Академический Документы
Профессиональный Документы
Культура Документы
Appl. Supervisor
Master
Standard
Mode
WTX110
< 3 seconds
WTX110 V#.#.#
< 3 seconds Navigation Pilot
Password General Products Weight Storage Logbook Software ID MAC-/IP-Address
Enter service
password
Date: Entry Target weight Search Date 3_ ... ID: ... M:
Time: Entry ... Id-No. 2_ ... IP:
… Weight not found 1_...
Brightness
Filler configuration; only info
Password parameter
only available note: only if
in filler application ALI available
Interface General Calibration Config. Test Reset Network Backup General Setup Limit switches Digital IO Print Formats Factory defaults Mode: Info Mode: Adapt
(zero offset) (several
note: if „W1“ jumper filter settings)
is in position 1
Language only access, Scale Digital IO Reset Service IP Backup or Application LS1 – LS4 Source Input 1 – 4 Ticket Weight Load application
Com0 (Eth) Com1 (SIM1) Com6 (DWB) no changes possible
Keyboard Serial IO Mode Parameters? Mask Restore LS1 – LS4 Mode Output 1 – 4 Total Weight
Reset from USB
Time Zone (1) Calibrate Scale 1 Gate Ticket Count
Approved Wgt note: after
Time Zone (2) DNS change restart Total Count
Port Baud Baud only available in
Date (format only) NTP note: ETH required!
Protocol Databits Databits standard application
Time (format only) FTP pwd or USB option Language
Parity Parity note: only if
Mastermode error protocoll, required
Country Code ALI available PanelX access
Ctrl. Ctrl. note: alternative only info
Decimal char. access Access number
Protcl. Protcl.
Approval signs Set PanelX password
Tare mode Update SSL cert
Cont. out. Start auto ping
Light off (Min.) Terminal No.
Power off (Min.) Config. Config.
Config. Scale
Power Supply Digital IO Analog out
Serial No.
1 Scale 2 Calibration 3 Linearization 4 Zero Adjust 5 Adaption 6 High 7 Reset 8 Calculation 9 W&M Info
Select Group 1 – 9 Parameters Resolution Span