Академический Документы
Профессиональный Документы
Культура Документы
CHECKED BY:
TECH RECORDS
FORM NO.IGO/E&M/A320/8D/42A
8 DAY INSPECTION SCHEDULE
(AIRBUS A320 AIRCRAFT WITH V2527-A5 ENGINES)
APPROVAL IGO/E&M/Approval/Insp.Sch/57 dated 15.02.2017 EFFECTIVITY: IGO ALL
MANPOWER DETAILS
CERTIFYING STAFF
TECHNICIANS
SIGNATURE WITH
SN NAME EMP. ID SHORT SIGN.
DATE
FORM NO.IGO/E&M/A320/8D/42A
8 DAY INSPECTION SCHEDULE
(AIRBUS A320 AIRCRAFT WITH V2527-A5 ENGINES)
APPROVAL IGO/E&M/Approval/Insp.Sch/57 dated 15.02.2017 EFFECTIVITY: IGO ALL
ISSUE: 12 Rev 00 DATED: 15.02.2017
INTERVAL To be performed once every 8 days or 120 FH whichever is earlier
PAGE: 4 of 22
FLIGHT REPORT
SECTOR FLOWN TIME IN AIR OIL UPLIFT (QTS.)
NO. OF
SN DATE OF FLIGHT FLIGHT NO.
FROM AIRBORNE TOUCH DOWN IN AIR LDGS. ENG 1 ENG 2 APU
TO
1
10
11
12
TOTAL
PREVIOUS DAY RECORD CURRENT DAY RECORD TOTAL NOTE: THIS FLIGHT TIME LOG IS TO BE FILLED AND CERTIFIED BY THE APPROVED/AUTHORISED PERSON
SIGN
A/C LANDINGS DATE TIME APP. / AUTH. STAMP CAT
(CERTIFYING STAFF)
FORM NO.IGO/E&M/A320/8D/42A
8 DAY INSPECTION SCHEDULE
(AIRBUS A320 AIRCRAFT WITH V2527-A5 ENGINES)
APPROVAL IGO/E&M/Approval/Insp.Sch/57 dated 15.02.2017 EFFECTIVITY: IGO ALL
460007280 /
16 GROUND LOCK SLEEVE OF MLG DOWNLOCK 2
DRT68923
FORM NO.IGO/E&M/A320/8D/42A
8 DAY INSPECTION SCHEDULE
(AIRBUS A320 AIRCRAFT WITH V2527-A5 ENGINES)
APPROVAL IGO/E&M/Approval/Insp.Sch/57 dated 15.02.2017 EFFECTIVITY: IGO ALL
ARRIVAL
1 Install the wheel chocks.
AF
REF: AMM TASK 10-11-00-555-015
2 Install the nose landing gear and the main landing gear ground lock safety
devices (as necessary). REF: AMM TASK 32-00-00-481-001 AF
3 If aircraft towing is required, place the towing lever in the "towing position"
and install pin. AF
REF: AMM TASK 09-10-00-860-092
8 If ‘STS’ has appeared on the upper ECAM DU, check for messages in the
maintenance section of the STATUS page on the lower ECAM DU. Start AF
corrective actions as required.
9 ENGINE OIL
(MPD 791000-I1-1-IGO) REF: AMM TASK 12-13-79-610-011
Continued…
SIGNATURE
AUTH. STAMP
(CERTIFYING STAFF)
FORM NO.IGO/E&M/A320/8D/42A
8 DAY INSPECTION SCHEDULE
(AIRBUS A320 AIRCRAFT WITH V2527-A5 ENGINES)
APPROVAL IGO/E&M/Approval/Insp.Sch/57 dated 15.02.2017 EFFECTIVITY: IGO ALL
SKILL CERTIFYING
SN DESCRIPTION TECH
CODE STAFF
i. For NON-EDTO A/C:
Do a check of engine oil level as per AMM 12-13-79-610-011
and replenish, if required. Record the uplift in the aircraft
technical log.
SIGNATURE
AUTH. STAMP
(CERTIFYING STAFF)
FORM NO.IGO/E&M/A320/8D/42A
8 DAY INSPECTION SCHEDULE
(AIRBUS A320 AIRCRAFT WITH V2527-A5 ENGINES)
APPROVAL IGO/E&M/Approval/Insp.Sch/57 dated 15.02.2017 EFFECTIVITY: IGO ALL
SKILL CERTIFYING
SN DESCRIPTION TECH
CODE STAFF
11 HYDRAULIC RESERVOIR QUANTITY CHECK
Do a fluid level check of the Green, Blue and Yellow hydraulic reservoirs AF
(On ECAM LOWER DISPLAY, HYD page).
Add hydraulic fluid to the reservoirs as necessary. Record uplift(s)
Do a general visual inspection of the lower half of the fuselage from ground
as far as visible, including:
SIGNATURE
AUTH. STAMP
(CERTIFYING STAFF)
FORM NO.IGO/E&M/A320/8D/42A
8 DAY INSPECTION SCHEDULE
(AIRBUS A320 AIRCRAFT WITH V2527-A5 ENGINES)
APPROVAL IGO/E&M/Approval/Insp.Sch/57 dated 15.02.2017 EFFECTIVITY: IGO ALL
SKILL CERTIFYING
SN DESCRIPTION TECH
CODE STAFF
Radome: No damage, latches engaged and locked
Crew oxygen cylinder overpressure indicator: Green disc in place
(Near access door 812)
LP/HP GRD connection panels – CLOSED
Ram air inlet flap AF
Ram air intakes and outlets: No obstruction
Inspect the belly fairing access panels for missing fasteners.
Ensure that there are no signs of corrosion, cracks or damage.
Do a general visual inspection of the main landing gear well and hydraulic
AF
compartment as far as visible for condition like damage, cracks & corrosion:
Components: Installation, hydraulic fluid leakage
Doors: Structure, hinges, up-lock assy and operating mechanism
All the installations (wiring, ducting, piping) are attached correctly
SIGNATURE
AUTH. STAMP
(CERTIFYING STAFF)
FORM NO.IGO/E&M/A320/8D/42A
8 DAY INSPECTION SCHEDULE
(AIRBUS A320 AIRCRAFT WITH V2527-A5 ENGINES)
APPROVAL IGO/E&M/Approval/Insp.Sch/57 dated 15.02.2017 EFFECTIVITY: IGO ALL
SKILL CERTIFYING
SN DESCRIPTION TECH
CODE STAFF
19 STABILIZERS AND CONE/REAR FUSELAGE
(MPD ZL-300-01-1-IGO) REF: AMM TASK: 05-23-00-200-001
SIGNATURE
AUTH. STAMP
(CERTIFYING STAFF)
FORM NO.IGO/E&M/A320/8D/42A
8 DAY INSPECTION SCHEDULE
(AIRBUS A320 AIRCRAFT WITH V2527-A5 ENGINES)
APPROVAL IGO/E&M/Approval/Insp.Sch/57 dated 15.02.2017 EFFECTIVITY: IGO ALL
SKILL CERTIFYING
SN DESCRIPTION TECH
CODE STAFF
21
MAIN LANDING GEAR BAY
(MPD: ZL-571-01-1-IGO) REF: AMM TASK: 05-25-70-200-001
Do a general visual inspection of the main landing gear bay as far as visible
for condition like damage, cracks & corrosion: AF
Do a general visual inspection of the main and nose landing gears and
landing gear doors from ground as far as visible, including:
Do a general visual inspection of all pax, service and cargo doors from
ground for signs of corrosion, cracks or damage.
AF
4 Passenger/Crew doors
3 cargo compartment doors
4 overwing emergency exits
Service panel doors, avionic compartment access doors
24 TANKS
(MPD 281100-01-2) REF: AMM TASK: 12-32-28-281-001
Drain water from wing tanks and center tank at water drain valves
AF
Take fuel samples from all tanks. Check for any contamination. Check water
contents in the samples with Aquadis detector (HYDROKIT).
After drainage, make sure that the drain valves are correctly closed and not
leaking.
SIGNATURE
AUTH. STAMP
(CERTIFYING STAFF)
FORM NO.IGO/E&M/A320/8D/42A
8 DAY INSPECTION SCHEDULE
(AIRBUS A320 AIRCRAFT WITH V2527-A5 ENGINES)
APPROVAL IGO/E&M/Approval/Insp.Sch/57 dated 15.02.2017 EFFECTIVITY: IGO ALL
SKILL CERTIFYING
SN DESCRIPTION TECH
CODE STAFF
25 CARGO COMPARTMENTS
(MPD 255000-01-1) REF:AMM TASK: 25-50-00-200-002
AF
Do a general visual inspection of the FWD, AFT and Bulk cargo compartment
decompression, lining, floor panels and pressure compensation valve.
26 WHEELS
(MPD 324100-01-1) REF: AMM TASK: 32-41-00-210-003
Inspect Nose, RH / LH Main Landing Gear Wheels and Tyres for satisfactory
condition (Wear & Damage) including:
NOTE: MLG Tyre Pressure - Min : 210 psi Max: 220 psi
NLG Tyre Pressure - Min : 178 psi Max: 187 psi
CAUTION: IN CASE TYRE PRESSURE IS FOUND BELOW 170 PSI FOR NLG OR
BELOW 190 PSI FOR MLG REFER AMM TASK 32-41-00-210-059 FOR
FURTHER ACTION.
Continued…
SIGNATURE
AUTH. STAMP
(CERTIFYING STAFF)
FORM NO.IGO/E&M/A320/8D/42A
8 DAY INSPECTION SCHEDULE
(AIRBUS A320 AIRCRAFT WITH V2527-A5 ENGINES)
APPROVAL IGO/E&M/Approval/Insp.Sch/57 dated 15.02.2017 EFFECTIVITY: IGO ALL
SKILL CERTIFYING
SN DESCRIPTION TECH
CODE STAFF
INITIAL TYRE PRESSURE:
Main Wheels Nose Wheels
#1 #2 #3 #4 #1 #2
Tyre Pr.
(PSI)
Do a check of the piston housing of all 4 brakes for looseness. If the piston
housing is found loose, replace the brake as per AMM Task 32-42-27- AF
000/400-001.
NOTE: Create a maintenance workorder in case of brake change.
SIGNATURE
AUTH. STAMP
(CERTIFYING STAFF)
FORM NO.IGO/E&M/A320/8D/42A
8 DAY INSPECTION SCHEDULE
(AIRBUS A320 AIRCRAFT WITH V2527-A5 ENGINES)
APPROVAL IGO/E&M/Approval/Insp.Sch/57 dated 15.02.2017 EFFECTIVITY: IGO ALL
SKILL CERTIFYING
SN DESCRIPTION TECH
CODE STAFF
WASTE/WATER SERVICING
NOTE: In freezing conditions, drain the potable water system and the
toilet waste tank. Service before aircraft departure.
NOTE: Obey the cold weather maintenance procedure (Ref. AMM TASK
12-31-38-660-001). AF
NOTE: If the temperature in the aircraft is below 4 DEG.C (39.20 DEG.F)
do the pre-conditioning procedure (Ref. AMM TASK 12-33-21-618-
001).
30 Ensure that the potable water system is serviced as required.
To fill the potable water system with electrical power (Ref. AMM TASK 12-
15-38-613-001). AF
To fill the potable water system without electrical power (Ref. AMM TASK
12-15-38-613-002).
31 Ensure that the toilet waste tank is serviced as required (Ref. AMM TASK 12-
AF
16-38-613-001).
FLIGHT COMPARTMENT
32 CREW OXYGEN SYSTEM
On the DOOR/OXY page (lower ECAM DU), ensure that the oxygen pressure AF
is indicated in Green
33 RAIN REPELLANT FLUID CAN
Do a check of the rain repellant CAN for correct fluid level and pressure AF
AMM TASK: 12-17-30-200-001
34 AIRCRAFT DOCUMENTS
Check for the presence and validity (where applicable) of the following
documents.
Torn/mutilated/missing/invalid documents must be replaced.
1. Certificate of Registration
2. Certificate of Airworthiness
3. Airworthiness Review Certificate (ARC)
4. Certificate of Release to Service (CRS)
5. Aircraft Station License
6. Noise Certificate
AF
7. Permit to Operate
8. Certificate of Insurance
9. Weight Schedule
10. Emergency Equipment Location Chart
11. LOPA
12. MEL Vol 1 and Vol 2
13. Flight Report Book (FRB)
14. Dent & Buckle Chart
15. Cabin Defect Log Book (CDLB) – in passenger compartment.
16. Special Security Anti-Sabotage Search Schedule
SIGNATURE
AUTH. STAMP
(CERTIFYING STAFF)
FORM NO.IGO/E&M/A320/8D/42A
8 DAY INSPECTION SCHEDULE
(AIRBUS A320 AIRCRAFT WITH V2527-A5 ENGINES)
APPROVAL IGO/E&M/Approval/Insp.Sch/57 dated 15.02.2017 EFFECTIVITY: IGO ALL
SKILL CERTIFYING
SN DESCRIPTION TECH
CODE STAFF
35 EMERGENCY EQUIPMENT:
Check the emergency equipment for presence, correct stowage & validity
(where applicable).
1. Crash Axe AF
2. Fire proof gloves
3. Life vest for crew
4. Portable fire extinguisher
5. Portable Breathing Equipment
6. Flash light
7. Escape Rope
36 Check for the presence of Fan Cowl Doors (FCD) Latch Keys (Qty. 2) in the
L/G pins stowage compartment in cockpit.
Ensure that a flag "remove before flight" is attached to the keys.
NOTE:
1. TO BE PERFORMED ON AIRCRAFT WITH MODIFIED FAN COWL
DOOR LATCH (POST MOD SB A320-71-1069 & Goodrich VSB NAC-71-
0331). EN
2. THE MODIFIED FAN COWL DOOR LATCH CAN BE IDENTIFIED BY THE
FOLLOWING:
a. ON THE FAN COWL, “USE KEY” SHALL BE PAINTED ADJACENT
TO THE LATCH.
b. IN THE COCKPIT, THE LANDING GEAR PINS STOWAGE
COMPARTMENT SHALL HAVE AN ADDITIONAL PLACARD
STATING “FCD KEYS At the back of STWG”.
PASSENGER COMPARTMENT
37 EMERGENCY EQUIPMENT
Check the emergency equipment for presence, correct stowage & validity
(where applicable).
Refer ‘Emergency Equipment Location Chart’ in ‘Documents on-board’ file
for location and quantity of the equipment:
1. First Aid Kit (FAK) AF
2. Medical Kit (MK)
3. Universal Precaution Kit (UPK)
NOTE: REPLACE THE FAK, MK OR UPK IF THE VALIDITY IS LESS
THAN 3 DAYS.
Continued…
SIGNATURE
AUTH. STAMP
(CERTIFYING STAFF)
FORM NO.IGO/E&M/A320/8D/42A
8 DAY INSPECTION SCHEDULE
(AIRBUS A320 AIRCRAFT WITH V2527-A5 ENGINES)
APPROVAL IGO/E&M/Approval/Insp.Sch/57 dated 15.02.2017 EFFECTIVITY: IGO ALL
SKILL CERTIFYING
SN DESCRIPTION TECH
CODE STAFF
4. Megaphone
5. Life vest for cabin crew
6. Life vest for infants
7. Portable fire extinguisher
8. Portable oxygen bottle & masks
9. Portable Breathing Equipment
10. Manua-l Release Tools
11. Portable ELT
12. Flash lights
13. PAX Life Vests
14. Automated External Defibrillators (AED)
Ensure that the Green “Ready” light is blinking.
NOTE:
- If the “Ready” light is steady: The AED is in use or running
a self-test.
- If the “Ready” light is off, the AED is chirping, and the i-
button is flashing: The following may be the probable AF
causes:
a) A self-test error has occurred,
b) there is a problem with the pads,
c) the Infant/Child Key has been left installed,
d) the battery power is low.
SIGNATURE
AUTH. STAMP
(CERTIFYING STAFF)
FORM NO.IGO/E&M/A320/8D/42A
8 DAY INSPECTION SCHEDULE
(AIRBUS A320 AIRCRAFT WITH V2527-A5 ENGINES)
APPROVAL IGO/E&M/Approval/Insp.Sch/57 dated 15.02.2017 EFFECTIVITY: IGO ALL
SKILL CERTIFYING
SN DESCRIPTION TECH
CODE STAFF
38 DEMO KIT CONTENTS:
Check the FWD and AFT Demo Kits’ contents as mentioned below:
1 DEMO MASK 1 2 AF
2 DEMO BELT 1 2
3 EXTENSION BELT 2 2
4 PAX INFO CARD 1 2
5 DEMO LIFE VEST 1 2
SN Description Qty.
1 Transit / Preflight Inspection Task Card (Current Revision) 1
2 Anti-Sabotage Task Card (Current Revision) 1
3 Contact Cleaner 1
4 Paper Tape 1 roll
5 Hi Speed Tape 1 roll
6 Transparent Tape 1 roll
7 Locking Wire 1 roll
8 CB Collars, P/N ABS0772B01A 3 AF
9 CB Collars, P/N ABS0772B02A 3
10 INOP Tray Table Belt 2
11 "MEL" Stickers 20
12 "INOP" Stickers 20
13 CAT I ONLY Stickers 10
14 LAV INOP Stickers 10
15 "DO NOT OPERATE" Tags 10
16 "AUTOLAND DOWNGRADED" Placards 10
SIGNATURE
AUTH. STAMP
(CERTIFYING STAFF)
FORM NO.IGO/E&M/A320/8D/42A
8 DAY INSPECTION SCHEDULE
(AIRBUS A320 AIRCRAFT WITH V2527-A5 ENGINES)
APPROVAL IGO/E&M/Approval/Insp.Sch/57 dated 15.02.2017 EFFECTIVITY: IGO ALL
SKILL CERTIFYING
SN DESCRIPTION TECH
CODE STAFF
41 PASSENGER/CREW DOOR (FWD & AFT)
(MPD 521000-01-1) REF: AMM TASK: 52-10-00-210-004
AF
Do a check of the emergency cylinder/accumulator for correct pressure.
NOTE: NOT APPLICABLE TO VT-IDN (MSN 2334) AND VT-IDO (MSN 2275)
42 PLACING THE DEODORANT DISC
AF
Place the deodorant disc in all lavatories.
Ensure that the tray table is horizontal and level in open position.
If the tray table is not horizontal, carry out adjustment in accordance with
the CMM 25-02-69 Subtask 25-02-69-870-808-A01 (8).
AIRCRAFT CLEANING
44 COCKPIT AREA
Check and clean the cockpit area including windshield & windows, crew and AF
observer seats, floor area and cockpit door.
45 CABIN
SIGNATURE
AUTH. STAMP
(CERTIFYING STAFF)
FORM NO.IGO/E&M/A320/8D/42A
8 DAY INSPECTION SCHEDULE
(AIRBUS A320 AIRCRAFT WITH V2527-A5 ENGINES)
APPROVAL IGO/E&M/Approval/Insp.Sch/57 dated 15.02.2017 EFFECTIVITY: IGO ALL
SKILL CERTIFYING
SN DESCRIPTION TECH
CODE STAFF
48 Visual check of the APU area from ground for general condition:
Air intake
Doors: Closed and secured
Drain mast, drains and vents
EN
Exhaust
Fire extinguisher overpressure discharge indicator: Red disc in
place
Visual inspection of power plant, nacelles and pylon from ground as far as
visible(cowl doors closed) including:
SIGNATURE
AUTH. STAMP
(CERTIFYING STAFF)
FORM NO.IGO/E&M/A320/8D/42A
8 DAY INSPECTION SCHEDULE
(AIRBUS A320 AIRCRAFT WITH V2527-A5 ENGINES)
APPROVAL IGO/E&M/Approval/Insp.Sch/57 dated 15.02.2017 EFFECTIVITY: IGO ALL
SKILL CERTIFYING
SN DESCRIPTION TECH
CODE STAFF
RECORD THE SERIAL NUMBERS (OFF AND ON S/Ns) OF THE PCMCIA CARD
ON THE WORK ORDER OF THE 8DAY INSPECTION SCHEDULE.
SIGNATURE
AUTH. STAMP
(CERTIFYING STAFF)
FORM NO.IGO/E&M/A320/8D/42A
8 DAY INSPECTION SCHEDULE
(AIRBUS A320 AIRCRAFT WITH V2527-A5 ENGINES)
APPROVAL IGO/E&M/Approval/Insp.Sch/57 dated 15.02.2017 EFFECTIVITY: IGO ALL
CERTIFIES THAT THE WORK SPECIFIED EXCEPT AS OTHERWISE SPECIFIED WAS CARRIED OUT IN ACCORDANCE WITH
CAR-145 AND IN RESPECT TO THAT WORK THE AIRCRAFT/AIRCRAFT COMPONENT IS CONSIDERED READY FOR
RELEASE TO SERVICE.
CERTIFYING LIC/APP./AUTH.
SIGNATURE
STAFF (NAME) STAMP
FORM NO.IGO/E&M/A320/8D/42A