Академический Документы
Профессиональный Документы
Культура Документы
Notifier NCA2/NFS2-3030
FS-8700-130 Version: 1.02 / Rev. 3.C
www.sierramonitor.com
FieldServer Protocol Driver Sheet
Notifier NCA2/NFS2-3030
FS-8700-130 Version: 1.02 / Rev. 3.C
6.1 Message Types Supported This driver divides the memory into various types.
Each location in each memory type is assigned an
The primary purpose of this driver is to record the address. It is therefore possible to map an address to
status of devices connected to the Notifier panel by a particular offset in a Data Array and make it
interpreting the text messages sent to the printer or accessible for reading by other connected devices.
CRT port. Not all messages will be interpreted, as The address structure is provided below.
many messages do not directly pertain to device
Most of these addresses will only contain binary
status or are not currently supported. The following
information to represent an active or inactive state.
subset of event messages is recognized:
Where multiple troubles are associated with a single
Active Events
FIRE ALARM device the addressed register corresponding to that
SECURITY ALARM (LIFE) device will be incremented as a counter for each
LIFE CRITICAL ALARM trouble message and decremented when a trouble is
MEDICAL EMERGENCY cleared. These addresses should preferably be
SECURITY ALARM stored in SINT16 format in the Data Array.
CRITICAL PROCESS
SUPERVISORY Parameter Addresses
TROUBLE/ FAULT For each SLC loop per Node
DISABLED Memory Type: Detector; Module
PREALARM Fire Alarm 1 – 159
ACTIVE Security Life 160 – 318
ON/ OFF Life Critical 319 – 477
Medical Emergency 478 – 636
A detailed mapping of message interaction System Security Alarm 637 – 795
Trouble messages provided by Notifier at the time Critical Process 796 – 954
this driver was written is tabulated in the driver Supervisory 955 - 1113
manual. Any changes or additions by Notifier will not Disabled 1114 – 1272
be reflected in this driver unless specifically revised. Prealarm 1273 – 1431
Active 1432 – 1590
ON/OFF 1591 – 1749
6.2 Zone Status Memory Type: Detector_Trouble; Nodule_Trouble
This driver will not record information about zone Troubles/Faults 1 – 159
status that is incorporated with point status
messages. A device can belong to multiple zones,
however, only the primary zone is listed in the printer
output. This severely limits the accuracy of zone data
based on event generated messages, and therefore
will not be recorded.
www.sierramonitor.com
FieldServer Protocol Driver Sheet
Notifier NCA2/NFS2-3030
FS-8700-130 Version: 1.02 / Rev. 3.C
MSA Safety
1991 Tarob Court, Milpitas, California 95305 USA
T28600-130 3/20
O. +1 408 262-6611 TF: +1 800 72 SIERRA (74377) E. SMC-insidesales@msasafety.com
www.sierramonitor.com