Академический Документы
Профессиональный Документы
Культура Документы
Section A
Q.1: 20 Nos. of small answer type question asked in which 10 questions (each 01
marks) identify name of the symbols given whether another 10 questions (each 01
marks) from basic fundamentals of drawing related questions.
Q.2: Draw the assembly drawing in cross sectional elevation of the flanged
coupling, Unprotected type whose details is given in Fig.2. Take scale of 1:1.
Q.3(a): Draw with standard dimensions slip-on flange(Table-H) for carbon steel
pipe of Nominal bore 100mm and OD 116mm with following details.
W.P.=14kg/cm2, PCD=190mm, Bolt size=16mm, Flange OD=230mm & Flange
thickness=25mm.
Answer :
Answer :
Q.3(c): Draw the hemispherical end cap for pipe of nominal size 100mm,
OD=116mm, Straight Face=20mm. Write the thickness of cap.
Answer :
Part Name :
A [Thread size] = 10mm
B [Overall bolt length] =194.2mm
C [Center axle to center of pipe] =69.mm
D [Overall stud height] =152.4mm
E [Center of chair]
Q.3(f): Draw the explosion door of economizer of size 600mm width and 900mm
height.
Answer :
Answer :
Q.3(h): Draw the steam separator for 100mm steam pipe line.
Answer :