Академический Документы
Профессиональный Документы
Культура Документы
2. A contact sulfuric acid plant produces 98.06% by absorbing SO3 into a 97.3%
sulfuric acid solution. A gas containing 8% SO3 (remainder inerts) enters the SO3
absorption tower at a rate of 28 lbmol/h; 98.5% of the SO3 is absorbed in this tower.
Sulfuric acid (97.3%) is introduced into the top of the tower and 95.9 % sulfuric
acid from another part of the process is used as make up acid?
a. How much make-up acid (95.9%) is required?
b. How much sulfuric acid (97.3%) is introduced into the top of the tower?
c. How much sulfuric acid (98.06%) is produced?
*wala po yung figure sa board exam, naka-describe lang po kung ano yung
figure.
5. A metal plating firm is installing a precipitation system to remove zinc. They plan
to use a pH meter to control the feed of hydroxide solution to the mixing tank. What
pH should the controller be set at to achieve a zinc effluent concentration of 0.80
mg/L. the Ksp of Zn(OH)2 is 7.68 x 10-17 ?
6. What are buckyballs? (fullerene daw po yung answer)
7. Deacetylation reaction of histone
8. Which of the following is an elastomer? (chloroprene, neoprene, silicone,
polyurethane)
9. What is the role of sodium hexametaphosphate in a boiler?
10. What is the main advantage of SCADA (Supervisory Control and Data
Acquisition)?
11. What is the significance of the Boltzmann Constant?
12. What plant is vanilla derived from? *orchid
13. A steel tube with inner diameter of 125.1 mm is placed over an aluminum tube with
inner diameter of 120 mm. There is a 0.05 mm radial clearance. Each tube is 2.5
mm thick. Modulus of elasticity for aluminum = 70 GPa, and for steel = 200 GPa
a. Find the internal pressure experienced by the aluminum when the tubes are in
contact
b. When the internal pressure is 5 MPa, calculate the pressure of contact.
c. What is the force of contact when the internal pressure is 5 MPa?
14. A truss is supported at points A and D. A load of 450kN is applied in the middle.
Members AB and BD are 30° inclined from the horizontal, forming an isosceles
triangle. Another 450kN is applied at point B towards member BD. (di ko na po
matandaan yung questions)
15. Describe gluconeogenesis? (pero yung nasa choices po ay comparison ng sizes ng
ions)
16. How many electrons must be removed by the following elements (nakalimutan ko
po yung elements) to have the same electron configuration as the nearest noble gas?
(yung nasa choices po ay yung mismong noble gases)
17. 100 g of ice was dissolved in water (26.5 ºC)
a. How much heat was absorbed by the ice?
b. What is the amount of water used to dissolve 100 g of ice?
c. If water at 25 ºC was used, what is the final temperature?
18. What is the temperature of the moon (may given po na rate of radiation at the top
atmosphere ng Earth) assume the effects of greenhouse gases and the emissivity of
the atmosphere? *wala na pong ibang given