Академический Документы
Профессиональный Документы
Культура Документы
1
1. What type of tool that can cause extreme heat and can burn the skin?
A. Auxiliary tool C. Cutting tool
B. Boring tool D. Soldering tool
2. Who is the original inventor of the magnifying glass?
A. Ernst Sacks C. Paul Eisler
B. Meng Tian D. Roger Bacon
3. A device that generates electronic signals and wave forms which are either
repetitive or non-repetitive depending upon the requirement and field of
application.
A. Electromagnetic signal C. Oscilloscope
B. Multi-meter D. Signal generator
4. What type of screw driver used to drive or fasten positive slotted screws.
A. Jeweler’s Screwdriver C. Slotted Screwdriver
B. Phillip’s Screwdriver D. Stubby Screwdriver
5. Which electronic tools used to thin off excess component on the circuit
board?
A .Allen Wrench C .Side Cutter
B. Long Nose pliers D. Wire Stripper
6. What happens when you receive an electrical shocks?
A. Heart Burn
B. Unfrozen muscles
C. You’ll be able to release a tool, wire, or other energized object
D. Loss of muscular control lack of ability to release an electrical
conductor
7. In a workplace, it is important to have safety and health regulation, policies,
and procedures. What regulation should be follow?
A. Keep the place crowded
B. Keep the working area unclean
C. Keep the hand tools inside the tool cabinet, cabinet, and tool box
D. Keep the floor area from waste, water and grease
8. Why is there a need to wear personal protective equipment while working?
A. It causes damage
B. It give satisfaction and overwhelming factor
C. It provides safety and reduces a workers exposure to hazards
D. It maximize industrial noise and determine the nature of any available
hazard and the risk that are not involved
9. Which of the following is Occupational Health Safety Policies?
I. Always use protective equipment while performing a job
II. be aware of caution, warnings, and instructions
III. Engage play while at work
IV. Keep flammable materials and substances away
17. After drilling the components, what should be the next step?
A. Remove the toner with acetone
B. Tin all parts where a component is going to be soldered
C. Clean the polish and the remain toner with a paper moisten in
acetone.
D. Then solder all the components in place and clean the remaining flux or
resin.
22. If Lailani applied the so-called pre-tinning, how should be the process be?
A. Lailani cleans the soldering tip using files, sand paper or a cutter.
B. Lailani checks the temperature of the tip before soldering is made.
C. Lailani applies a little amount of soldering lead and soldering flux to the tip
during pre-heating of the soldering iron.
D. Lailani allows his soldering iron to heat at least 40 minutes before he uses
it and solders with the terminal of the component.