Академический Документы
Профессиональный Документы
Культура Документы
Feature Description
Disclaimer
The contents of this document are subject to revision without notice due to
continued progress in methodology, design and manufacturing. Ericsson shall
have no liability for any error or damage of any kind resulting from the use of this
document.
Trademark List
All trademarks mentioned herein are the property of their respective owners.
These are shown in the document Trademark Information.
Contents
1 Overview 1
2 Dependencies 2
3 Feature Operation 3
4 Network Impact 5
5 Parameters 6
6 Performance 7
Summary
The Downlink Coordinated Multi-Point feature makes it possible to get a higher
data throughput for interfered UEs. It enables the efficient use of network
resources and achieves higher user experience for the interfered UE. The benefit
of the feature is achieved by transmitting data on a higher bit rate to an
interfered UE. This is done by coordinating the serving and interfering cells.
The feature increases downlink throughput for cell edge users in interfered radio
environment with high intercell intra-frequency interference. The feature
improves cell edge throughput in a heterogeneous network, macro deployment,
and indoor deployment, where the overlap between the cells is large.
Additional Information
More information about this feature and related topics can be found in 3GPP TS
36.331, Event A5.
Hardware
This feature is not supported on AIR 6454 units.
Limitations
Inter-DU coordination is not supported.
The number of UEs to be coordinated is limited if there is a high load on the main
processor, due to rejected event A5.
Network Requirements
No network requirement for this feature.
The feature uses downlink transmission information from serving and interfering
cells to coordinate and improve the downlink link adaptation.
L0001071A
L0001072A
Operational Process
Event A5
Configuration UEs with
poor SINR are Scheduling and
identified Link Adaptation
L0001073C
Interfaces
No impact.
Table 2 Parameters
Parameter Type Description
EUtranCellFDD.dlInte Introduced See MOM description.
rferenceManagementDu
ration
Note:
Consult the next level of
maintenance support for
custom values.
EUtranCellTDD.dlInte
rferenceManagementDu
ration
Note:
Consult the next level of
maintenance support for
custom values.
DlComp.dlCompMeasRpr
tMinSinr
DlComp.dlCompMeasRpr
tMaxSinr
KPIs
The table lists the main KPIs associated with the feature, and the expected
impact.
Counters
— EUtranCellFDD.pmRrcConnReconfAttNoMobDlComp
— EUtranCellTDD.pmRrcConnReconfAttNoMobDlComp
— EUtranCellFDD.pmRrcConnReconfSuccNoMobDlComp
— EUtranCellTDD.pmRrcConnReconfSuccNoMobDlComp
— EUtranCellFDD.pmMeasRepDlComp
— EUtranCellTDD.pmMeasRepDlComp
— EUtranCellFDD.pmMeasRep
— EUtranCellTDD.pmMeasRep
— EUtranCellFDD.pmConfigRejDlComp
— EUtranCellTDD.pmConfigRejDlComp
— EUtranCellFDD.pmMeasRepDiscDlComp
— EUtranCellTDD.pmMeasRepDiscDlComp
— EUtranCellFDD.pmDeltaSinrDlComp
— EUtranCellTDD.pmDeltaSinrDlComp
— EUtranCellFDD.pmMaxDeltaSinrDlComp
— EUtranCellTDD.pmMaxDeltaSinrDlComp
Events
Table 4 Events
Event Event Parameter Description
INTERNAL_EVENT_DL_ EVENT_PARAM_RRC_C The reason why Radio
COMP_MEAS_CONFIG_ ONFIG_REJECT_CAUSE Access Control (RAC)
REJECT rejects Baseband request
for Downlink
Coordinated Multi-Point
measurement
configuration.
INTERNAL_EVENT_DL_ EVENT_PARAM_MEAS_ The reason why RAC
COMP_MEAS_REP_DIS REP_DISCARD_CAUSE discards Downlink
CARD Coordinated Multi-Point
measurement reports
from the UE.
Prerequisites
— Continuous Cell Trace Recording (CCTR) is activated since at least one week.
This ensures there is troubleshooting data available if something goes
wrong.
Steps
Prerequisites
Continuous Cell Trace Recording (CCTR) is activated since at least one week. This
ensures there is troubleshooting data available if something goes wrong.
Steps
This section lists changes that affected this feature and the impact it had on
network.
Note: Consult the next level of maintenance support for the custom values of
the new attributes.
Operation
The following features are affected by the new attributes. Click the feature
names to access the related Feature Description guides. Click the attribute names
to view the related MOM descriptions.
rachNoOfAllocationsPerFr EUtranCellFDD
ame EUtranCellTDD
Random Access
EUtranCellFDD
rachPreambleRepetition
EUtranCellTDD
Coverage-Adapted LoadBalancingFunct
lbHitRateFilterCoeffCalm
Load Management ion
dlInterferenceManagement EUtranCellFDD
Duration EUtranCellTDD
Downlink Coordinated
Multi-Point dlCompMeasRprtMinSinr DlComp
dlCompMeasRprtMaxSinr DlComp
The following functions are affected by the new attributes. Click the attribute
names to view the related MOM descriptions.
Interfaces
No impact.
Hardware
No special hardware requirements.