Академический Документы
Профессиональный Документы
Культура Документы
g
buildin
All holes shall be drilled and shall be 2mm larger than the bolt
diameter U.N.O. Holes in baseplates may be 5mm larger than the
bolt diameter U.N.O. All bolts shall have at least one thread
projecting through both sides of the nut.
Bolt spacing, edge distances, gauge lines, beam copes etc, to
oom
classr d
conform to A.I.S.C standardised connections U.N.O.
School Existing Playing Ground
se
Remove all sharp edges and burrs.
existing
Propo
S5. Unless otherwise noted, all welds to be 6 mm continuous
fillet from E41XX electrodes.
building All welds shall be general purpose welds unless noted
otherwise.
Structural purpose welds shall be denoted thus `SP'.
School Butt welds where indicated in the drawings are to be
complete penetration butt welds as defined in AS 1554.
existing Welding symbols to AS 1101 Part 3.
building S6. Concrete encased steelwork shall be wrapped with 665 mesh
and have a minimum of 50 cover unless noted otherwise.
S7. High strength friction grip bolts, nuts and washers shall
comply with the relevant requirements of AS 1252, shall be
installed in accordance with AS 1511 and shall be tightened
to the correct tension using approved load indicating
washers. Contact surfaces of all high strength friction grip
School bolted connections shall be left unpainted.
existing S8. Structural steelwork shall have the surface treatment in
accordance with the specification.
building
ELEMENT SURFACE PRIMING
CLEANING
TOTAL PERIMETER OF
All Sand blast to As Noted
FENCE 318 METERS UNO class 2.5 Elsewhere
School S9.
NOTE: Concrete encased steelwork shall be left unpainted.
The builder shall provide all cleats and drill all holes
existing School
existing
SITE MAP necessary for fixing steel to steel and timber to steel
whether or not detailed in the drawings.
building
building Scale: NTS S10. All the requirements of the A.C.S.E. Structural Steel
Specification Document 2 shall apply.
S11. All fxing devices bolts , brackets etc shall be
hot dipped galvanised
Copyright reserved in all drawings and the work executed from them. CLIENT PROJECT AND LOCATION: ACE CONSULTANCY DESIGN DRAWN DATE SHEET TITLE SCALE SHEET NUMBER
Figured dimensions shall be read in preference. Largest scaled ILLIA COMMUNITY HIGH SCHOOL
PROPOSED NEW CHAINLINK C/-P O BOX 2024
HONIARA, SOLOMOM ISLANDS
drawings shall take precedence. Check all dimensions on site. All FENCE FOR ILLIA COMMUNITY HONIARA, SOLOMON ISLANDS
discrepancies shall be reported to the Consultant immediately HIGH SCHOOL, HONIARA Mobile: 677-7406500
Email: andrewaraha@gmail.com ARAHA.A ARAHA.A 04/08/2020
SITE MAP AS SHOWN A01
LOGO\ACE-print.jpg
..\..\..\Desktop\ACE
ISSUE FOR FUNDING PROPOSAL
Copyright reserved in all drawings and the work executed from them. CLIENT PROJECT AND LOCATION: ACE CONSULTANCY DESIGN DRAWN DATE SHEET TITLE SCALE SHEET NUMBER
Figured dimensions shall be read in preference. Largest scaled ILLIA COMMUNITY HIGH SCHOOL
PROPOSED NEW CHAINLINK C/-P O BOX 2024
HONIARA, SOLOMOM ISLANDS
drawings shall take precedence. Check all dimensions on site. All FENCE FOR ILLIA COMMUNITY HONIARA, SOLOMON ISLANDS
discrepancies shall be reported to the Consultant immediately HIGH SCHOOL, HONIARA Mobile: 677-7406500
Email: andrewaraha@gmail.com ARAHA.A ARAHA.A 04/08/2020
Typical Fence 3D AS SHOWN A02
LOGO\ACE-print.jpg
..\..\..\Desktop\ACE
ISSUE FOR FUNDING PROPOSAL
3000 3000 3000 3000
Y D3
A04 A04
Barb wire
150150
Barb wire
Galvanized
running wire
40mmØx3mm
thick galvanized
Pipe
Galvanized
running wire
2400
Chainlink
50
300x300x500
deep footing
500
D2
TYPICAL FENCE ELEVATION D1 A04
Scale: 1:40 A04
NOTES
Provide brace after every 2 posts and all corners posts
Apply oxide paint to all weld areas
All steel fencing work to be galvanized, unless otherwise stated
Copyright reserved in all drawings and the work executed from them. CLIENT PROJECT AND LOCATION: ACE CONSULTANCY DESIGN DRAWN DATE SHEET TITLE SCALE SHEET NUMBER
Figured dimensions shall be read in preference. Largest scaled ILLIA COMMUNITY HIGH SCHOOL
PROPOSED NEW CHAINLINK C/-P O BOX 2024
HONIARA, SOLOMOM ISLANDS
drawings shall take precedence. Check all dimensions on site. All FENCE FOR ILLIA COMMUNITY HONIARA, SOLOMON ISLANDS
discrepancies shall be reported to the Consultant immediately HIGH SCHOOL, HONIARA Mobile: 677-7406500
Email: andrewaraha@gmail.com ARAHA.A ARAHA.A 04/08/2020 ELEVATIONS
AS SHOWN A03
LOGO\ACE-print.jpg
..\..\..\Desktop\ACE
ISSUE FOR FUNDING PROPOSAL
2 rows
150150
barb wire
Galvanized
40mm Ø
wire no. 8 Galvanized 40mm Ø
20
post Galvanized
post brace
46
GL GL
1194
8
2 no. D12x200mm 2 no. D12x200mm
500
long steel rod weld long steel rod weld
diagonally at bottom diagonally at bottom
25 Mpa
Concrete 5 0
Galvanized 25 Mpa 2
wire no. 8 Concrete footing
footing 300
40mmØx3mm
thick galvanized D1 DETAIL 1 D2 DETAIL 2
A03 Scale: 1:20 A03 Scale: 1:20
1194
Pipe
galvanized
posts
Galvanized
wire no. 8
57
2 strands of barb
2 no. D12x200mm wire spacing @
150mm
500
186
diagonally at bottom to top of fence post
and brace both sides
Concrete 300
footing 40mm Ø
70
Galvanized 40mm Ø
Y-Y Section Y-Y post brace Galvanized
post
A03 Scale: 1:20 D3 DETAIL 3
A03 Scale: 1:20
Copyright reserved in all drawings and the work executed from them. CLIENT PROJECT AND LOCATION: ACE CONSULTANCY DESIGN DRAWN DATE SHEET TITLE SCALE SHEET NUMBER
Figured dimensions shall be read in preference. Largest scaled ILLIA COMMUNITY HIGH SCHOOL
PROPOSED NEW CHAINLINK C/-P O BOX 2024
HONIARA, SOLOMOM ISLANDS
drawings shall take precedence. Check all dimensions on site. All FENCE FOR ILLIA COMMUNITY HONIARA, SOLOMON ISLANDS DETAILS
discrepancies shall be reported to the Consultant immediately HIGH SCHOOL, HONIARA Mobile: 677-7406500
Email: andrewaraha@gmail.com ARAHA.A ARAHA.A 04/08/2020
AS SHOWN A04
LOGO\ACE-print.jpg
..\..\..\Desktop\ACE
ISSUE FOR FUNDING PROPOSAL