Академический Документы
Профессиональный Документы
Культура Документы
A bit of history:
There are many different versions about the structure on the Internet
platform, but with no knowledge of the basics of theory, they are all practically
Useless.
And the mystery turns out to lie much deeper and even touches on the theory
universes and directly related to the theory of ether.
«1»
«0»
It becomes clear in detail that the ether has both charges and mass just
they are compensated and therefore neutral.
Стоп !!! Как можно скомпенсировать массу.
Тут пришло время раскрыть секрет который давно и тщательно
скрывают от человечества.
+ = 0
Алюминий Медь
The wings wave of the beetle only supports the airflow which
need to create a static voltage negative
polarity and to control the direction of flight.
-10 000v
Lamp (glass)
Later, the scientist realized that the lifting force is directly related to the area
cathode, more precisely from the ratio of the area between the cathode and the anode.
Reminiscent of the principle of beetle flaps, only the beetle uses the stream
air to create static voltage, as Thomas Townsend
Brown uses high voltage.
It turns out that if you create an asymmetric capacitor with a very large
difference in the area of electrodes, then we get not a bad negative
Mass.
Let's go back to Grebennikov's platform.
How to find material with a large area of contact and make out
cathode capacitor (negative electrode).
Negative electrode
Activated charcoal
The design of the "gravitas"
Pictured is the simplest "gravitas"
"Gravitsapa" is an asymmetric capacitor
negative electrode which is made of activated charcoal.
Dielectric is, for example, a simple plexiglass.
When calculating the dielectric should take into account its breakdown stress
because this device is powered by high voltage. So
also should take into account the punching distance between the electrodes
calculations - at normal humidity of about 1mm per 1Kv.
The distance between the electrodes for reliability is better to increase
for example, this way:
5-7mm
20mm
Solder
pins and
Bend
activated charcoal
from the gas mask filter metal mesh
Fabric Insulator ogre glass
Start button
Converter
Voltage 9v - 10Kv
When you press the "start" button, the voltage from the "Crohn's" battery is applied
on a voltage converter that converts into tension
10-20Kv.
slowly rises upright. As self-discharge
capacitor (ether strive to establish balance and occurs
the platform is slowly descending.
Grebennikov used to control the direction of the flight
metal blinds (flaps) that were located from the bottom on the
corners of the platform and were controlled by cables running from the
steering wheel.
The design of the flaps can be any, their purpose is redirection
gravitational flow.
Visually, the platform's nozzle is divided into four parts as shown
in the picture below where the flaps are located.
Grebennikov himself used fan-type flaps, but my opinion
it's better to use the blinds design even though it's more difficult in
Manufacture.
Flaps