Plug Adjusting the Set Pressure Manual Override Conversion Cap !Warning: Relieve system pressure before installing Note: Adjust the set pressure before installing the Spring valve in a system. manual override handle. Handle 1. Loosen lock nut and remove cap from bonnet. Set 1. Thread cap onto the bonnet 10 full turns. Screw Sleeve 2. Remove plug from cap. 2. Tighten lock nut against the cap and test for pres- sure. 3. Remove spring from bonnet. Lock Wire Hole 4. Remove sleeve by pulling up on base of sleeve Cap 3. Relieve system pressure, unthread cap as need- ed, and retest. Repeat procedure as necessary to with hooked tool. Lock Nut obtain desired set pressure. 5. Remove spring support disc. Label Spring Support 4. Tighten lock nut against the cap. 6. Install pull rod into bonnet. Disc 5. Lock wire cap and body together to maintain set 7. Install sleeve by compressing it with a suitable Bonnet pressure. tool and pushing it down into bonnet. 8. Place spring over pull rod. Lock Wire Hole 9. Place cap over pull rod, resting it on bonnet. 10. Screw handle onto pull rod. Tighten set screw Pull Rod on handle to 20 in.·lb (2.2 N·m) with 5/64 in. hex wrench. 11. Engage cap threads. Spring Proceed to “Adjusting the Set Pressure” Body CRD0055 10/23/03 10:49 AM Page 2