Академический Документы
Профессиональный Документы
Культура Документы
R2015a
How to Contact MathWorks
Latest news: www.mathworks.com
Sales and services: www.mathworks.com/sales_and_services
User community: www.mathworks.com/matlabcentral
Technical support: www.mathworks.com/support/contact_us
Phone: 508-647-7000
v
vi
1 Introduction
1.1 Conformance Demonstration Template Overview
This Conformance Demonstration Template can be used to demonstrate conformance with the
parts of ISO 26262-6/8, IEC 61508-3, or EN 50128 covered in the document
To access the reference workflow document, on the MATLAB ® command line, type
certkitiec to open the Artifacts Explorer. The reference workflow document is in Simulink
Design Verifier > r2015a.
In the third column, state to what degree you applied the technique or measure for the
application under consideration by using one of the phrases: Used, Used to a limited
degree, or Not used.
In the fourth column, state how you used the technique or measure in the application under
consideration. If the reference workflow includes alternative means for compliance,
indicate what variant you used. In addition, enter a reference to the document (for example,
test report or review documentation).
1-2
1.2 Application Identification
Applicant: <Insert information>
Application: <Insert information>
1-3
1-4
2 Test Case Generation
Checklist 1: Test Case Generation
2-2
3 Additional Considerations
Checklist 2: Additional Considerations
3-2
Technique / Measure Associated Requirements Used / Used to Interpretation in
a limited degree this application,
/ Not used Evidence
9 Deviation from the Documentation and
reference workflow justification for deviations from
the reference workflow by
(See “Deviation from using a deviation procedure (if
Reference Workflow” in applicable)
the Simulink Design
Verifier Reference
Workflow)
10 Integration with the Documented software safety
software safety lifecycle lifecycle, including activities
for application-specific
(See “Integration with generation and verification of
Software Safety test cases
Lifecycle” in the
Simulink Design Verifier
Reference Workflow)
3-3