Академический Документы
Профессиональный Документы
Культура Документы
For product description refer to product data sheet HEMPADUR PRIMER 15360.
Film thickness: Depending on the area of use the typical dry film thickness may vary between 15 micron/0.6 mil and up to
50 micron/2 mils. This will alter amount of thinning needed, spreading rate, drying time and overcoating
interval as described below.
Shopprimer, container When used as a shopprimer in container systems a typical dry film thickness is 15 micron/0.6 mil. Dilute
systems: 100-150% for airless spray, corresponding wet film thickness 60-75 micron/2.4-3 mils. (Note: In the case
of a high degree of thinning, the mixture is to be stirred constantly and recirculate until all paint has been
used).
Primer, container When used as a general purpose primer, dry film thickness is 30-40 micron/1.2-1.6 mils corresponding to
systems: 60-80 micron/2.4-3.2 mils wet film thickness. Dilute 5-10% for airless spray.
Spreading rates: The film thickness and the spreading rate are inversely proportional. By controlling the spreading rate, the
film thickness can be controlled.
Thinners: Airless spray: THINNER 08450 or 08570. Lowest nozzle pressure should be used when highest amount
of thinner is added. THINNER 08570 is used for fast setting at application in shops. (Be aware of
increased risk of dry spray).
Stirring: Before mixing with the curing agent stir the base thoroughly in order to redisperse any possible settling
after storage. After mixing it is equally important to maintain stirring to keep the wet paint as a
homogeneous mixture.
This is specifically important in case of a high level of thinning and/or long break in application, where the
risk of settlement of zinc particles is the highest.
Physical data Drying time and overcoating interval vary with film thickness, curing agent used, drying/curing
Versus temperature: temperatures and later exposure conditions.
Shorter minimum overcoating intervals when overcoated with 18300, 45200, 46330, 46370 and 46410
are provided in case the finished paint system is through dry before exposure to the environment.
Safety: Handle with care. Before and during use, observe all safety labels on packaging and paint containers,
consult HEMPEL Material Safety Data Sheets and follow all local or national safety regulations. Avoid
inhalation, avoid contact with skin and eyes, and do not swallow. Take precautions against possible risks
of fire or explosions as well as protection of the environment. Apply only in well ventilated areas.