Академический Документы
Профессиональный Документы
Культура Документы
The information given is to the best of our knowledge true and is intended for general guideline. However, any recommendations or suggestions made are without guarantee,
since the condition of use is outside our control.
RIPEX APPLICATION HR newly developed
CYCLIZED RUBBER RESIN RIPEX APPLICATION developed
CYCLIZED RUBBER RESIN
RIPEX L not only improves the setting and drying of lithographic inks, but it
The modern high speed printing machinery requires inks which set very
also confers improved working properties, resistance to fountain solutions
rapidly. Inks based on RIPEX cyclized rubber resins in solution with drying
when these are acidic as the result of chemical additions. When good
oils and high boiling petroleum cuts, give ideal media for rapidly setting
finish and gloss are required RIPEX L should be used together with hard
inks. These resins are excellent additives for majority of inks as they assist
resins. Improved set, working conditions, and resistance to set-off in offset
setting and diminish tack even when only small amounts are employed.
ink is obtained by substitution (10-15%) of the resin with RIPEX L.
Cyclized rubber resins, however, tend to increase the tendency of ink to
mist when used in excess, or when formulation is not properly balanced. It
• GRAVURE INKS
was established that misting is connected to a large degree with the
viscosity of the resin solution and we recommend to use low viscosity RIPEX
A good and reasonably cheap vehicle for gravure ink can be made from
L in ink formulations in order to minimize this inconvenience.
almost neutral resinate of high melting point blended with in ratio of 6
parts to 1 part of RIPEX L. The use of 5-10% RIPEX L on the total resin
• LETTERPRESS INKS
content of a gravure ink based on petroleum or aromatic hydrocarbons,
will improve the grinding rate in ball mill, and will assist suspension of the
High quality letterpress inks are prepared by adding RIPEX L to conventional
pigment on storage. Gravure inks based solely on RIPEX L set rapidly and
ink vehicles. Substitution (5-10%) of the used resin with RIPEX L will give an
have good flexibility. Metallic inks based on RIPEX L resins give excellent
ink improved set and remove some of the tack which causes set-off on
brightness and stability.
stacking or handling of fresh print. In addition such inks have better flow,
gloss, abrasion and chemical resistance. Low viscosity bodied oils ( 1 - 5
• MISCELLANEOUS USES
poise) in combination with RIPEX L in high boiling petroleum cuts give inks
of extremely rapid set.
RIPEX L together with soya alkyds proved to be very useful vehicle for
serigraphic inks. RIPEX L is also a useful additive to improve adhesion of
certain inks to difficult surfaces such as polyethylene, cellophane and
cellulose acetate.
The information given is to the best of our knowledge true and is intended for general guideline. However, any recommendations or suggestions made are without guarantee,
since the condition of use is outside our control.
RIPEX APPLICATION no. MMfQMttM
CYCLIZED RUBBER RESIN RIPEX APPLICATION BR newly developed
CYCUZED RUBBER RESIN
The information given is to the best of our knowledge true and is intended for general guideline. However, any recommendations or suggestions made are without guarantee,
since the condition of use is outside our control.