A) 65
Dimension (W*H*D) mm 860 x 720 x 350
Outdoor unit Packing (W*H*D) mm 960 x 745 x 415
Net/Gross weight Kg 81 / 85
Model YSK170-4P
Brand Welling
Indoor fan motor Input W 356/201/152
Capacitor uF 10uF/450V
Speed(Hi/Mi/Lo) r/min 1070/750/650
a.Number of rows 4
b.Tube pitch(a)× row pitch(b) mm 21×13.37
c.Fin spacing mm 1.5
Indoor coil d.Fin type (code) Precoated Hydrophilic Aluminum
e.Tube outside dia.and type mm Ф7,Inner grooved tube
f.Coil length × height × width mm 1030×378×53.48
g.Number of circuits 8
cfm 1370 / 880 / 715
Indoor air flow (Hi/Mi/Lo) @ 0 external static pressure 3
m /hr 2322 / 1492 / 1212
Indoor maximum external static pressure Pa 100
Indoor noise level (Hi/Mi/Lo) dB(A) 48.2 / 40.6 / 38.4
Dimension (W*H*D) (body) mm 1200 x 300 x 865
Indoor unit Packing (W*H*D) (body) mm 1385 x 373 x 920
Net/Gross weight (body) kg 48 / 56
Refrigerant type / quantity g R22 / 1850
Design pressure MPa 2.94 / 1.0
Liquid side/ Gas side mm(inch) Ф9.52 / Ф19 ( 3/8" / 3/4" )
Refrigerant piping Max. refrigerant pipe length m 30
Max. difference in level m 15
Drainage water pipe outside diameter mm ODØ 25
Control type Wired Control / Wireless Remote Control
Operation temperature Ԩ 17 ~ 30
Ambient temperature (cooling/heating) Ԩ 21 ~ 52 / 2 ~ 24
22
Physical Data (Cont.)
Outdoor Unit Model 38QDMT48-518
Indoor Unit Model 42QDMT48-718
Power supply Ph-V-Hz 3Ph, 380-420V∼, 50Hz
Btu/h 44500
Capacity
Kw 13.04
Input W 4200
Cooling
Rated current A 7.5
Btu/wh 10.60
EER
W/W 3.10
Btu/h 47500
Capacity
Kw 13.92
Heating Input W 3795
Rated current A 6.7
COP W/W 3.67
Model C-SB303H8A
Type Scroll Tropical
Brand Sanyo
Capacity ( @ 380 V ) ± 5% Btu/h 40260
Input ( @ 380 V ) ± 5% W 3650
Compressor
Rated current ( @ 380 V ) ± 5% A 6.5
Locked rotor Amp ( @ 380 V ) A 48
Thermal protector position Internal
Refrigerant oil uF / V SAY56T
Oil initial charge / recharge ml 1700 / 1600
Model YDK150-4H
Brand Welling
Outdoor fan motor (1) Output HP ( W ) 1/6 ( 127 )
Capacitor uF / V 7.5 / 440
Speed r/min 1030
Model YDK150-4H
Brand Welling
Outdoor fan motor (2) Output HP ( W ) 1/6 ( 127 )
Capacitor uF / V 7.5 / 440
Speed r/min 1030
a.Number of rows 2
b.Tube pitch(a)× row pitch(b) mm 22×19.05
c.Fin spacing mm 1.6
Outdoor coil d.Fin type (code) Hydrophilic aluminum
e.Tube outside dia.and type mm Ф7.94,inner grooved tube
f.Coil length × height × width mm 837×1100×38.1
g.Number of circuits 8
Restrictor Size Cool / Heat C 0.069 / H 0.054
Outdoor air flow cfm (m3/h) 4160 ( 7055 )
Outdoor noise level dB(A) 68
Dimension (W*H*D) mm 860 x 1150 x 350
Outdoor unit Packing (W*H*D) mm 995 x 1170 x 415
Net/Gross weight Kg 90 / 95
Model YSK170-4P
Brand Welling
Input W 356/201/152
Indoor fan motor Capacitor uF 10uF/450V
Speed(Hi/Mi/Lo) r/min 1070/750/650
a.Number of rows 4
b.Tube pitch(a)× row pitch(b) mm 21×13.37
c.Fin spacing mm 1.5
d.Fin type (code) Precoated Hydrophilic Aluminum
Indoor coil e.Tube outside dia.and type mm Ф7,Inner grooved tube
f.Coil length × height × width mm 1030×378×53.48
g.Number of circuits 8
Model C-SB303H8A
cfm 1370 / 880 / 715
Indoor air flow (Hi/Mi/Lo) @ 0 external static pressure
m3/hr 2322 / 1492 / 1212
Indoor maximum external static pressure Pa 100
Indoor noise level (Hi/Mi/Lo) dB(A) 48.2 / 40.6 / 38.4
Dimension (W*H*D) (body) mm 1200 x 300 x 865
Indoor unit Packing (W*H*D) (body) mm 1385 x 373 x 920
Net/Gross weight (body) kg 48 / 56
Refrigerant type / quantity g R22 / 3900
Design pressure MPa 2.94/1.0
Liquid side/ Gas side mm(inch) Ф9.52 / Ф19 ( 3/8" / 3/4" )
Refrigerant piping Max. refrigerant pipe length m 30
Max. difference in level m 15
Drainage water pipe outside diameter mm ODØ 25
Control type Wired Control / Wireless Remote Control
Operation temperature Ԩ 17 ~ 30
Ambient temperature (cooling/heating) Ԩ 21 ~ 52 / 2 ~ 24
23
Physical Data (Cont.)
Outdoor Unit Model 38QDMT60-518
Indoor Unit Model 42QDMT60-718
Power supply Ph-V-Hz 3Ph, 380-420V∼, 50Hz
Btu/h 52300
Capacity
Kw 15.33
Input W 4725
Cooling
Rated current A 8.3
Btu/wh 11.07
EER
W/W 3.24
Btu/h 55300
Capacity
Kw 16.21
Heating Input W 4155
Rated current A 7.6
COP W/W 3.90
Model ZR61KH-TFD-522
Type Scroll Tropical
Brand Copeland
Capacity ( @ 380 V ) ± 5% Btu/h 51100
Input ( @ 380 V ) ± 5% W 4440
Compressor
Rated current ( @ 380 V ) ± 5% A 7.8
Locked rotor Amp ( @ 380 V ) A 97
Thermal protector position Internal
Refrigerant oil uF / V Blended White – Mineral Oil
Oil initial charge / recharge ml 1774 / 1656
Model YDK150-4H
Brand Welling
Outdoor fan motor (1) Output HP ( W ) 1/6 ( 127 )
Capacitor uF / V 7.5 / 440
Speed r/min 1030
Model YDK150-4H
Brand Welling
Outdoor fan motor (2) Output HP ( W ) 1/6 ( 127 )
Capacitor uF / V 7.5 / 440
Speed r/min 1030
a.Number of rows 2
b.Tube pitch(a)× row pitch(b) mm 22×19.05
c.Fin spacing mm 1.6
Outdoor coil d.Fin type (code) Hydrophilic Aluminum
e.Tube outside dia.and type mm Ф7.94,inner grooved tube
f.Coil length × height × width mm 837×1100×38.1
g.Number of circuits 8
Restrictor Size Cool / Heat C 0.085 / H 0.068
Outdoor air flow cfm (m3/h) 4160 ( 7055 )
Outdoor noise level dB(A) 69
Dimension (W*H*D) mm 900×1167×340
Outdoor unit Packing (W*H*D) mm 1032×1307×443
Net/Gross weight Kg 105/110
Model YSK180-4P
Brand Welling
Indoor fan motor Input W 355 / 223 / 173
Capacitor uF 10 uF / 450 V
Speed(Hi/Mi/Lo) r/min 1080 / 830 / 710
a.Number of rows 4
b.Tube pitch(a)× row pitch(b) mm 21 x 13.37
c.Fin spacing mm 1.5
Indoor coil d.Fin type (code) Precoated Hydrophilic Aluminum
e.Tube outside dia.and type mm Ф7,Inner grooved tube
f.Coil length × height × width mm 1030 x 378 x 53.48
g.Number of circuits 8
cfm 1470 / 1020 / 860
Indoor air flow (Hi/Mi/Lo) @ 0 external static pressure
m3/hr 2492 / 1729 / 1458
Indoor maximum external static pressure Pa 100
Indoor noise level (Hi/Mi/Lo) dB(A) 50.4 / 44.3 / 41.5
Dimension (W*H*D) (body) mm 1200 x 300 x 865
Indoor unit Packing (W*H*D) (body) mm 1385 x 373 x 920
Net/Gross weight (body) kg 48/56
Refrigerant type / quantity g R22 / 2750
Design pressure MPa 2.94 / 1.0
Liquid side/ Gas side mm(inch) Ф9.52 / Ф19 ( 3/8" / 3/4" )
Refrigerant piping Max. refrigerant pipe length m 30
Max. difference in level m 15
Drainage water pipe outside diameter mm ODØ 25
Control type Wired Control / Wireless Remote Control
Operation temperature Ԩ 17 ~ 30
Ambient temperature (cooling/heating) Ԩ 21 ~ 52 / 2 ~ 24
24
8. Refrigeration Cycles
Ducted Split System
53QDMT12-718 Heat Pump
220-240V / 1Ph / 50Hz
42QDMT12-718
INDOOR UNIT
Indoor Coil
T2 Indoor Coil
Temp. sensor
T1 Air return
temperature sensor
Centrifugal Blowers
Connecting
Gas Liquid
Refrigerant
1/2" 1/4"
Piping Lines
Gas Liquid
Service Valve Service Valve
Reversing Valve
Compressor 38QDMT12-718
Rotary Tropical
GMCC / Toshiba
PH210M2A-4FTS1
Outdoor Coil
T3 Outdoor
Coil Temp.
sensor
Restrictor
C 0.041
OUTDOOR UNIT H 0.035
Propeller Fan
25
Refrigeration Cycles (Cont.)
Ducted Split System
53QDMT18-718 Heat Pump
220-240V / 1Ph / 50Hz
42QDMT18-718
INDOOR UNIT
Indoor Coil
T2 Indoor Coil
Temp. sensor
T1 Air return
temperature sensor
Centrifugal Blowers
Connecting
Gas Refrigerant Liquid
1/2" 1/4"
Piping Lines
Gas Liquid
Service Valve Service Valve
Reversing Valve
Compressor
Rotary Tropical
GMCC / Toshiba
PH340G2C-4KTS1 38QDMT18-718
Outdoor Coil
T3 Outdoor
Coil Temp.
sensor
Restrictor
C 0.041
OUTDOOR UNIT H 0.035
Propeller Fan
26
Refrigeration Cycles (Cont.)
Ducted Split System
53QDMT24-718 Heat Pump
220-240V / 1Ph / 50Hz
42QDMT24-718
INDOOR UNIT
Indoor Coil
T2 Indoor Coil
Temp. sensor
T1 Air return
temperature sensor
Centrifugal Blowers
Connecting
Gas Liquid
Refrigerant
5/8" 3/8"
Piping Lines
Gas Liquid
Service Valve Service Valve
Reversing Valve
Compressor
Rotary Tropical
Panasonic
2V40S225BUB
38QDMT24-718
Outdoor Coil
T3 Outdoor
Coil Temp.
sensor
Restrictor
C 0.062
H 0.052
OUTDOOR UNIT Propeller Fan
27
Refrigeration Cycles (Cont.)
Ducted Split System
53QDMT30-718 Heat Pump
220-240V / 1Ph / 50Hz
42QDMT30-718
INDOOR UNIT
Indoor Coil
T2 Indoor Coil
Temp. sensor
T1 Air return
temperature sensor
Centrifugal Blowers
Connecting Liquid
Gas
Refrigerant 3/8"
3/4"
Piping Lines
Gas Liquid
Service Valve Service Valve
Reversing Valve
Compressor
Rotary Tropical
Mitsubishi
NHT52VBET
T3 Outdoor
Coil Temp.
sensor
Restrictor
C 0.082
OUTDOOR UNIT H 0.057
Propeller Fan
28
Refrigeration Cycles (Cont.)
Ducted Split System
53QDMT36-718 Heat Pump
220-240V / 1Ph / 50Hz
42QDMT36-718
INDOOR UNIT
Indoor Coil
T2 Indoor Coil
Temp. sensor
T1 Air return
temperature sensor
Centrifugal Blowers
Connecting
Gas Refrigerant Liquid
3/4" Piping Lines 3/8"
Gas Liquid
Service Valve Service Valve
Reversing Valve
Accumulator
Compressor
Reciprocating Tropical
Copeland
CR47KQM-PFZ
38QDMT36-718
Outdoor Coil
T3 Outdoor
Coil Temp.
sensor
Restrictor
C 0.071
H 0.058
OUTDOOR UNIT Propeller Fan
29
Refrigeration Cycles (Cont.)
Ducted Split System
53QDMT36-518 Heat Pump
380-420V / 3Ph / 50Hz
42QDMT36-718
INDOOR UNIT
Indoor Coil
T2 Indoor Coil
Temp. sensor
T1 Air return
temperature sensor
Centrifugal Blowers
Connecting
Gas Refrigerant Liquid
3/4" Piping Lines 3/8"
Gas Liquid
Service Valve Service Valve
Reversing Valve
Accumulator
Compressor
Scroll Tropical
Sanyo
C-SB303H8A
38QDMT36-518
Outdoor Coil
T3 Outdoor
Coil Temp.
sensor
Restrictor
C 0.071
H 0.058
OUTDOOR UNIT Propeller Fan
30
Refrigeration Cycles (Cont.)
Ducted Split System
53QDMT42-718 Heat Pump
220-240V / 1Ph / 50Hz
42QDMT42-718
INDOOR UNIT
Indoor Coil
T2 Indoor Coil
Temp. sensor
T1 Air return
temperature sensor
Centrifugal Blowers
Connecting
Gas Refrigerant Liquid
3/4" Piping Lines 3/8"
Gas Liquid
Service Valve Service Valve
Reversing Valve
Accumulator
Compressor
Reciprocating Tropical
Copeland
CR47KQM-PFZ
38QDMT42-718
Outdoor Coil
T3 Outdoor
Coil Temp.
sensor
Restrictor
C 0.077
H 0.066
OUTDOOR UNIT Propeller Fan
31
Refrigeration Cycles (Cont.)
Ducted Split System
53QDMT42-518 Heat Pump
380-420V / 3Ph / 50Hz
42QDMT42-718
INDOOR UNIT
Indoor Coil
T2 Indoor Coil
Temp. sensor
T1 Air return
temperature sensor
Centrifugal Blowers
Connecting
Gas Refrigerant Liquid
3/4" Piping Lines 3/8"
Gas Liquid
Service Valve Service Valve
Reversing Valve
Accumulator
Compressor
Scroll Tropical
Sanyo
C-SB303H8A
38QDMT42-518
Outdoor Coil
T3 Outdoor
Coil Temp.
sensor
Restrictor
C 0.077
H 0.066
OUTDOOR UNIT Propeller Fan
32
Refrigeration Cycles (Cont.)
Ducted Split System
53QDMT48-518 Heat Pump
380-420V / 3Ph / 50Hz
42QDMT48-718
INDOOR UNIT
Indoor Coil
T2 Indoor Coil
Temp. sensor
T1 Air return
temperature sensor
Centrifugal Blowers
Connecting Liquid
Gas
Refrigerant 3/8"
3/4"
Piping Lines
Gas Liquid
Service Valve Service Valve
Reversing Valve
Accumulator
Compressor
Scroll Tropical
Sanyo
C-SB303H8A
T3 Outdoor
Coil Temp.
sensor
Restrictor
C 0.085
H 0.068
OUTDOOR UNIT Propeller Fan
33
Refrigeration Cycles (Cont.)
Ducted Split System
53QDMT60-518 Heat Pump
380-420V / 3Ph / 50Hz
42QDMT60-718
INDOOR UNIT
Indoor Coil
T2 Indoor Coil
Temp. sensor
T1 Air return
temperature sensor
Centrifugal Blowers
Connecting
Gas Refrigerant Liquid
3/4" Piping Lines 3/8"
Gas Liquid
Service Valve Service Valve
Reversing Valve
Accumulator
Compressor
Scroll Tropical
Copeland
ZR61KH-TFD-522
Outdoor Coil
38QDMT60-518
T3 Outdoor
Coil Temp.
sensor
Restrictor
C 0.085
H 0.068
OUTDOOR UNIT Propeller Fan
34
9. External Static Pressure Versus Air Flow Data
9.1 External Static Pressure versus Air Flow
35
External Static Pressure Versus Air Flow Data (Cont.)
External Static Pressure versus Air Flow (Cont.)
Super High Speed 1080 1036 1005 976 947 915 883 851 819
(reserved)
1831 1756 1703 1654 1605 1551 1497 1442 1388
36
External Static Pressure Versus Air Flow Data (Cont.)
External Static Pressure versus Air Flow (Cont.)
37
External Static Pressure Versus Air Flow Data (Cont.)
External Static Pressure versus Air Flow (Cont.)
cfm cfm cfm cfm cfm cfm cfm cfm cfm cfm cfm
Air Flow 3 3 3 3 3 3 3 3 3 3 3
m /h m /h m /h m /h m /h m /h m /h m /h m /h m /h m /h
1370 1333 1300 1255 1223 1187 1151 1115 1079 1043 1007
Super High Speed
2322 2259 2203 2127 2073 2012 1951 1890 1829 1768 1707
1260 1223 1190 1145 1113 1077 1041 1005 969 933 897
High Speed (reserved)
2136 2073 2017 1941 1886 1825 1764 1703 1642 1581 1520
880 835 803 770 733 693 653 613 573 533 493
Medium Speed
1492 1415 1361 1305 1242 1175 1107 1039 971 903 836
715 668 636 594 548 491 434 377 320 263 206
Low Speed
1212 1132 1078 1007 929 832 736 639 542 446 349
The actual factory connected speeds are Super High – Medium – Low
Reserved High speed can be used in the field as per the requirements.
cfm cfm cfm cfm cfm cfm cfm cfm cfm cfm cfm
Air Flow 3 3 3 3 3 3 3 3 3 3 3
m /h m /h m /h m /h m /h m /h m /h m /h m /h m /h m /h
1370 1333 1300 1255 1223 1187 1151 1115 1079 1043 1007
Super High Speed
2322 2259 2203 2127 2073 2012 1951 1890 1829 1768 1707
1260 1223 1190 1145 1113 1077 1041 1005 969 933 897
High Speed (reserved)
2136 2073 2017 1941 1886 1825 1764 1703 1642 1581 1520
880 835 803 770 733 693 653 613 573 533 493
Medium Speed
1492 1415 1361 1305 1242 1175 1107 1039 971 903 836
715 668 636 594 548 491 434 377 320 263 206
Low Speed
1212 1132 1078 1007 929 832 736 639 542 446 349
The actual factory connected speeds are Super High – Medium – Low
Reserved High speed can be used in the field as per the requirements.
38
External Static Pressure Versus Air Flow Data (Cont.)
External Static Pressure versus Air Flow (Cont.)
cfm cfm cfm cfm cfm cfm cfm cfm cfm cfm cfm
Air Flow 3 3 3 3 3 3 3 3 3 3 3
m /h m /h m /h m /h m /h m /h m /h m /h m /h m /h m /h
1370 1333 1300 1255 1223 1187 1151 1115 1079 1043 1007
Super High Speed
2322 2259 2203 2127 2073 2012 1951 1890 1829 1768 1707
1260 1223 1190 1145 1113 1077 1041 1005 969 933 897
High Speed (reserved)
2136 2073 2017 1941 1886 1825 1764 1703 1642 1581 1520
880 835 803 770 733 693 653 613 573 533 493
Medium Speed
1492 1415 1361 1305 1242 1175 1107 1039 971 903 836
715 668 636 594 548 491 434 377 320 263 206
Low Speed
1212 1132 1078 1007 929 832 736 639 542 446 349
The actual factory connected speeds are Super High – Medium – Low
Reserved High speed can be used in the field as per the requirements.
cfm cfm cfm cfm cfm cfm cfm cfm cfm cfm cfm
Air Flow 3 3 3 3 3 3 3 3 3 3 3
m /h m /h m /h m /h m /h m /h m /h m /h m /h m /h m /h
1470 1441 1405 1380 1345 1314 1283 1252 1221 1190 1159
Super High Speed
2492 2442 2381 2339 2280 2227 2175 2122 2070 2017 1964
1375 1346 1310 1285 1250 1219 1188 1157 1126 1095 1064
High Speed (reserved)
2331 2281 2220 2178 2119 2066 2014 1961 1909 1856 1803
1020 992 968 948 914 880 846 812 778 744 710
Medium Speed
1729 1681 1641 1607 1549 1492 1434 1376 1319 1361 1203
860 828 800 762 728 703 678 653 628 603 578
Low Speed
1458 1403 1356 1292 1234 1192 1149 1107 1064 1022 980
The actual factory connected speeds are Super High – Medium – Low
Reserved High speed can be used in the field as per the requirements.
39
10. Sound Levels Data
10.1 Sound Level Data of Ducted Indoor Units
Discharge Return
Air Air
Duct Duct
40
Sound Levels Data (Cont.)
Sound Level Data of Ducted Indoor Units (Cont.)
High Speed 48.5 48.1 47.7 47.3 46.9 46.5 46.1 45.7 45.3
Medium Speed 45.4 45.0 44.7 44.3 43.9 43.5 43.1 42.8 42.4
Low Speed 44.0 43.6 43.2 42.8 42.4 42.0 41.6 41.2 40.8
The actual factory connected speeds are High – Medium – Low,
Reserved Super High speed can be used in the field as per the requirements.
High Speed (reserved) 48.5 48.1 47.7 47.3 46.9 46.5 46.1 45.7 45.3
Medium Speed 45.4 45.0 44.7 44.3 43.9 43.5 43.1 42.8 42.4
Low Speed 44.0 43.6 43.2 42.8 42.4 42.0 41.6 41.2 40.8
The actual factory connected speeds are Super High – Medium – Low
Reserved High speed can be used in the field as per the requirements.
41
Sound Levels Data (Cont.)
Sound Level Data of Ducted Indoor Units (Cont.)
Super High Speed 52.0 51.6 51.2 50.9 50.5 50.1 49.7 49.3 49.0 48.6 48.2
High Speed (reserved) 48.1 47.7 47.3 46.9 46.5 45.7 45.7 45.3 44.9 44.5 44.1
Medium Speed 44.2 43.8 43.5 43.1 42.8 42.4 42.0 41.7 41.3 41.0 40.6
Low Speed 42.4 42.0 41.6 41.2 40.8 40.4 40.0 39.6 39.2 38.8 38.4
The actual factory connected speeds are Super High – Medium – Low
Reserved High speed can be used in the field as per the requirements.
42
Sound Levels Data (Cont.)
Sound Level Data of Ducted Indoor Units (Cont.)
Super High Speed 54.2 53.8 53.4 53.1 52.7 52.3 51.9 51.5 51.1 50.8 50.4
High Speed (reserved) 51.1 50.7 50.3 49.9 49.5 49.1 48.7 48.3 47.9 47.5 47.1
Medium Speed 47.9 47.5 47.2 46.8 46.5 46.1 45.7 45.4 45.0 44.7 44.3
Low Speed 44.9 44.6 44.2 43.9 43.5 43.2 42.9 42.5 42.2 41.8 41.5
The actual factory connected speeds are Super High – Medium – Low
Reserved High speed can be used in the field as per the requirements.
43
Sound Levels Data (Cont.)
10.2 Sound Level Data of Outdoor Units
Outdoor Unit
Microphone
1m
38QDMT12-718 56
38QDMT18-718 57
38QDMT24-718 62
38QDMT30-718 62
38QDMT36-718 65
38QDMT42-718 65
38QDMT48-518 68
38QDMT60-518 69
44
11. Operating Limits - Cooling
COOLING
Dry Bulb Wet Bulb
Difference
Temp. C° Temp. C°
Indoor temperature
Maximum 32 23
Minimum 21 15
Outdoor temperature
Maximum 52 -
Minimum 20 -
53QDMT18-718
53QDMT24-718
220-240/1/50 198 254
53QDMT30-718
53QDMT36-718
53QDMT42-718
53QDMT36-518
53QDMT42-518
380-420/3/50 342 462
53QDMT48-518
53QDMT60-518
NOTES:
* When the system is operated above or below these limits for a long time,
system diagnostics may detect a malfunction and the unit will not operate properly.
45
12. System Cooling Performance Data
Ducted Split System
53QDMT12-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT12-718
38QDMT12-718
Indoor Conditions Outdoor Ambient Temperature
Temp. °C 35°C 43°C 46°C 52°C
Air
ESP Fan Capacity Capacity Capacity Capacity
Flow Input Input Input Input
in.wg Speed DB WB Btu/hr Btu/hr Btu/hr Btu/hr
cfm W W W W
Total Sensible Total Sensible Total Sensible Total Sensible
21 15 12105 9980 1195 11580 10025 1230 11300 9920 1245 10735 9710 1275
Super 24 17 12475 10445 1240 11705 10150 1305 11460 10060 1330 10975 9870 1380
400
High 27 19 13000 10480 1265 12105 10230 1330 11700 10025 1355 10885 9610 1400
32 23 13530 12290 1325 12475 12000 1380 12110 11875 1395 11385 11630 1420
21 15 11500 9185 1150 11005 9225 1185 10735 9130 1200 10200 8935 1225
High 24 17 11855 9615 1195 11120 9340 1255 10890 9260 1280 10430 9085 1325
345
(Reserved) 27 19 12350 9645 1215 11500 9415 1280 11115 9225 1305 10345 8845 1345
0 32 23 12855 11310 1275 11855 11040 1325 11505 10925 1340 10820 10700 1365
in.wg 21 15 11040 8450 1115 10565 8485 1150 10310 8400 1160 9795 8220 1190
24 17 11380 8845 1155 10675 8595 1220 10455 8515 1240 10010 8355 1290
Medium 290
27 19 11860 8880 1180 11040 8660 1240 10675 8485 1265 9930 8135 1305
32 23 12340 10405 1235 11380 10155 1290 11045 10055 1300 10385 9845 1325
21 15 10580 7810 1070 10125 7840 1100 9880 7765 1115 9385 7595 1140
24 17 10905 8170 1110 10235 7945 1170 10020 7870 1190 9595 7720 1235
Low 250
27 19 11365 8200 1130 10580 8000 1190 10230 7840 1210 9515 7520 1250
21 23 11830 9610 1185 10905 9390 1235 10585 9290 1250 9955 9095 1270
21 15 11860 9605 1180 11345 9820 1215 11070 9725 1230 10520 9520 1260
Super 24 17 12225 10045 1225 11470 9950 1290 11235 9860 1315 10755 9670 1365
344
High 27 19 12740 10070 1250 11860 10030 1315 11465 9820 1340 10670 9415 1390
32 23 13250 11850 1310 12220 11750 1365 11860 11635 1380 11150 11395 1405
21 15 11270 8840 1135 10780 9040 1170 10520 8950 1185 9995 8760 1210
High 24 17 11615 9245 1180 10900 9155 1240 10675 9075 1265 10220 8905 1315
289
(Reserved) 27 19 12105 9265 1200 11270 9230 1265 10895 9040 1290 10140 8665 1335
0.08 32 23 12590 10905 1260 11610 10815 1315 11270 10705 1325 10595 10490 1350
in.wg 21 15 10820 8135 1100 10350 8315 1135 10100 8235 1150 9595 8055 1175
24 17 11150 8505 1145 10465 8425 1205 10250 8345 1225 9810 8190 1275
Medium 242
27 19 11620 8525 1165 10820 8490 1225 10460 8315 1250 9735 7970 1295
32 23 12085 10035 1220 11145 9950 1275 10820 9850 1290 10170 9645 1310
21 15 10370 7515 1055 9920 7685 1085 9680 7610 1100 9195 7450 1125
24 17 10685 7855 1095 10025 7785 1155 9820 7710 1175 9400 7565 1220
Low 203
27 19 11135 7875 1120 10370 7845 1175 10025 7685 1200 9330 7365 1245
21 23 11585 9270 1170 10685 9190 1220 10370 9100 1235 9750 8915 1255
21 15 11740 9415 1170 11235 9730 1205 10960 9625 1220 10420 9425 1250
Super 24 17 12100 9845 1215 11360 9860 1280 11125 9770 1305 10660 9590 1355
312
High 27 19 12610 9865 1240 11740 9930 1305 11350 9730 1330 10575 9325 1380
32 23 13105 11635 1300 12085 11625 1355 11730 11505 1370 11025 11270 1400
21 15 11155 8665 1125 10675 8955 1160 10415 8855 1175 9900 8670 1200
High 24 17 11495 9060 1170 10795 9075 1230 10570 8990 1255 10130 8825 1305
257
(Reserved) 27 19 11980 9080 1195 11155 9140 1255 10785 8955 1280 10050 8585 1325
0.12 32 23 12450 10705 1250 11485 10695 1305 11145 10585 1320 10475 10375 1345
in.wg 21 15 10710 7970 1090 10250 8240 1125 10000 8150 1140 9505 7980 1165
24 17 11040 8335 1135 10365 8345 1195 10150 8275 1220 9725 8120 1265
Medium 220
27 19 11505 8350 1155 10710 8410 1220 10355 8240 1240 9645 7895 1290
32 23 11955 9850 1215 11025 9845 1265 10700 9740 1280 10055 9545 1305
21 15 10265 7365 1045 9820 7615 1080 9580 7530 1090 9110 7370 1120
24 17 10580 7700 1085 9930 7710 1145 9725 7645 1170 9320 7500 1210
Low 180
27 19 11025 7715 1110 10265 7770 1170 9920 7615 1190 9245 7300 1235
21 23 11455 9100 1165 10565 9095 1210 10255 9000 1225 9640 8815 1250
Note : Reserved High speed can be used in the field as per the requirements
46
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT12-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT12-718
38QDMT12-718
Indoor Conditions Outdoor Ambient Temperature
Temp. °C 35°C 43°C 46°C 52°C
Air
ESP Fan Capacity Capacity Capacity Capacity
Flow Input Input Input Input
in.wg Speed DB WB Btu/hr Btu/hr Btu/hr Btu/hr
cfm W W W W
Total Sensible Total Sensible Total Sensible Total Sensible
21 15 11620 9225 1160 11115 9620 1195 10845 9525 1210 10300 9320 1240
Super 24 17 11970 9635 1205 11235 9745 1270 11000 9655 1295 10535 9475 1345
275
High 27 19 12475 9650 1230 11620 9820 1295 11230 9620 1320 10450 9220 1370
32 23 12965 11415 1290 11960 11505 1345 11610 11390 1360 10920 11155 1390
21 15 11040 8490 1115 10560 8850 1150 10305 8765 1165 9785 8580 1195
High 24 17 11375 8865 1160 10675 8965 1220 10450 8890 1245 10010 8725 1295
220
(Reserved) 27 19 11855 8885 1185 11040 9040 1245 10670 8850 1270 9930 8485 1320
0.16 32 23 12320 10510 1240 11365 10585 1295 11030 10480 1310 10375 10265 1335
in.wg 21 15 10600 7810 1085 10140 8145 1115 9895 8060 1130 9395 7890 1155
24 17 10920 8160 1125 10250 8255 1185 10035 8175 1210 9610 8020 1255
Medium 193
27 19 11380 8170 1150 10600 8315 1210 10245 8145 1230 9535 7805 1280
32 23 11825 9665 1205 10910 9740 1255 10590 9645 1270 9960 9445 1295
21 15 10160 7215 1040 9715 7525 1070 9480 7450 1085 9005 7295 1110
24 17 10465 7535 1080 9820 7625 1135 9615 7555 1160 9210 7410 1205
Low 156
27 19 10905 7550 1100 10160 7685 1160 9820 7525 1180 9135 7210 1225
21 23 11335 8930 1155 10455 9000 1205 10150 8910 1215 9545 8725 1245
Note : Reserved High speed can be used in the field as per the requirements
47
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT18-718 Heat Pump
38QDMT18-718
220-240V/1Ph/50Hz 42QDMT18-718
Note : Reserved High speed can be used in the field as per the requirements
48
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT18-718 Heat Pump
38QDMT18-718
220-240V/1Ph/50Hz 42QDMT18-718
Note : Reserved High speed can be used in the field as per the requirements
49
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT24-718 Heat Pump
38QDMT24-718
220-240V/1Ph/50Hz 42QDMT24-718
Note : Reserved High speed can be used in the field as per the requirements
50
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT24-718 Heat Pump
38QDMT24-718
220-240V/1Ph/50Hz 42QDMT24-718
Note : Reserved High speed can be used in the field as per the requirements
51
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT30-718 Heat Pump
220-240V/1Ph/50Hz 38QDMT30-718
42QDMT30-718
Note : Reserved Super High speed can be used in the field as per the requirements
52
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT30-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT30-718
38QDMT30-718
Note : Reserved Super High speed can be used in the field as per the requirements
53
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT30-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT30-718
38QDMT30-718
Note : Reserved Super High speed can be used in the field as per the requirements
54
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT36-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT36-718 38QDMT36-718
Indoor Conditions Outdoor Ambient Temperature
Temp. °C 35°C 43°C 46°C 52°C
Air
ESP Fan Capacity Capacity Capacity Capacity
Flow Input Input Input Input
in.wg Speed DB WB Btu/hr Btu/hr Btu/hr Btu/hr
cfm W W W W
Total Sensible Total Sensible Total Sensible Total Sensible
21 15 34990 25315 3940 33490 25450 4065 32740 25195 4110 31240 24675 4200
Super 24 17 36100 26450 4105 33845 25740 4320 33095 25460 4400 31595 24900 4560
1080
High 27 19 37600 26545 4195 34990 25965 4400 33845 25430 4490 31555 24350 4670
32 23 39105 31150 4400 36100 30375 4570 35000 30105 4615 32800 29560 4705
21 15 33245 23295 3785 31820 23420 3905 31105 23180 3950 29680 22705 4035
High 24 17 34295 24340 3945 32155 23680 4150 31445 23425 4225 30020 22910 4380
910
(Reserved) 27 19 35720 24425 4030 33245 23890 4225 32155 23395 4315 29980 22405 4485
0 32 23 37150 28660 4225 34295 27950 4390 33250 27695 4435 31160 27200 4520
in.wg 21 15 31915 21430 3670 30545 21545 3790 29860 21325 3830 28495 20890 3915
24 17 32925 22390 3825 30870 21790 4025 30185 21550 4100 28815 21075 4250
Medium 730
27 19 34295 22470 3910 31915 21980 4100 30870 21525 4185 28780 20615 4350
32 23 35665 26365 4100 32925 25715 4260 31920 25485 4300 29915 25020 4385
21 15 30585 19800 3520 29275 19905 3630 28615 19705 3670 27305 19300 3750
24 17 31555 20685 3665 29585 20135 3860 28930 19910 3930 27615 19475 4075
Low 645
27 19 32865 20765 3750 30585 20310 3930 29585 19890 4010 27580 19045 4170
21 23 34180 24360 3930 31555 23755 4085 30590 23540 4125 28670 23120 4205
21 15 34175 25630 3925 32715 24860 4050 31980 24610 4095 30510 24110 4185
Super 24 17 35260 25835 4085 33055 25145 4300 32325 24865 4380 30865 24325 4540
1005
High 27 19 36720 25925 4175 34175 25365 4380 33055 24840 4470 30820 23785 4650
32 23 38195 30425 4380 35260 29670 4550 34185 29400 4595 32035 28570 4685
21 15 32470 23580 3770 31080 22870 3890 30385 22640 3935 28985 22185 4020
High 24 17 33500 23770 3925 31405 23135 4130 30710 22880 4205 29325 22380 4360
850
(Reserved) 27 19 34885 23855 4010 32470 23340 4205 31405 22855 4295 29280 21885 4465
0.08 32 23 36290 27995 4205 33500 27295 4370 32480 27055 4415 30435 26285 4500
in.wg 21 15 31170 21700 3655 29840 21045 3775 29170 20830 3815 27830 20410 3900
24 17 32160 21870 3805 30150 21285 4005 29485 21050 4080 28150 20590 4230
Medium 657
27 19 33490 21950 3890 31170 21475 4080 30150 21025 4165 28110 20135 4335
32 23 34835 25755 4080 32160 25110 4240 31180 24890 4280 29220 24185 4365
21 15 29870 20050 3505 28595 19440 3620 27955 19245 3660 26670 18860 3740
24 17 30820 20205 3650 28895 19665 3840 28255 19450 3915 26980 19025 4055
Low 562
27 19 32095 20280 3730 29870 19840 3915 28895 19430 3995 26940 18605 4155
21 23 33385 23795 3915 30820 23200 4065 29880 22995 4105 28000 22340 4185
21 15 33765 28050 3915 32330 24565 4040 31600 24320 4085 30140 23830 4175
Super 24 17 34835 25530 4075 32660 24840 4290 31940 24575 4370 30500 24040 4530
976
High 27 19 36280 25620 4165 33765 25060 4370 32660 24540 4460 30450 23500 4640
32 23 37735 30060 4370 34835 29310 4540 33775 29055 4585 31655 27315 4675
21 15 32080 25810 3760 30715 22600 3880 30020 22380 3925 28635 21925 4010
High 24 17 33095 23485 3915 31030 22855 4120 30345 22610 4200 28975 22120 4350
820
(Reserved) 27 19 34470 23575 4000 32080 23055 4200 31030 22580 4285 28930 21625 4455
0.12 32 23 35850 27655 4200 33095 26965 4360 32090 26730 4405 30075 25135 4490
in.wg 21 15 30795 23740 3650 29485 20795 3765 28820 20585 3805 27490 20175 3890
24 17 31770 21610 3795 29790 21025 3995 29130 20800 4070 27820 20350 4220
Medium 624
27 19 33090 21685 3880 30795 21215 4070 29790 20775 4155 27775 19895 4325
32 23 34415 25440 4070 31770 24815 4230 30805 24590 4270 28870 23120 4355
21 15 29515 21935 3500 28260 19210 3610 27620 19020 3650 26345 18640 3730
24 17 30450 19965 3640 28545 19430 3835 27920 19220 3905 26660 18800 4045
Low 525
27 19 31710 20035 3720 29515 19600 3905 28545 19195 3985 26615 18380 4145
21 23 32985 23510 3905 30450 22925 4055 29520 22725 4095 27670 21365 4175
Note : Reserved High speed can be used in the field as per the requirements
55
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT36-718 Heat Pump
220-240V/1Ph/50Hz 38QDMT36-718
42QDMT36-718
Note : Reserved High speed can be used in the field as per the requirements
56
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT36-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT36-718 38QDMT36-718
Note : Reserved High speed can be used in the field as per the requirements
57
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT36-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT36-718 38QDMT36-518
Note : Reserved High speed can be used in the field as per the requirements
58
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT36-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT36-718 38QDMT36-518
Note : Reserved High speed can be used in the field as per the requirements
59
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT36-518 Heat Pump
38QDMT36-518
380-420V/3Ph/50Hz 42QDMT36-718
Note : Reserved High speed can be used in the field as per the requirements
60
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT42-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT42-718
38QDMT42-718
Note : Reserved High speed can be used in the field as per the requirements
61
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT42-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT42-718 38QDMT42-718
Note : Reserved High speed can be used in the field as per the requirements
62
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT42-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT42-718
38QDMT42-718
Note : Reserved High speed can be used in the field as per the requirements
63
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT42-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT42-718 38QDMT42-718
Note : Reserved High speed can be used in the field as per the requirements
64
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT42-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT42-718 38QDMT42-518
Note : Reserved High speed can be used in the field as per the requirements
65
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT42-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT42-718
38QDMT42-518
Note : Reserved High speed can be used in the field as per the requirements
66
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT42-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT42-718
38QDMT42-518
Note : Reserved High speed can be used in the field as per the requirements
67
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT42-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT42-718
38QDMT42-518
Note : Reserved High speed can be used in the field as per the requirements
68
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT48-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT48-718 38QDMT48-518
Note : Reserved High speed can be used in the field as per the requirements
69
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT48-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT48-718 38QDMT48-518
Indoor Conditions Outdoor Ambient Temperature
Temp. °C 35°C 43°C 46°C 52°C
Air
ESP Fan Capacity Capacity Capacity Capacity
Flow Input Input Input Input
in.wg Speed DB WB Btu/hr Btu/hr Btu/hr Btu/hr
cfm W W W W
Total Sensible Total Sensible Total Sensible Total Sensible
21 15 40010 31740 3895 38290 31970 4015 37430 31540 4055 35715 30680 4135
Super 24 17 41300 33165 4065 38720 32225 4270 37860 31895 4350 36145 31230 4505
1233
High 27 19 43015 33255 4135 40005 32525 4348 38720 31855 4445 36140 30500 2305
32 23 44735 39015 4350 40810 38070 4520 40010 37665 4570 38415 36865 4660
21 15 38010 29200 3740 36380 29415 3855 35560 29020 3895 33930 28225 3970
High 24 17 39235 30515 3905 36785 29650 4100 35970 29345 4180 34340 28730 4325
1113
(Reserved) 27 19 40865 30600 3970 38005 29925 4175 36785 29305 4270 34335 28065 2215
0.16 32 23 42500 35895 4180 38770 35030 4340 38010 34655 4390 36495 33915 4475
in.wg 21 15 36490 26870 3630 34925 27060 3740 34140 26700 3780 32575 25970 3855
24 17 37670 28075 3790 35315 27280 3980 34530 26995 4055 32965 26435 4200
Medium 733
27 19 39230 28150 3855 36485 27530 4050 35315 26965 4140 32960 25820 2150
32 23 40800 33025 4055 37220 32225 4210 36490 31885 4260 35035 31205 4340
21 15 34970 24820 3480 33470 25005 3585 32715 24670 3625 31215 23995 3695
24 17 36100 25935 3630 33845 25205 3815 33090 24940 3885 31595 24425 4025
Low 548
27 19 37600 26010 3695 34965 25440 3885 33845 24910 3970 31590 23855 2060
21 23 39100 30510 3885 35670 29775 4040 34970 29455 4085 33575 28830 4165
21 15 39670 31470 3875 37970 31700 3995 37105 31270 4040 35405 30415 4120
Super 24 17 40945 32885 4050 38385 31940 4255 37535 31615 4335 35830 30955 4490
1187
High 27 19 42645 32975 4120 39660 32245 4327 38385 31575 4440 35830 30240 4585
32 23 44350 38675 4335 39965 37740 4505 39665 37345 4555 39070 36545 4645
21 15 37690 28955 3720 36075 29170 3840 35250 28770 3880 33635 27985 3960
High 24 17 38900 30260 3890 36470 29390 4085 35660 29090 4165 34040 28485 4315
1077
(Reserved) 27 19 40515 30335 3960 37680 29670 4155 36470 29055 4265 34040 27820 4405
0.20 32 23 42135 35585 4165 37970 34720 4325 37685 34360 4375 37120 33620 4460
in.wg 21 15 36180 26640 3610 34630 26835 3725 33840 26465 3765 32290 25750 3840
24 17 37345 27835 3775 35010 27035 3965 34235 26765 4040 32680 26205 4185
Medium 693
27 19 38895 27910 3840 36170 27295 4030 35010 26730 4135 32680 25595 4270
32 23 40450 32740 4040 36450 31945 4200 36175 31610 4245 35635 30935 4330
21 15 34675 24615 3460 33190 24790 3570 32430 24455 3610 30945 23785 3680
24 17 35790 25720 3620 33550 24980 3800 32810 24730 3875 31320 24215 4010
Low 491
27 19 37275 25790 3680 34665 25220 3865 33550 24695 3965 31320 23650 4095
21 23 38765 30250 3875 34930 29515 4025 34670 29205 4070 34150 28585 4150
21 15 39325 31200 3860 33910 28320 3980 33150 27940 4025 31635 27170 4105
Super 24 17 40595 32600 4040 34480 28695 4245 33720 28400 4325 32195 27820 4480
1151
High 27 19 42270 32690 4105 35040 28490 4315 33915 27905 4390 31665 26730 4540
32 23 43965 38340 4320 37265 35195 4490 36990 25130 4535 36440 35885 4630
21 15 37360 28705 3710 32215 26055 3825 31495 25705 3865 30055 25000 3945
High 24 17 38570 29995 3880 32760 26405 4080 32035 26130 4155 30590 25595 4305
1041
(Reserved) 27 19 40160 30080 3945 33290 26215 4145 32220 25675 4215 30085 24595 4360
0.24 32 23 41770 35275 4150 35405 32380 4315 35145 23125 4355 34620 33020 4445
in.wg 21 15 35865 26410 3595 30930 23975 3710 30235 23655 3750 28855 23000 3825
24 17 37025 27595 3765 31450 24290 3955 30755 24040 4030 29365 23550 4175
Medium 653
27 19 38555 27670 3825 31960 24115 4020 30935 23625 4090 28880 22625 4230
32 23 40100 32455 4025 33990 29790 4185 33735 21275 4225 33235 30375 4315
21 15 34375 24400 3450 29640 22150 3555 28975 21850 3595 27650 21250 3665
24 17 35485 25495 3610 30140 22445 3790 29475 22210 3865 28140 21760 4000
Low 434
27 19 36945 25565 3665 30625 22280 3855 29645 21825 3920 27680 20910 4055
21 23 38430 29985 3860 32570 27525 4010 32330 19655 4050 31850 28070 4135
Note : Reserved High speed can be used in the field as per the requirements
70
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT48-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT48-718 38QDMT48-518
Indoor Conditions Outdoor Ambient Temperature
Temp. °C 35°C 43°C 46°C 52°C
Air
ESP Fan Capacity Capacity Capacity Capacity
Flow Input Input Input Input
in.wg Speed DB WB Btu/hr Btu/hr Btu/hr Btu/hr
cfm W W W W
Total Sensible Total Sensible Total Sensible Total Sensible
21 15 38985 30925 3845 35445 24935 3965 34655 29200 4005 33070 28400 4090
Super 24 17 40235 32325 4025 35940 25450 4230 35140 29605 4310 33545 28995 4465
1115
High 27 19 41900 32405 4090 36835 24730 4300 35650 29330 4375 33285 28095 4525
32 23 43575 38005 4305 38095 32640 4475 37810 35600 4520 37245 36680 4615
21 15 37040 28455 3695 33675 22945 3810 32925 26870 3845 31420 26130 3930
High 24 17 38225 29740 3865 34145 23420 4065 33385 27240 4140 31870 26675 4290
1005
(Reserved) 27 19 39805 29810 3930 34995 22750 4130 33870 26985 4200 31625 25855 4345
0.28 32 23 41400 34970 4135 36195 30035 4300 35920 32755 4340 35385 33745 4435
in.wg 21 15 35555 26180 3585 32330 21110 3695 31610 24720 3730 30160 24040 3810
24 17 36695 27365 3750 32780 21545 3940 32050 25060 4015 30595 24545 4160
Medium 613
27 19 38215 27430 3810 33595 20930 4005 32515 24825 4075 30360 23785 4215
32 23 39745 32170 4010 34745 27630 4170 34485 30135 4210 33970 31050 4300
21 15 34075 24190 3435 30980 19505 3540 30290 22840 3580 28905 22210 3655
24 17 35170 25280 3595 31415 19905 3780 30715 23150 3850 29320 22675 3990
Low 377
27 19 36625 25340 3655 32195 19340 3840 31160 22940 3910 29095 21975 4040
21 23 38085 29725 3845 33300 25530 4000 33050 27840 4040 32555 28685 4125
21 15 38645 30655 3830 36975 30875 3950 36150 30465 3990 34500 29630 4075
Super 24 17 39885 32035 4015 37400 31120 4220 36565 30805 4300 34910 30165 4455
1079
High 27 19 41530 32115 4075 38625 31400 4275 37380 30755 4355 34895 29460 4505
32 23 43190 37665 4290 38920 36760 4460 38635 36370 4505 38055 37475 4600
21 15 36715 28205 3680 35130 28410 3795 34345 28035 3835 32775 27260 3915
High 24 17 37895 29475 3855 35530 28630 4055 34740 28340 4130 33165 27755 4280
969
(Reserved) 27 19 39455 29550 3915 36695 28890 4105 35515 28295 4185 33155 27105 4325
0.32 32 23 41035 34655 4120 36975 33820 4285 36705 33465 4325 36155 34480 4420
in.wg 21 15 35245 25945 3570 33725 26135 3680 32970 25790 3720 31465 25080 3795
24 17 36380 27115 3740 34110 26345 3930 33350 26075 4005 31840 25535 4150
Medium 573
27 19 37880 27185 3795 35230 26580 3985 34095 26030 4060 31825 24935 4200
32 23 39390 31885 3995 35500 31115 4155 35240 30790 4200 34710 31725 4285
21 15 33780 23975 3420 32320 24150 3530 31600 23825 3565 30155 23170 3640
24 17 34860 25055 3585 32690 24335 3770 31960 24090 3840 30515 23595 3980
Low 320
27 19 36300 25120 3640 33760 24560 3820 32675 24055 3890 30500 23040 4025
21 23 37750 29455 3835 34020 28745 3985 33770 28445 4025 33265 29310 4110
21 15 38300 30380 3815 36650 30605 3935 35830 30200 3975 34190 29365 4060
Super 24 17 39535 31755 4000 37060 30845 4210 36240 30530 4290 34605 29900 4445
1043
High 27 19 41155 31830 4060 38280 31125 4260 37050 30480 4340 34590 29195 4490
32 23 42805 37330 4270 38575 36430 4445 38290 36050 4490 37715 37145 4585
21 15 36385 27955 3665 34820 28155 3780 34040 27785 3820 32485 27015 3900
High 24 17 37560 29215 3840 35210 28380 4045 34430 28090 4120 32875 27515 4270
933
(Reserved) 27 19 39100 29285 3900 36370 28635 4090 35200 28045 4170 32865 26865 4315
0.36 32 23 40665 34345 4100 36650 33520 4270 36380 33165 4315 35830 34175 4405
in.wg 21 15 34930 25720 3555 33425 25905 3665 32680 25560 3705 31185 24855 3785
24 17 36060 26880 3725 33800 26110 3925 33055 25845 3995 31560 25315 4140
Medium 533
27 19 37535 26945 3785 34915 26350 3970 33790 25805 4045 31550 24715 4185
32 23 39040 31595 3980 35185 30835 4140 34925 30515 4185 34400 31440 4270
21 15 33475 23760 3410 32035 23935 3515 31320 23620 3550 29885 22970 3625
24 17 34555 24835 3575 32395 24125 3760 31675 23875 3835 30245 23385 3970
Low 263
27 19 35970 24890 3625 33460 24340 3805 32385 23840 3875 30235 22835 4010
21 23 37415 29190 3815 33715 28495 3970 33470 28195 4010 32965 29050 4095
Note : Reserved High speed can be used in the field as per the requirements
71
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT48-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT48-718 38QDMT48-518
Indoor Conditions Outdoor Ambient Temperature
Temp. °C 35°C 43°C 46°C 52°C
Air
ESP Fan Capacity Capacity Capacity Capacity
Flow Input Input Input Input
in.wg Speed DB WB Btu/hr Btu/hr Btu/hr Btu/hr
cfm W W W W
Total Sensible Total Sensible Total Sensible Total Sensible
21 15 37960 30110 3800 36320 30330 3920 35510 29930 3960 33885 29105 4045
Super 24 17 39180 31475 3990 36730 30575 4200 35920 30260 4275 34295 29640 4435
1007
High 27 19 40785 31540 4045 37935 30840 4245 36715 30205 4325 34280 28940 4475
32 23 42420 36985 4255 38225 36105 4430 37945 35725 4475 37375 36810 4570
21 15 36065 27705 3650 34505 27910 3765 33735 27535 3805 32195 26780 3885
High 24 17 37225 28960 3835 34895 28130 4035 34125 27840 4105 32585 27270 4260
897
(Reserved) 27 19 38750 29020 3885 36040 28380 4080 34880 27790 4155 32570 26625 4300
0.40 32 23 40300 34030 4085 36315 33220 4255 36050 32870 4300 35510 33865 4390
in.wg 21 15 34620 25490 3540 33125 25675 3655 32390 25335 3690 30905 24635 3770
24 17 35735 26640 3720 33500 25880 3915 32760 25615 3985 31280 25090 4130
Medium 493
27 19 37200 26700 3770 34600 26105 3955 33485 25565 4030 31265 24495 4170
32 23 38690 31310 3965 34865 30560 4130 34610 30240 4170 34090 31160 4260
21 15 33180 23550 3395 31745 23720 3500 31040 23410 3540 29620 22760 3615
24 17 34245 24615 3565 32105 23910 3750 31395 23665 3820 29975 23180 3960
Low 206
27 19 35650 24670 3615 33160 24125 3790 32090 23625 3865 29965 22630 4000
21 23 37080 28925 3800 33410 28235 3960 33165 27940 4000 32670 28785 4085
Note : Reserved High speed can be used in the field as per the requirements
72
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT60-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT60-718 38QDMT60-518
Indoor Conditions Outdoor Ambient Temperature
Temp. °C 35°C 43°C 46°C 52°C
Air
ESP Fan Capacity Capacity Capacity Capacity
Flow Input Input Input Input
in.wg Speed DB WB Btu/hr Btu/hr Btu/hr Btu/hr
cfm W W W W
Total Sensible Total Sensible Total Sensible Total Sensible
21 15 48640 37150 4445 46550 37345 4590 45505 36945 4635 43415 36155 4725
Super 24 17 50210 38840 4630 47075 37780 4865 46030 37365 4955 43940 36535 5135
1470
High 27 19 52300 38960 4725 48640 38090 4960 47075 37320 5050 43945 35780 5230
32 23 54395 45710 4960 50215 44585 5150 48650 44145 5200 45520 43255 5300
21 15 46210 34180 4270 44225 34360 4410 43230 33995 4450 41245 33265 4540
High 24 17 47700 35735 4445 44725 34765 4675 43730 34380 4760 41745 33615 4930
1375
(Reserved) 27 19 49685 35850 4540 46210 35040 4765 44725 34335 4850 41750 32920 5025
0 32 23 51680 42055 4765 47705 41025 4945 46220 40615 4995 43245 39795 5090
in.wg 21 15 44360 31445 4140 42455 31610 4275 41505 31275 4320 39595 30605 4400
24 17 45795 32875 4315 42935 31980 4535 41980 31630 4615 40075 30925 4785
Medium 1020
27 19 47700 32980 4400 44360 32240 4620 42935 31590 4705 40080 30290 4875
32 23 49610 38690 4620 45800 37740 4800 44370 37365 4845 41515 36610 4940
21 15 42515 29055 3970 40685 29205 4100 39775 28895 4140 37945 28275 4220
24 17 43885 30375 4135 41145 29550 4345 40235 29225 4425 38405 28575 4585
Low 860
27 19 45715 30470 4220 42515 29790 4430 41145 29185 4510 38410 27985 4670
21 23 47545 35750 4430 43890 34870 4600 42525 34520 4645 39785 33830 4735
21 15 47825 36530 4415 45770 36715 4558 44743 36330 4602 42690 35555 4692
Super 24 17 49370 38190 4600 46285 37170 4830 45260 36740 4920 43208 35885 5097
1405
High 27 19 51420 38785 4690 47825 37455 4925 46285 36695 5015 43210 35180 5194
32 23 53485 44945 4925 49370 43840 5115 47835 43405 5165 44765 42535 5264
21 15 45435 33610 4240 43485 33780 4380 42510 33425 4420 40560 32710 4505
High 24 17 46905 35135 4420 43975 34200 4640 43000 33805 4725 41050 33015 4895
1310
(Reserved) 27 19 48850 35685 4505 45435 34460 4730 43975 33760 4815 41050 32370 4990
0.08 32 23 50815 41355 4730 46905 40335 4915 45445 39935 4960 42530 39135 5055
in.wg 21 15 43620 30920 4115 41745 31080 4245 40810 30755 4290 38935 30095 4370
24 17 45030 32325 4285 42215 31465 4500 41280 31100 4585 39410 30375 4750
Medium 968
27 19 46900 32830 4370 43620 31705 4590 42215 31065 4670 39410 29780 4840
32 23 48780 38045 4590 45030 37110 4765 43630 36740 4810 40830 36005 4905
21 15 41800 28570 3945 40005 28715 4070 39110 28415 4110 37315 27805 4190
24 17 43150 29865 4110 40455 29075 4315 39560 28735 4395 37765 28065 4555
Low 800
27 19 44945 30335 4190 41800 29290 4400 40455 28700 4480 37770 27515 4640
21 23 46750 35150 4400 43150 34285 4570 41810 33950 4615 39125 33265 4700
21 15 47415 36215 4395 45380 36405 4540 44365 36025 4585 42335 35260 4675
Super 24 17 48945 37865 4580 45890 36920 4815 44875 36430 4905 42845 35455 5085
1380
High 27 19 50980 38945 4675 47415 37135 4910 45890 36385 5000 42840 34885 5180
32 23 53025 44560 4910 48950 43465 5100 47425 43035 5150 44375 42175 5250
21 15 45045 33320 4220 43115 33500 4360 42150 33145 4405 40220 32445 4490
High 24 17 46500 34835 4400 43600 33965 4625 42635 33520 4710 40705 32620 4885
1285
(Reserved) 27 19 48435 35830 4490 45045 34165 4715 43600 33475 4800 40700 32095 4975
0.12 32 23 50375 40995 4715 46505 39990 4900 45055 39595 4945 42160 38805 5040
in.wg 21 15 43245 30660 4095 41390 30815 4230 40465 30495 4270 38610 29845 4355
24 17 44640 32050 4265 41855 31250 4485 40930 30840 4570 39075 30015 4740
Medium 948
27 19 46495 32965 4355 43245 31430 4575 41855 30795 4660 39075 29525 4825
32 23 48360 37715 4575 44645 36790 4750 43255 36425 4800 40470 35700 4890
21 15 41445 28325 3925 39665 28470 4055 38780 28175 4095 37005 27580 4175
24 17 42780 29610 4090 40110 28870 4300 39225 28490 4380 37450 27730 4540
Low 762
27 19 44560 30455 4175 41445 29040 4385 40110 28455 4465 37445 27280 4625
21 23 46345 34845 4385 42785 33990 4555 41450 33655 4600 38785 32985 4690
Note : Reserved High speed can be used in the field as per the requirements
73
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT60-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT60-718 38QDMT60-518
Note : Reserved High speed can be used in the field as per the requirements
74
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT60-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT60-718 38QDMT60-518
Note : Reserved High speed can be used in the field as per the requirements
75
System Cooling Performance Data (Cont.)
Ducted Split System
53QDMT60-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT60-718 38QDMT60-518
Indoor Conditions Outdoor Ambient Temperature
Temp. °C 35°C 43°C 46°C 52°C
Air
ESP Fan Capacity Capacity Capacity Capacity
Flow Input Input Input Input
in.wg Speed DB WB Btu/hr Btu/hr Btu/hr Btu/hr
cfm W W W W
Total Sensible Total Sensible Total Sensible Total Sensible
21 15 44545 34030 4150 42635 34210 4425 41675 33845 4470 39745 33110 4560
Super 24 17 45995 35580 4465 43130 34615 4695 42175 34240 4780 40245 33470 4950
1159
High 27 19 47900 36595 4535 44550 34905 4765 43130 34200 4855 40285 32795 5035
32 23 49830 41875 4770 45985 40845 4955 44590 40460 5005 41820 39730 5105
21 15 42320 31305 3985 40505 31475 4250 39595 31140 4295 37760 30460 4380
High 24 17 43700 32735 4290 40975 31850 4510 40070 31505 4590 38235 30795 4755
1064
(Reserved) 27 19 45505 33665 4355 42325 32115 4575 40975 31470 4665 38275 30175 4835
0.40 32 23 47340 38525 4580 43690 37575 4760 42365 37230 4805 39730 36555 4905
in.wg 21 15 40630 28805 3865 38885 28960 4125 38010 28650 4165 36250 28025 4250
24 17 41950 30120 4160 39335 29300 4375 38465 28980 4455 36705 28335 4610
Medium 710
27 19 43685 30975 4225 40630 29545 4440 39335 28950 4525 36740 27765 4690
32 23 45445 35445 4445 41940 34575 4615 40670 34250 4665 38140 33635 4755
21 15 38935 26615 3710 37265 26755 3955 36425 26470 3995 34740 25895 4075
24 17 40200 27825 3990 37700 27070 4195 36865 26775 4270 35175 26180 4420
Low 578
27 19 41865 28620 4050 38940 27295 4255 37700 26745 4335 35210 25650 4500
21 23 43555 32750 4260 40195 31940 4425 38975 31640 4470 36555 31075 4560
Note : Reserved High speed can be used in the field as per the requirements
76
13. Operating Limits - Heating
HEATING
Dry Bulb Wet Bulb
Difference
Temp. C° Temp. C°
Indoor temperature
Maximum 27 -
Outdoor temperature
Maximum 24 18
Minimum 2 1
53QDMT18-718
53QDMT24-718
220-240/1/50 198 254
53QDMT30-718
53QDMT36-718
53QDMT42-718
53QDMT36-518
53QDMT42-518
380-420/3/50 342 462
53QDMT48-518
53QDMT60-518
NOTES:
* When the unit is operated above or below these limits for a long time,
system diagnostics may detect a malfunction and the unit will not operate properly.
** During heat pump operation, the system will undergo several defrost cycles to eliminate ice that
might possibly collect on the outdoor unit in very low ambient temperatures.
After completion of defrost cycle, the system will normally operate
77
14. System Heating Performance Data
Ducted Split System
53QDMT12-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT12-718
38QDMT12-718
Note : Reserved High speed can be used in the field as per the requirements
78
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT12-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT12-718
38QDMT12-718
Note : Reserved High speed can be used in the field as per the requirements
79
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT18-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT18-718
38QDMT18-718
Indoor Conditions Outdoor Ambient Temperature
Air 24/18°C DB/WB 7/6°C DB/WB 2/1°C DB/WB
ESP Fan Temp. °C
Flow Capacity Input Capacity Input Capacity Input
in.wg Speed DB
cfm Btu/hr W Btu/hr W Btu/hr W
Note : Reserved High speed can be used in the field as per the requirements
80
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT18-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT18-718
38QDMT18-718
Indoor Conditions Outdoor Ambient Temperature
Air 24/18°C DB/WB 7/6°C DB/WB 2/1°C DB/WB
ESP Fan Temp. °C
Flow Capacity Input Capacity Input Capacity Input
in.wg Speed DB
cfm Btu/hr W Btu/hr W Btu/hr W
Note : Reserved High speed can be used in the field as per the requirements
81
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT24-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT24-718
38QDMT24-718
Note : Reserved High speed can be used in the field as per the requirements
82
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT24-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT24-718
38QDMT24-718
Note : Reserved High speed can be used in the field as per the requirements
83
System Heating Performance Data (Cont.)
Note : Reserved Super High speed can be used in the field as per the requirements
84
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT30-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT30-718
38QDMT30-718
Note : Reserved Super High speed can be used in the field as per the requirements
85
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT30-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT30-718
38QDMT30-718
Note : Reserved Super High speed can be used in the field as per the requirements
86
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT36-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT36-718
38QDMT36-718
Note : Reserved High speed can be used in the field as per the requirements
87
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT36-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT36-718
38QDMT36-718
Note : Reserved High speed can be used in the field as per the requirements
88
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT36-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT36-718
38QDMT36-718
Note : Reserved High speed can be used in the field as per the requirements
89
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT36-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT36-718
38QDMT36-518
Note : Reserved High speed can be used in the field as per the requirements
90
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT36-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT36-718
38QDMT36-518
Note : Reserved High speed can be used in the field as per the requirements
91
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT36-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT36-718
38QDMT36-518
Note : Reserved High speed can be used in the field as per the requirements
92
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT42-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT42-718
38QDMT42-718
Note : Reserved High speed can be used in the field as per the requirements
93
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT42-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT42-718
38QDMT42-718
Note : Reserved High speed can be used in the field as per the requirements
94
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT42-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT42-718
38QDMT42-718
Note : Reserved High speed can be used in the field as per the requirements
95
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT42-718 Heat Pump
220-240V/1Ph/50Hz 42QDMT42-718
38QDMT42-718
Note : Reserved High speed can be used in the field as per the requirements
96
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT42-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT42-718
38QDMT42-518
Note : Reserved High speed can be used in the field as per the requirements
97
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT42-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT42-718
38QDMT42-518
Note : Reserved High speed can be used in the field as per the requirements
98
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT42-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT42-718
38QDMT42-518
Note : Reserved High speed can be used in the field as per the requirements
99
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT42-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT42-718
38QDMT42-518
Note : Reserved High speed can be used in the field as per the requirements
100
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT48-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT48-718
38QDMT48-518
Note : Reserved High speed can be used in the field as per the requirements
101
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT48-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT48-718
38QDMT48-518
Note : Reserved High speed can be used in the field as per the requirements
102
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT48-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT48-718
38QDMT48-518
Note : Reserved High speed can be used in the field as per the requirements
103
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT48-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT48-718
38QDMT48-518
Note : Reserved High speed can be used in the field as per the requirements
104
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT60-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT60-718
38QDMT60-518
Note : Reserved High speed can be used in the field as per the requirements
105
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT60-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT60-718
38QDMT60-518
Note : Reserved High speed can be used in the field as per the requirements
106
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT60-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT60-718
38QDMT60-518
Note : Reserved High speed can be used in the field as per the requirements
107
System Heating Performance Data (Cont.)
Ducted Split System
53QDMT60-518 Heat Pump
380-420V/3Ph/50Hz 42QDMT60-718
38QDMT60-518
Note : Reserved High speed can be used in the field as per the requirements
108
15. Electrical Data
Electrical Consumption
Split Starting System
Cooling Heating Circuit
System Current Power
35 °C 43 °C 46 °C 52 °C Breaker
Model (Note 1) Supply *****
* ** *** ****
Heat Pump Amp V/Ph/Hz Amp Watt Amp Watt Amp Watt Amp Watt Amp Watt Amp
53QDMT12-718 35 220-240 5.9 1265 6.5 1330 6.8 1355 7.3 1400 5.1 1045 16
53QDMT18-718 58 220-240 9.2 1985 10.4 2095 10.9 2135 11.9 2215 7.8 1695 20
53QDMT24-718 72 220-240 11.2 2415 12.4 2540 12.9 2585 13.8 2675 10.2 2125 25
53QDMT30-718 91 220-240 16.3 3515 18.5 3690 19.4 3760 21.1 3900 12.3 2755 32
53QDMT36-718 115 220-240 20.9 4195 23.7 4400 24.7 4490 26.7 4670 16.8 3220 40
53QDMT36-518 61 380-420 7.2 4105 8.3 4315 8.6 4405 9.3 4580 5.9 3200 20
53QDMT42-718 115 220-240 22.5 4555 25.3 4785 26.4 4870 28.4 5040 16.9 3200 40
53QDMT42-518 61 380-420 7.2 4245 8.3 4460 8.6 4540 9.3 4695 5.4 2975 20
53QDMT48-518 61 380-420 7.5 4200 8.6 4415 9.0 4490 9.7 4645 6.7 3795 20
53QDMT60-518 77 380-420 8.3 4725 9.4 4960 9.8 5050 10.6 5230 7.6 4155 20
NOTES
2. Operating Conditions.
* @ 35ºC db outdoor temperature :
27/19ºC db/wb Indoor Temperature. High air flow of indoor unit
109
16. Wiring Diagrams
Wiring Diagram
53QDMT12-718 Heat Pump 220-240/1/50
53QDMT18-718 Heat Pump 220-240/1/50
TO WIRED CONTROLLER
110
Wiring Diagrams (Cont.)
Wiring Diagram
53QDMT12-718 Heat Pump 220-240/1/50
53QDMT18-718 Heat Pump 220-240/1/50
LEGEND : INDOOR UNIT
CAP1 : INDOOR FAN CAP. KM1 : RELAY FOR COMPRESSOR
CN1-CN33 : P.C.B SOCKETS RT1 : INDOOR – AIR SENSOR
T4 : TRANSFORMER RT2 : INDOOR COIL SENSOR
FAN1 : INDOOR MOTOR XT1 : 8-WAY TERMINAL
XP1 ˜ 4 : CONNECTORS K3 : WATER LEVEL SWITCH
XS1 ˜ 4 : CONNECTORS RY6 : COMP. RELAY WIRING
LEGEND : OUTDOOR UNIT
COMP : COMPRESSOR RVS : 4 WAY REVERSING VALVE
FM : FAN MOTOR RT3 : OUTDOOR COIL SENSOR
CONT : CONTACTOR CTB : COND. TERMINAL BLOCK
DC : DUAL CAPACITOR
LEGEND : TERMINAL BOX
1 : LIVE CONNECTION 3 : REVERSING VALVE CONTROL
2 : NEUTRAL CONNECTION 4 : OUTDOOR FAN CONTROL
LEGEND : WIRE COLORS
WH : WHITE BR : BROWN
BK : BLACK BL : BLUE
RD : RED OR : ORANGE
GR : GREEN YL : YELLOW
YL/ GR : YELLOW / GREEN
NOTES
➀ MAIN SWITCH ➁ TIME DELAY FUSE OR CIRCUIT BREAKER
➂ DOTTED WIRES TO BE FITTED BY INSTALLER ➃ ALL ITEMS IN DASHED RECTANGLES ARE OPTIONAL
➄ THE SYSTEM SHALL BE INSTALLED ACCORDING TO NATIONAL WIRING REGULATIONS
111
Wiring Diagrams (Cont.)
Wiring Diagram
53QDMT24-718 Heat Pump 220-240/1/50
53QDMT30-718 Heat Pump 220-240/1/50
53QDMT36-718 Heat Pump 220-240/1/50
53QDMT42-718 Heat Pump 220-240/1/50
112
Wiring Diagrams (Cont.)
Wiring Diagram
53QDMT24-718 Heat Pump 220-240/1/50
53QDMT30-718 Heat Pump 220-240/1/50
53QDMT36-718 Heat Pump 220-240/1/50
53QDMT42-718 Heat Pump 220-240/1/50
LEGEND : INDOOR UNIT
CAP1 : INDOOR FAN CAP. KM1 : RELAY FOR COMPRESSOR
CN1-CN33 : P.C.B SOCKETS RT1 : INDOOR AIR SENSOR
T4 : TRANSFORMER RT2 : INDOOR COIL SENSOR
FAN1 : INDOOR MOTOR XT1 : 8-WAY TERMINAL
XP1 ˜ 4 : CONNECTORS K3 : WATER LEVEL SWITCH
XS1 ˜ 4 : CONNECTORS CN20 : NET CONTROL INTERFACE
LEGEND : OUTDOOR UNIT
COMP : COMPRESSOR RVS : 4 WAY REVERSING VALVE
OFM : OUTDOOR FAN MOTOR RT3 : OUTDOOR COIL SENSOR
CONT : CONTACTOR CTB : COND. TERMINAL BLOCK
DC : DUAL CAPACITOR
LEGEND : TERMINAL BOX
L : LIVE CONNECTION 1 : COMPRESSOR CONTROL
N : NEUTRAL CONNECTION 2 : REVERSING VALVE CONTROL
3 : OUTDOOR FAN CONTROL
WIRE COLORS
WH : WHITE OR : ORANGE
BK : BLACK BL : BLUE
BR : BROWN RD : RED
YL : YELLOW YL/ GR : YELLOW / GREEN
NOTES
➀ MAIN SWITCH ➁ TIME DELAY FUSE OR CIRCUIT BREAKER
➂ DOTTED WIRES TO BE FITTED BY INSTALLER ➃ ALL ITEMS IN DASHED RECTANGLES ARE OPTIONAL
➄ THE SYSTEM SHALL BE INSTALLED ACCORDING TO NATIONAL WIRING REGULATIONS
113
Wiring Diagrams (Cont.)
Wiring Diagram
53QDMT36-518 Heat Pump 380-420/3/50
53QDMT42-518 Heat Pump 380-420/3/50
53QDMT48-518 Heat Pump 380-420/3/50
53QDMT60-518 Heat Pump 380-420/3/50
114
Wiring Diagrams (Cont.)
Wiring Diagram
53QDMT36-518 Heat Pump 380-420/3/50
53QDMT42-518 Heat Pump 380-420/3/50
53QDMT48-518 Heat Pump 380-420/3/50
53QDMT60-518 Heat Pump 380-420/3/50
LEGEND : INDOOR UNIT
CAP1 : INDOOR FAN CAP. RT1 : INDOOR AIR SENSOR
CN1-CN33 : P.C.B SOCKETS RT2 : INDOOR COIL SENSOR
T4 : TRANSFORMER XT1 : 8-WAY TERMINAL
FAN1 : FAN MOTOR K3 : WATER LEVEL SWITCH
XP1 ˜ 4 : CONNECTORS KM1 : RELAY FOR COMPRESSOR
XS1 ˜ 4 : CONNECTORS CN20 : NET CONTROL INTERFACE
LEGEND : OUTDOOR UNIT
COMP : COMPRESSOR RT3 : OUTDOOR COIL SENSOR
CONT : CONTACTOR FC : FAN CAPACITOR
CTB : COND. TERMINAL BLOCK FM : OUTDOOR FAN MOTOR
OL : OVERLOAD R : RESISTANCE
RVS : 4 WAY REVERSING VALVE C-HTR : CRANKCASE HEATER
LEGEND : TERMINAL BOX
A1 : LIVE CONNECTON W2 : OUTDOOR FAN CONTROL
N1 : NEUTRAL CONNECTON O : REVERSING VALVE CONTROL
Y : COMPRESSOR CONTROL
WIRE COLORS
WH : WHITE OR : ORANGE
BK : BLACK BL : BLUE
BR : BROWN RD : RED
YL : YELLOW YL/ GR : YELLOW / GREEN
NOTES
➀ MAIN SWITCH ➁ TIME DELAY FUSE OR CIRCUIT BREAKER
➂ DOTTED WIRES TO BE FITTED BY INSTALLER ➃ ALL ITEMS IN DASHED RECTANGLES ARE OPTIONAL
➄ THE SYSTEM SHALL BE INSTALLED ACCORDING TO NATIONAL WIRING REGULATIONS
115
17. Optional Accessories For Installation ( Field Supplied )
17.1 Branched Supply Air Front Panel
Branched supply air front panel can be field supplied and installed where
desired by using flexible ducts.
Comfortable air conditioning can be achieved without affecting the rooms
layout or decor.
Installation examples are shown below :
Rectangular Room
L-Shaped Room
Large Room
116
Optional Accessories For Installation ( Field Supplied ) (Cont.)
Branched Supply Air Front Panel (Cont.)
Indoor Branched Supply Air Front Panel
Unit
Size Shape Details
12K
18K
24K
30K
36K
42K
48K
60K
117
Optional Accessories For Installation ( Field Supplied ) (Cont.)
17.2 Convas Air Passage
Indoor Branched Supply Air Front Panel
Unit
Size Shape Details
12K
18K
24K
30K
36K
42K
48K
60K
118
Optional Accessories For Installation ( Field Supplied ) (Cont.)
17.3 Front panel for Ducted Indoor unit size 12K
Front Panel
119
Optional Accessories For Installation ( Field Supplied ) (Cont.)
17.4 Front panel for Ducted Indoor unit size 18K
Front Panel
120
Optional Accessories For Installation ( Field Supplied ) (Cont.)
17.5 Front panel for Ducted Indoor unit size 24K
Front Panel
121
Optional Accessories For Installation ( Field Supplied ) (Cont.)
17.6 Front panel for Ducted Indoor units sizes 30K – 36K – 42K – 48K – 60K
Front Panel
122
18. Troubleshooting
Solving steps for typical malfunction
(1) For indoor unit
a. Indoor air sensor is abnormal
Whether the resistance of the air sensor is 10K No Replace indoor air sensor
Yes
Replace indoor PCB
Whether the resistance of indoor coil sensor is No Replace indoor coil sensor
10K
Yes
Replace indoor PCB
Whether the resistance of outdoor coil sensor is No Replace outdoor coil sensor
10K
Yes
Replace indoor PCB
123
Troubleshooting (Cont.)
Solving steps for typical malfunction (Cont.)
For indoor unit (Cont.)
d. Outdoor unit malfunction
Yes
Measure whether the voltage of the
communication line’s red and black end No Replace outdoor unit board
between the indoor and outdoor unit is +5V
Yes
Check the indoor unit main board CN5 or
replace the main control board
Yes
Replace indoor PCB
e. EEPROM malfunction
EEPROM malfunction
No
Check whether the main control chip 9177
is broken No Replace 9177 chip
No
Check PCB board or replace the main
control board
124
Troubleshooting (Cont.)
Solving steps for typical malfunction (Cont.)
For indoor unit (Cont.)
f. Full-water malfunction
Full-water malfunction
Check whether the water-level switch is No Insert the water-level switch well
inserted well
Yes
Check whether the water-level switch is broken Yes Replace the water-level switch
No
Check whether the water pump is normal No Replace the water pump
Yes
Check PCB board or replace the main control
board
125
Troubleshooting (Cont.)
Solving steps for typical malfunction (Cont.)
(2) For outdoor unit
a. Phase sequence error
Phase sequence error
b. Overload of current
Overload of current
c. Lack of phase
Lack of phase
Yes
Check the connection between power supply and terminal,
is the voltage in outdoor terminal is 3 phase, 380-420V?
Yes
Outdoor PCB is defective
126
Troubleshooting (Cont.)
Solving steps for typical malfunction (Cont.)
For outdoor unit (Cont.)
d. Protection of pressure or temp.
Protection of pressure or temp.
Yes
Is it k1 or K2 open ?
Yes Yes
Possible reason Possible reason
1. The wires is loose to K1 1. The wires is loose to K2
2. Air or other gas in the refrigerant. 2. Air or other gas in the refrigerant.
3. Heat exchanger is dirty 3. Heat exchanger is dirty
4. Outdoor fan or fan blade is defective 4. Outdoor fan or fan blade is defective
5. Outdoor unit is bad ventilation 5. Outdoor unit is bad ventilation
6. Refrigerant is leakage 6. Refrigerant is too much
7. K1 switch is defective 7. K2 switch is defective
Yes
Check the resistance of the temp. sensor according
to Annex 1
Yes
Indoor PCB is defective.
127
Troubleshooting (Cont.)
Solving steps for typical malfunction (Cont.)
For outdoor unit (Cont.)
f. Open-circuit and short-circuit trouble of T4
Is connection to connector of temp. sensor good? No Repair connector
Yes
Check the resistance of the temp. sensor according to Annex 1
Yes
Indoor PCB is defective.
Yes
Possible reason
1. Air or other gas in the refrigerant.
2. Outdoor coil is dirty
3. Outdoor fan or fan blade is defective
4. Outdoor unit is bad ventilation
5. Refrigerant is leakage
6. Outdoor PCB is defective
128
Troubleshooting (Cont.)
Appendix
Sensor Resistance Value Table ( °C – K )
Indoor Air Sensor
Indoor Coil Sensor
Outdoor Coil Sensor
°C K Ohm °C K Ohm °C K Ohm °C K Ohm
-20 115.266 20 12.6431 60 2.35774 100 0.62973
-19 108.146 21 12.0561 61 2.27249 101 0.61148
-18 101.517 22 11.5000 62 2.19073 102 0.59386
-17 96.3423 23 10.9731 63 2.11241 103 0.57683
-16 89.5865 24 10.4736 64 2.03732 104 0.56038
-15 84.2190 25 10.000 65 1.96532 105 0.54448
-14 79.3110 26 9.55074 66 1.89627 106 0.52912
-13 74.5360 27 9.12445 67 1.83003 107 0.51426
-12 70.1698 28 8.71983 68 1.76647 108 0.49989
-11 66.0898 29 8.33566 69 1.70547 109 0.48600
-10 62.2756 30 7.97078 70 1.64691 110 0.47256
-9 58.7079 31 7.62411 71 1.59068 111 0.45957
-8 56.3694 32 7.29464 72 1.53668 112 0.44699
-7 52.2438 33 6.98142 73 1.48481 113 0.43482
-6 49.3161 34 6.68353 74 1.43498 114 0.42304
-5 46.5725 35 6.40021 75 1.38703 115 0.41164
-4 44.0000 36 6.13059 76 1.34105 116 0.40060
-3 41.5878 37 5.87359 77 1.29078 117 0.38991
-2 39.8239 38 5.62961 78 1.25423 118 0.37956
-1 37.1988 39 5.39689 79 1.21330 119 0.36954
0 35.2024 40 5.17519 80 1.17393 120 0.35982
1 33.3269 41 4.96392 81 1.13604 121 0.35042
2 31.5635 42 4.76253 82 1.09958 122 0.3413
3 29.9058 43 4.57050 83 1.06448 123 0.33246
4 28.3459 44 4.38736 84 1.03069 124 0.32390
5 26.8778 45 4.21263 85 0.99815 125 0.31559
6 25.4954 46 4.04589 86 0.96681 126 0.30754
7 24.1932 47 3.88673 87 0.93662 127 0.29974
8 22.5662 48 3.73476 88 0.90753 128 0.29216
9 21.8094 49 3.58962 89 0.87950 129 0.28482
10 20.7184 50 3.45097 90 0.85248 130 0.27770
11 19.6891 51 3.31847 91 0.82643 131 0.27078
12 18.7177 52 3.19183 92 0.80132 132 0.26408
13 17.8005 53 3.07075 93 0.77709 133 0.25757
14 16.9341 54 2.95896 94 0.75373 134 0.25125
15 16.1156 55 2.84421 95 0.73119 135 0.24512
16 15.3418 56 2.73823 96 0.70944 136 0.23916
17 14.6181 57 2.63682 97 0.68844 137 0.23338
18 13.9180 58 2.53973 98 0.66818 138 0.22776
19 13.2631 59 2.44677 99 0.64862 139 0.22231
129