Академический Документы
Профессиональный Документы
Культура Документы
Section 1. DANGER
Section 2. WARNING
Section 3. NOTICE
Section 5. WARRANTY
-2-
DANGER
Keep the TIRE AIR PRESSURE in regulated value.
The maximum air pressure is marked on the surface of
ALUX WHEEL. lf tire air pressure is higher or lower than
the regulation, it can cause tire explode or reduce the life
cycle of wheel & other parts.
-3-
WARNING (Ⅰ)
-4-
WARNING (Ⅱ)
-5-
WARNING (Ⅲ)
-6-
NOTICE
-7-
Hub Piloted Mounting (ISO-TYPE) Stud Located Ball Seat Mounting (JIS-TYPE)
8
AIR VALVE INSTALLATION
AIR VALVE INSTALLATION AIR VALVE INSTALLTION NOTICE
Bending
1) Take out the Air valve on the bottom
Type Valve
in the packaging box.
2) Separate CAPs from the Valve.
3) Separate Nuts from the Valve.
4) Check the O-RING on the Valve.
5) Check the insert position of the Valve
Linear
on the Forged Wheel and insert to the
Type Valve
Valve with O-ring. Apply the proper
vaccum grease inside and outside of
the holes.
6) After Valve insert and fix the upper
parts, and assemble the Nuts with
the pictures shown.
7) Fasten Nuts with torque 9~14.6 N.m Air Leakage Cases:
by TRA specification. Improperly assembled Air Valve can cause O-RING
damage, cause the Air Leakage. Especially,
8) Afer Air Valve installation, assemble if the Valve circles around and around when assembling
the Valve, the O-RING can turn around together which
with Tire, and inflate with specifications
can cause damage. As O-RING is heat-harden by use,
and close the cap. It should be replaced when replacing Tire.
-9-
Wheel & Tire SPEC.
- 10 -
WARRANTY
ALUX warrants to the original purchaser from ALUX or its authorized distributor thar the truck
wheel is free from defects in material and workmanship.
ALUX agrees, without any payment, to repair or replace a wheel which fails in normal use and
service because of defects in material or workmanship. Wheels are warranted for 5years
from date of manufacture as shown on the wheel(except rust, scratch and finishing condition).
ALUX does not warrant and will not repair or replace or make adjustment with respect to normal
wear or for any wheel which has been damaged or subject to misuse or abuse including, without
limitation, the following:
ALUX shall not be liable for any incidental or consequential damages for any for any
breach of warranty, its liability and the purchaser's exclusive remedy being expressly
limited to repair or replacement of the wheel.
- 11 -
-1 3-