Академический Документы
Профессиональный Документы
Культура Документы
Title: AUDIO / VIDEO: AUDIO AND VISUAL SYSTEM: Vehicle Speed Signal Circuit between Stereo Component
Amplifier and Combination Meter; 2016 MY IS200T IS250 IS300 IS350 [08/2015 ]
Vehicle Speed Signal Circuit between Stereo Component Amplifier and Combination Meter
DESCRIPTION
The stereo component amplifier assembly receives a vehicle speed signal from the combination meter assembly to
control the ASL function.
HINT:
A voltage of 12 V or 5 V is output from each ECU and then input to the combination meter assembly. The signal
is changed to a pulse signal at the transistor in the combination meter assembly. Each ECU controls its
respective systems based on this pulse signal.
If a short occurs in any of the ECUs or in the wire harness connected to an ECU, all systems in the diagram
below will not operate normally.
WIRING DIAGRAM
for 2GRFSE, 4GRFSE
https://techinfo.toyota.com/t3Portal/resources/jsp/siviewer/index.jsp?dir=rm/RM30G0U&locale=en&User=false&publicationNumber=RM30G0U&objType=toc/… 1/5
3/6/2017 AUDIO / VIDEO: AUDIO AND VISUAL SYSTEM: Vehicle Speed Signal Circuit between Stereo Component Amplifier and Combination Meter; 2016 MY IS…
for 8ARFTS
https://techinfo.toyota.com/t3Portal/resources/jsp/siviewer/index.jsp?dir=rm/RM30G0U&locale=en&User=false&publicationNumber=RM30G0U&objType=toc/… 2/5
3/6/2017 AUDIO / VIDEO: AUDIO AND VISUAL SYSTEM: Vehicle Speed Signal Circuit between Stereo Component Amplifier and Combination Meter; 2016 MY IS…
PROCEDURE
1. INSPECT COMBINATION METER ASSEMBLY (OUTPUT WAVEFORM)
(a) Check the output waveform.
https://techinfo.toyota.com/t3Portal/resources/jsp/siviewer/index.jsp?dir=rm/RM30G0U&locale=en&User=false&publicationNumber=RM30G0U&objType=toc/… 3/5
3/6/2017 AUDIO / VIDEO: AUDIO AND VISUAL SYSTEM: Vehicle Speed Signal Circuit between Stereo Component Amplifier and Combination Meter; 2016 MY IS…
Component with harness connected
*a
(Combination Meter Assembly)
(1) Remove the combination meter assembly with the connector(s) still connected.
(2) Connect an oscilloscope to terminal K319 (+S) and body ground.
(3) Turn the engine switch on (IG).
(4) Turn a wheel slowly.
(5) Check the signal waveform according to the condition(s) in the table below.
ITEM CONDITION
Measurement terminal K319 (+S) Body ground
Tool setting 5 V/DIV., 20 ms./DIV.
Vehicle condition Wheel being rotated
OK:
The waveform is similar to that shown in the illustration.
HINT:
When the system is functioning normally, one wheel revolution generates 4 pulses. As the vehicle speed
increases, the width indicated by (A) in the illustration narrows.
NG GO TO METER / GAUGE SYSTEM
OK
2. INSPECT STEREO COMPONENT AMPLIFIER ASSEMBLY (INPUT WAVEFORM)
(a) Check the input waveform.
https://techinfo.toyota.com/t3Portal/resources/jsp/siviewer/index.jsp?dir=rm/RM30G0U&locale=en&User=false&publicationNumber=RM30G0U&objType=toc/… 4/5
3/6/2017 AUDIO / VIDEO: AUDIO AND VISUAL SYSTEM: Vehicle Speed Signal Circuit between Stereo Component Amplifier and Combination Meter; 2016 MY IS…
Component with harness connected
*a (Stereo Component Amplifier
Assembly)
(1) Remove the stereo component amplifier assembly with the connector(s) still connected.
(2) Connect an oscilloscope to terminal P2411 (SPD) and body ground.
(3) Turn the engine switch on (IG).
(4) Turn a wheel slowly.
(5) Check the signal waveform according to the condition(s) in the table below.
ITEM CONDITION
Measurement terminal P2411 (SPD) Body ground
Tool setting 5 V/DIV., 20 ms./DIV.
Vehicle condition Wheel being rotated
OK:
The waveform is similar to that shown in the illustration.
HINT:
When the system is functioning normally, one wheel revolution generates 4 pulses. As the vehicle speed
increases, the width indicated by (A) in the illustration narrows.
PROCEED TO NEXT SUSPECTED AREA SHOWN IN
OK PROBLEM SYMPTOMS TABLE
REPAIR OR REPLACE HARNESS OR CONNECTOR
NG (STEREO COMPONENT AMPLIFIER ASSEMBLY
COMBINATION METER ASSEMBLY)
https://techinfo.toyota.com/t3Portal/resources/jsp/siviewer/index.jsp?dir=rm/RM30G0U&locale=en&User=false&publicationNumber=RM30G0U&objType=toc/… 5/5