Академический Документы
Профессиональный Документы
Культура Документы
4. EE Board Exam April 1992 11. REE Board Exam April 1997
The stator of a 440 V, 50 HP shunt motor is tested at Which of the following instrument is suited for high
75°C for its insulation resistance between terminals frequency measurements?
connected together and the ground frame. When a A. thermocouple C. moving iron vane
50,000 ohm voltmeter is connected in series with a B. dynamocouple D. oscilloscope
600 V DC source, the meter indicates 125 V.
Calculate the insulation resistance. 12. REE Board Exam April 1997
A. 170 kΩ C. 180 kΩ What does a voltmeter indicate?
B. 190 kΩ D. 200 kΩ A. total current
B. coulombs per second
5. EE Board Exam October 1986 C. potential difference
The Meralco test of a 10 A wattmeter having a D. resistance per meter
constant of 0.4, the disk makes 40 revolutions in 53.6
seconds. The average volts and amperes during the 13. REE Board Exam October 1996
period of test are 116 volts and 9.4 A. What is the In addition to supporting the moving coil, the
percent accuracy of the meter at this load? aluminum bobbin in a permanent moving coil meter
A. 97.45% C. 98.07% performs the function of one of the following. Which
B. 98.58% D. 96.44% one is this?
A. reduce the reluctance
6. EE Board Exam April 1992 B. balance the pointer
In a test of a 10-ampere watthour meter having a C. conducts magnetic flux lines
constant of 0.40, the disk makes 40 revolutions in 55 D. dampens the needle movement
seconds. The average volts and amperes during this
period are 116 volts and 10 amps. Determine the 14. REE Board Exam October 1996
percent accuracy of this meter at this load. What effect on the pointer operation if any, will
A. 92.34% C. 83.46% reversing the leads of a DC permanent moving coil
B. 91.03% D. 90.28% instrument have, when taking the readings?
A. The pointer swings to the opposite direction.
7. REE Board Exam March 1998 B. It still indicates correctly.
A power plant customer draws power at 220 volts C. It indicates maximum value.
from transformers on a pole. Current transformers D. The needle oscillates back and forth.
with a ratio of 200/5 are used to meter the electrical
usage. What is the multiplier of the kW-hr and 15. EE Board Exam April 1995
demand meters? The damping force acts on the moving system of an
A. 40 C. 100 indicating instrument only when it is
B. 200 D. 80 A. stationary
B. just starting to move
C. moving
D. near its full deflection
A. C.
16. EE Board Exam October 1993 B. D.
Which meter used dual triode tube and requires
external power for operation? 25.
A. TVM C. VOM
B. FETVM D. VTVM A. C.
B. D.
17. EE Board Exam October 1993
A meter device that tests insulation resistance is the 26.
A. megohmmeter C. gauss meter
B. transistor checker D. voltage tester A. C.
B. D.
18. EE Board Exam April 1992
An instrument often used to check the degree of 27.
motor shaft misalignment is the
A. dial indicator C. voltmeter A. C.
B. clamp-on ammeter D. megohmmeter B. D.
31.
A. C.
B. D.
32.
22.
A. C.
B. D.
23.
A. C.
B. D.
24.