Вы находитесь на странице: 1из 101

uu Air conditioning u Automatic air conditioning of the sensor

Automatic air conditioning of the sensor

The automatic air conditioning, you now with a sensor. Or place


sensor anything on top of the sensor, please do not only whether the

water.

Department of Sakumisao each

sensor

233
audio

Audio equipment
USB jack ..................................... 235

234
Audio equipment

USB jack
Open the cover, and connect the USB cable of the device to 1 USB jack

be charged to the USB jack. Do not leave the device connected to the car.

u USB jack (2.5A) is the charge only.

Depending on the type of device connected you may not be able to

charge.

If you use a USB extension cord, you may not be able to charge.

Hard disk or card reader, memory - because the leader is that there
audio
is that the equipment and the data may be damaged, please do not

use.

When you connect by mistake please remove from the power mode

to the OFF mode.

Because there is a risk of data corruption, we recommend a backup

of the file.

235
operation

In this chapter, the driving operation, have been described, such as refueling.

.............................................. before operation 237 Honda sensing ................................... 265 Radar sensor ............................... 329
Driving operation Switch and table for operating the functions shown Brake operation
The start of the engine ................................... 240 ....................................... ................ 266 Brake system ............................... 330
Notes at the time of running ................................... 243 Collision mitigation brake (CMBS) ................. 268 ABS (anti-lock brake system) ... 337
For continuously variable automatic ...... 246 Improper start suppression function ................................... 275 Electronically controlled brake assist ................. 338

Shift operation .......................................... 247 Pedestrian accident reduction steering ............. 277 Emergency stop signal .. 339
ECON switch .................................. 251 Congestion following function with ACC (adaptive crew's Parking and stopping operation

Idling stop system .......... 252 control) ............................... 283 Parking is .............................................. 340

VSA (Vehicle Stability Assist) .. 258 LKAS (lane keeping support system) ........... 299 Refueling For the specified fuel ............................... 342

Agile handling assist ...... 260 Road departure suppression function ............................... 310

Real-time AWD (Intelligent Control System) ✤ ...................... 261 The preceding vehicle start notification function .................... 316 How refueling ...................................... 342

Sign Recognition function ...................................... 320 About turbo car

Blind Spot Information ... 262 Front sensor camera .................... 327 handling.............................................. 345
236
✤ : Due to the type and options, different equipment.
Before the operation

Preparation of operation

Please check the following items before you start the operation. 1 Confirmation of outside the vehicle items

advice

■ Confirmation of outside the vehicle items When the door is frozen, please dissolve over hot water not forcibly

stripped.
• Field of view of the windows and mirrors, or there is nothing blocking the light of the lighting device class?
If forcibly peeled off, you peel off the rubber around the door. After
u Frost, snow, and remove if the ice is attached.
applying the hot water, to prevent freezing, please wipe well the
u If you have piled up snow on the roof it is possible to block the view slides down at the time of traveling
moisture.
Remove because there is sex.
When you're freezing, please remove it from melting ice. The key hole of the door, Do not apply hot water.
u If the ice cubes in the leg is attached, being careful not to damage the parts
Remove. When frozen, the key is you will not be plugged.

• Or bonnet is completely closed?


u When the hood is opened while the vehicle is running, it is dangerous is blocked the view. Misplaced or of combustible materials in the engine room, please

make sure there is no fuel Eyasui.


• Whether the tire is normal? operation
And if you did not used for a long period of time the vehicle, after the
u Air pressure, crack, to see if there are any damage or unusual wear.
maintenance, please particular attention. There is a risk that lead to
2 Inspection and maintenance of the tire P.368
unexpected accidents such as fire.
• Or around the car children are not? Is not
obstacles around the car?

u Blind spot and that can not be seen from the driver's seat, there is a blind spot that can not be confirmed in the rearview mirror or
1 Confirmation of the car item

Because, check before you ride. The driver, please do not use a cell phone while driving.

■ Confirmation of the car item That the driver is using a mobile phone other than the hands-free

while driving, we are prohibited by law. Caution for the situation


• Or floor mat is not caught in the pedal?
surrounding the use while driving is insufficient, assembly may
• Floor or mat is fixed?
result in unexpected accident.
• Do not overlap the floor mat?
u It is dangerous there is a possibility that the operation of the brake and the accelerator can not be reliably.

• Do not place anything on the foot of the front seat? Please use the floor mat for your car.
Continued on next page 237
uu Before the operation u Preparation of operation

• Or embarked's luggage is properly secured?


u Loading of inappropriate luggage, the balance of running or a burden to the tire
Is the danger can not be maintained.

• Or luggage does not exceed the height of the seat?

u Is a risk that stick out luggage at the time of sudden braking or interfere with the rear view

There is a danger.

• When you put the animals are either so as not to Limit your movement?

u Or hindering of the operation, O lead to unexpected accidents, such as when the sudden braking

That there is a danger.


• Or such as seat position is adjusted properly?
u Traveling in the wrong seat position is dangerous.
2 Adjustment of the seat P.191

operation
• Room mirror, door mirror, or handle was properly adjusted?
u Sit in the correct driving position, and adjust to each appropriate position.
2 Adjustment of the mirror such P.187

2 Adjustment of the handle P.186

• Or all of the occupant is fasten your seat belt?


u All of the crew will always wear seat belts.
2 Wearing of seat belts P.30

• Or door, the tailgate is securely closed?


u All the doors before traveling, the tail gate is closed completely, are properly locked
Make sure that you are.
2 Locking / unlocking of the car P.142

238
uu Before the operation u Preparation of operation

• When you start the engine, or a warning lamp is not lit indicating an abnormality in the meter?

u It travels from to resolve the abnormality of the warning light indicating an abnormality.

2 Warning light P.65

operation

239
Driving operation

The start of the engine

1. Slowly the parking brake switch 1 The start of the engine

And certainly raise.


u It is under the parking brake
w
If the brake warning light (red) lights up for about 15 When the battery liquid is insufficient, do not start

seconds. the engine.

u When you start the engine, always Battery There is a risk of rupture.

Please Apply the parking brake.


c
2. Verify that the shift position is
P When you start the engine, stepping firmly
And, stepping on the brake pedal with the right foot. Burekipeda Le.
u And it is under the parking brake
The start of the engine when cold, perform all electrical accessories
N you can start, but again that will be done in safety
Huang But
from then to OFF.
P fixed.
because the driving wheels were of is
operation Start-up of the cold when the engine of the write class in order to

prevent an anti-Worn of the battery, air conditioning, please go after

all OFF electrical accessories, such as Riyadefuro star.

240
uu Driving operation u The start of the engine

3. Without going through the accelerator pedal, 1 The start of the engine

ENGINE START / STOP push. If the engine is not applied, Please operate wait at least 30

seconds.

Or exhaust sound is changed, when indelible smell of gasoline and exhaust gas

is in the car, the abnormality will be considered of the exhaust system and fuel

system.

Please have it inspected by Honda dealer.

In order to protect the car from theft, it has adopted a key

■ Stopping of the engine immobilizer system.

Therefore, you can not start the engine and not a key that has been
When the car is completely stopped, you can turn off the engine.
pre-registered.
1. To the shift position. P
2 Immobilizer system P.158
2. ENGINE START / STOP push. operation

ENGINE START / STOP To start-up the engine

You do not need to hold down to.

When the battery of Honda smart key has expired, the key

ENGINE START / STOP Please touch the.

2 Honda smart Expired battery of hotkey When was

P.401

Continued on next page 241


uu Driving operation u The start of the engine

■ Operation at the time of start


1 Operation at the time of start

1. While stepping on the brake pedal with the right foot, to the select lever. D
c
u If you want to retreat toRthe.
While stepping on the accelerator pedal, do not operate the
2. While applying the parking brake, release the brake pedal, Akuserupeda
select lever.
Tread slowly Lumpur.
It may cause an unexpected accident and sudden acceleration.
u Please make sure that the brake warning light (red) is turned off.
u If it does not mount the driver's seat belt, electronic control parking even at the time of starting You can also cancel the operation of the parking brake switch. In

Brake is not automatically released. the case of downhill, and release the parking brake manually

2 Electronically controlled parking brake P.330 without going through the accelerator pedal, you can start smoothly

Ri good.

operation ■ Hill start assist system 1 Hill start assist system

When the start of the steep slope, then release the foot from the brake pedal, the reverse of the vehicle is alleviated by In the gentle slope there is that the system does not work.

holding the brake force of about one second, a system that facilitates the start.

242
uu Driving operation u Notes on running

Notes on running

■ When the fog came out 1 Notes on running

Visibility will be worse when the fog came out. Lit by the downward headlights even during the day, the While driving, please do not stop the engine.
It is dangerous to the status as follows.
central line, guardrail, such as a guide the tail lamp of the preceding vehicle, please travels slow down.
• Since the booster of the brake does not work, effectiveness of braking

may deteriorate

• Steering becomes heavier because power steering power device

■ When the wind is strong does not work

When the wind is strong car, such as flows in sideways, firmly grip the handle and rebuild the course drop
While driving Do not set the shift position. N
the speed gradually.
The exit of the tunnel, bridge, on top of the embankment, the mountains, such as overtaking at the time of traveling or during
Engine brake is not ineffective at all, it may cause an unexpected
heavy truck Kiridoshi shaved, in order to especially susceptible to side wind, sure to caution. accident.

When you move the car, please be sure to start the engine.
operation

Such as the movement of using the downhill may cause an unexpected

accident.

Until the 1,000km traveling, sudden acceleration for the protection of the

engine and drive system, avoid sudden acceleration, please refrain Me of

operation.

Continued on next page 243


uu Driving operation u Notes on running

1 When it is raining
■ When it is raining
Please be aware of the hydroplaning phenomenon.
Since the time of rainy weather that has become slippery road surface, sudden braking, sudden acceleration, please carefully operation
The hydroplaning phenomenon, when you run the place where the
than usual to avoid the steep handle.
road surface is enveloped by water at high speed, between the tire
In accumulate easy location of water, such as a rut it will be easier Ya cause the hydroplaning phenomenon.
and the road surface can water of the film, that of the state, such that

ineffective handle and brake floated tires It refers to.

Deep puddles, such as flooding road, please do not travel. Engine and drive system of corruption, there is a risk that lead

to failure of the electrical equipment.

operation

244
uu Driving operation u Notes on running

1 Additional Notes
■ Additional Notes
During traveling, when subjected to a strong impact under the floor, because there is a possibility that lead to unexpected accident,
c
please make sure that there are no damage leakage of brake fluid and fuel, to each section to stop immediately in a safe place.
The vehicle speed at the time of shift down, be very careful.

On a slippery road surface, sudden engine brake is


you will Kotogaa lead to a slip of the tire.

advice

Or repeat a handle operated vehicle stop or during an extremely low


speed, the temperature of the EPS (electric power steering) system,
such as by holding apply force to the handle is increased, limiting
the function of power devices for system protection because, handle
operation will gradually heavier. operation

Will return to the temperature of the system is reduced, but if


intermittently repeat how to use such as system protection works,
will be the cause of system damage.

245
uu Driving operation u For continuously variable automatic

For continuously variable automatic

■ Creep phenomenon 1 Creep phenomenon

When the engine is at stake, select lever PN Dynamic and has entered into other than When the vehicle is stopped at the uphill, than the force of forward due to creep

phenomenon, more of the force to retreat becomes large, there are times when
Ready to force led, even without stepped on the accelerator pedal by the creep phenomenon, we start moving
the car is retracted.
the car slowly.
Stepping on the brake pedal, please take the parking brake.

Creep phenomenon will be stronger when the engine speed is increased.

When the engine speed is raised, I do firmly stepping on the brake pedal.

1 Kick down
■ Kick down
Come and depresses the accelerator pedal in such as uphill, rising
Select lever DS In depresses fill the accelerator pedal during running,
above suddenly engine rotation by the kick-down, the speed is too
Automatically the gear ratio is changed up the rotational speed of the engine, you can get a powerful acceleration.
out.
operation
Please the accelerator pedal is carefully operation. On a slippery road

surface or curve, is the special attention is required.

246
uu Driving operation u Shift operation

Shift operation

You can switch the select lever in accordance with the running state. 1 Names and Functions of the select position

When the select lever is otherPthan the power mode it does not

■ Names and Functions of the select position become OFF mode.

R Is, that it contains selector Kutoreba is in the driver chime tone


button
parking sounds when the TheRShirasema be.
Start-up of the car or engine

N Transformer Emissary is also, when the engine is cold when

reverse the ® Nfurudo of Due to the viscosity, it may car starts to move

Retraction of the car slightly.

Firmly stepping on the brake pedal, please take the parking brake if

necessary.
neutral
Idling state operation

drive
• normal running
• When temporarily to 7-speed manual shift mode

Drive (S)
• Efficient use of the high speed region
• When traveling uphill or downhill
• When the 7-speed manual shift mode

Continued on next page 247


uu Driving operation u Shift operation

1 Operation of the select lever


■ Operation of the select lever
advice
Select position is, in conjunction with the select position indicator light in the meter unit, to display the current
Retreat from the forward, completely stopped the car when you move
position at the lighting of the indicator lights.
forward from the retracted, please operate the cell Rekutoreba while

stepping on the brake pedal.

When the car is to operate the lever in a state that is not completely
light)
stopped, large enough to damage the transmission.
the tachometer (transmission warning
Red zone select position indicator light in

When to start the car, please check the position of the select lever in

the select position indicator light in order to prevent accidents

caused by misunderstanding.

When the transmission warning light is blinking while driving, there


operation
is an abnormality in the transmission.
Shift indicator / M (7-speed manual shift mode)
indicator
Avoid sudden acceleration, sure to receive a check in the Honda dealer.

Stepping on the brake pedal with the right foot,


operation and press the button

Without pressing the button, as it is operation

Press the button Operation Te

248
uu Driving operation u Shift operation

1 Operation of the select lever


■ 7-speed manual shift mode and is
The shift switch on the handle, you can shift manually 1 to 7 in Hayama without lifting your hands from the
c
steering wheel. Pulling the shift switch while the vehicle is running, it will switch to a 7-speed manual shift
The vehicle speed at the time of shift down, be very careful.
mode. Even when the engine brake is required, please use.

On a slippery road surface, sudden engine brake is


you will Kotogaa lead to a slip of the tire.
■ When the select position is D
Temporarily become a 7-speed manual shift mode, shift indicator lights up.

If you stepped on the brake pedal while holding down the select
When in a state of constant speed running and acceleration, 7-speed manual shift mode is automatically lever button, you may not be able to operation of the select lever.

+
canceled. It can also be released that continues to pull the shift switch (right side) for a few seconds.
Please depress the brake pedal before.

Such as in front of the curve, it is useful when you want to temporarily slow down. operation

■ When the select position is S

Become a 7-speed manual shift mode, M indicator and the shift indicator lights.

When the vehicle speed is lowered a shift switch without operation, automatically Shifutoda Unshi to turn the low speed stage, will shift

down to the first speed when you stop.

When the engine speed vehicle speed is increased approaches the limit speed (red zone), automatically shifted up

one stage.

Continued on next page 249


uu Driving operation u Shift operation

1 7-speed manual operation of the shift mode


■ 7-speed manual operation of the shift mode
Because of the shift indicator displays fuel efficiency and meet the
In a single shift switch operation, the gear will shift one stage. Start can be
conditions during the seven-speed, and further switches to
done only at the first speed.
high-speed gear ratio. At this time, the shift indicator will remain of
If you want to cancel the mode, please move the selector lever
S D 7-speed manual shift mode is
from to.
the 7-speed.
canceled, M indicator light and the shift indicator is unlit.

When you operate the shift switch, when the engine speed after the
Shift switch
operation is outside the allowable range does not change speed indicator

light will blink.

In order to protect the engine, it may automatically shift up or shift

down.

operation
When you operate the shift switch on a slippery road surface, when

the tire is such as to lock, it might return from the 7-speed manual

shift mode to the normal running.

- Shift switch Subtracting (left), + Shift switch and pull the (right side),
downshifting (shifting to the low gear) (shift to the high speed gear) shift up

250
uu Driving operation u ECON switch

ECON switch
1 ECON switch

When the ECON mode, you may effect of the air conditioning is

weakened during travel.

operation

When you press the switch engine, transmission, and the operation of the automatic air conditioning control and control, and

controlled so as to facilitate the energy-saving operation.

Press the ECON switch on when the power mode is ON mode, please switch the ON and OFF of the
ECON mode.
u When the ECON mode is ON, the indicator light in the meter is turned on, respond to the situation of the operation

Flip switches and fuel-saving control.

251
uu Driving operation u Idling stop system

Idling stop system


In order to improve fuel efficiency and idling noise reduction, or idling stop when the vehicle is 1 Idling stop system

stopped, it is a system in which the engine is automatically restarted. Idling stop, indicator (green) We are using a dedicated battery adapted to the idling stop system

lights up. vehicles. If you use other than the dedicated battery, there is a

And will report that the buzzer opened the luck rolling possibility that premature aging and idling stop of the battery is less

likely to be working. Please during the exchange using a dedicated


seat door is made, it has been idling stop when the
battery. Please consult your Honda dealer for details.
indicator light (green) is on.

2 Warning light P.65


2 specification P.424
2 Indicator light P.78

2 Customization features P.114 When the ECON switch is ON, the longer it idling stop time in air

conditioners use.

Multi-information display in the idling stop state message


will be displayed. 2 ECON switch P.251
operation

252
uu Driving operation u Idling stop system

1 ON / OFF state of the idling stop system


■ ON / OFF state of the idling stop system
When you press during the idling stop, the engine is restarted.
To stop the operation of the idling stop system, please
press. Idling stop system OFF indicator (orange) lights
up in the meter, the operation of the irregular idling stop
system will stop.

Even if you stop the operation at the time of the last traveling,

automatically becomes the ready state and to start the

re-engine.

operation

Continued on next page 253


uu Driving operation u Idling stop system

1 The idling stop


■ The idling stop
During the idling stop, please do not only open the bonnet. It
And the idling stop and have stepped on the brake pedal when the vehicle is stopped.
opened the hood, the engine does not re-start automatically. When

I opened the bonnet,


■ Conditions that do not idling stop
• When you turn OFF the idling stop function by pressing the idling stop system OFF switch

ENGINE START / STOP In the restart of the engine


• When the driver is not wearing a seat belt Please let.
• When the water temperature of the engine cooling water is low, or high when 2 The start of the engine P.240

• When the oil temperature of the transmission fluid is low or high when
• After the engine is started, when the vehicle stops without reaching the 5km / h During the idling stop,

ENGINE START / STOP When you press the accessories


• When the vehicle stops at a steep slope
Does not restart automatically becomes the mode. Please refer to the
• When you are in addition toDthe shift position
start-up operation of the normal engine.
operation • When you start the engine in a state in which the hood is open
2 The start of the engine P.240
u Please restart the engine from closing the bonnet.
• When the amount of charge of the battery is low When the ACC with congestion follow-up function is activated, it

• When the internal temperature of the battery is 5 ℃ below may stop at without operating the brake become idling Stop state.

• Outside air temperature is -20 ° C. or less, or 40 ° C. or higher, when using air conditioning In such a case, when the shift position to the outside than the

engine is restarted. D
• When the air volume of the air conditioning is often

• In air conditioner set temperature Hi or Lo, when using air conditioning


• When but of ON

254
uu Driving operation u Idling stop system

■ Conditions that may not idling stop


• When it was shut down over the sudden braking

• When you are moving the handle

• When the air-conditioned air volume is large

• When the altitude is high

• In a low vehicle speed, when the acceleration and deceleration are repeated

• When there is a large temperature difference between the set temperature, and the in-vehicle air conditioning is in use

• When the car of the humidity is high in the use of air conditioning

operation

Continued on next page 255


uu Driving operation u Idling stop system

1 The engine is automatically restarted


■ The engine is automatically restarted
Engine from idling stop restart Then, depending on the electronic
• When you release the brake pedal engine will automatically restart.
equipment you are using, you may power is temporarily turned off.
• If the automatic brake hold system is stopped at the ON Press down the Akuserupe Dar.

2 Automatic brake hold P.334

■ Without releasing the brake pedal, the conditions under which the engine is automatically restarted ※ 1 1 Without releasing the brake pedal, the engine is automatically

• When you turn OFF the idling stop function by pressing the idling stop system OFF switch Conditions to restart the ※ 1

※ 1: During brake holding by the automatic brake hold will be able

to release the brake pedal when the idling stop system is operating.
• When you move the handle
However, when OFF the automatic brake hold system, or the
• A shift position, when in, or operated
R S from to come N D
engine to automatically restarting when the problem Otomachi' click

brake hold system has occurred.


operation • To parked on a slope, when a moving car loosen the brake
• When you loosen the brake pedal
• When the amount of discharge of the battery is large

• When I stepped on the accelerator pedal

• When the driver removed the seat belt 2 Automatic brake hold P.334

• When you press the

• When the temperature difference between the set temperature, and the in-vehicle air conditioning is in use has increased

• When the interior of the humidity has increased in use air conditioning

• After the automatic stop at the function of the congestion following function with ACC, when it was allowed to resume the follow-up

running or constant speed travel

256
uu Driving operation u Idling stop system

■ Starting auxiliary brake function

Starting from the idling stop holds the temporarily braking force even if you release your foot from the brake pedal, this

will make it harder down the car on a slope.

operation

257
uu Driving operation u VSA (Vehicle Stability Assist)

VSA (Vehicle Stability Assist)


The VSA, ABS function, and overall control of the TCS function and side-slip suppression function, is a device to try to suppress the 1 VSA (Vehicle Stability Assist)
change in the behavior of rapid vehicle. When the different tires types and sizes are mixed, VSA is may not

function properly.
■ ABS (anti-lock brake system) function 2 P.337
Always tire, the same specified size, please use the specified air

■ TCS (Traction Control System) function pressure of the same type of tire.
To prevent the unnecessary idling of the drive wheel, such as a slippery road surface, the driving force, is the ability to try to ensure the

steering capability. And when the VSA warning light is lit during the operation, if you do not

light up even if the path Wamodo to ON mode, the abnormality of the

■ Sideslip suppression function system will be considered.

At the time of turning in such rapid steering wheel operation and slippery road surface, it is the ability to try to ensure the stability of the There is no obstacle for normal operation, please have it inspected

vehicle by suppressing such as skidding of the wheels. at the Honda dealer immediately.

In addition, it installed electronic control brake Assist to assist the brake operation of the driver at the time of emergency After battery reconnection, congestion following function with ACC warning
operation
braking. Tsugeto and CMBS warning light, road departure suppression function

2 Electronically controlled brake assist P.338 warning light, VSA warning light, VSA OFF warning light, when the brake

system warning light (orange) are temporarily turned there is. Will be turned

off for a while traveling at a speed 20km / h or more. Please have it


■ VSA operation and warning lights
inspected at the Honda dealer when it is not turned off.
TCS in the function or the skid suppression function is active, VSA

warning light flashes.

Since there is a limit to ensure the stability of the vehicle even in a state in

which the VSA is activated, please not attempt to unreasonable operation.

• Drop enough speed before the curve

• Snowy, when traveling the freezing path, fitted with Sunotai Ya or

tire chains operating at modest velocity

258
uu Driving operation u VSA (Vehicle Stability Assist)

1 VSA (Vehicle Stability Assist)


■ VSA of the ON and OFF
When you want to escape from fresh snow or mud, in when the
The VSA function to partially stop (OFF) state, please
VSA to OFF TCS function is limited, it may be driving wheels at low
press until the buzzer and the "beep" sounds a.
speed effective since easily rotated.

TCS function is limited, it will have the drive wheels at a low speed easy

to rotate. After the escape from the fresh snow and mud, please ON promptly

To again use (ON), and press until you hear the buzzer and VSA. Traveling in while the VSA to the OFF is not recommended.

the "beep" the. Even if it OFF at the time of the last traveling,

is or will automatically be ON and to start the engine again.

During immediately after the engine start-up and running, there is a

Rukoto hear the motor sound from the engine room for the system

check, but this is not a malfunction.


operation

259
uu Driving operation u Agile handling assist

Agile handling assist


Depending on the driver's steering operation, by applying a light brake on four wheels, respectively, to smooth the 1 Agile handling assist

movement of the vehicle, to a system that enables cornering a sense of stability. Agile handling assist is not a system to improve the stability in all

driving conditions.

For the sake of safety, at an appropriate speed during cornering is in accordance

with the situation, please traveling taking enough distance between vehicles.

When the remains VSA warning lamp is lit while the vehicle is

running, agile handling assist does not work.

During agile handling assist is activated, the sound may be heard

from the engine room, but this is not a malfunction.


operation

260
uu Driving operation u Real-time AWD (intelligent control system) ✤

Real-time AWD (Intelligent Control System) ✤


1 Real-time AWD (intelligent controller

Roll system) ✤
AWD (all-wheel driving) system, snow land, sand, mud, in steep slope such as the slippery road surface,
When the different tires types and sizes are mixed, AWD is may not
but has immediately been in off-road compared to the 2WD vehicle (two-wheel drive vehicle), the following
function properly.
points so not perfect please note.
• Accelerator, steering wheel, brake operation is performed again carefully general car
Always tire, the same specified size, please use the specified air
• Sand, mud, etc., are not continuously running in the front wheel idles convenient location
pressure of the same type of tire.
• Not the water running, such as a river crossing

• Brake performance because there is little difference in comparison with the 2WD models, on a slippery road surface traveling taking When the oil temperature in the system continued to wheel racing of

enough distance between vehicles the running in the state of AWD goes up, it may be switched from

AWD for system protection in 2WD.

After a while the oil temperature is lowered, and then return to the AWD.

operation

261
✤ : Due to the type and options, different equipment.
uu Driving operation u Blind Spot Information

Blind Spot Information


News that the detection area of ​the adjacent lane behind there are other vehicle, is a system to reduce the burden at the time of the 1 Blind Spot Information

operation, such as the driver to change lanes.


w
During the lane change is confirmed, such as visual and mirrors.

By the situation, it may not be able to detect the vehicle. When

you do a lane change without the direct confirmation, it may lead

to unexpected accident.

As with other driver assistance systems, there is a limit to the blind

spot information.

The following cases, it may blind spot in Fomeshon warning light

does not light up.


operation

• Can the other of the vehicle is not in the detection range for more than 2 seconds

• When the adjacent lane is parked vehicle

• When the vehicle overtakes about 10 km / h or faster difference

vehicles traveling adjacent lane

• Or close to those that are not detected by the radar sensor, when

or passed

• When vehicle traveling lane and the adjacent vehicle is small-sized vehicle

such as a two-wheel vehicles

262
uu Driving operation u Blind Spot Information

■ The operating conditions of the system 1 Blind Spot Information

Even when another vehicle is within the detection range, it may be


When the vehicle speed of the subject vehicle is moving forward at 20
km / h or more, detects the detection range of the vehicle radar sensor operated as follows.
is in sensing range A: about 0.5 m B: about 3m C: about 3m • Such as by spray, blind spot Lee down conformation warning

Radar Sensor: located in lamp is not lit, it is displayed as a "blind spot system inspection"

the rear bumper side. Detection range to the multi-information display


A

B • Even if the multi-information display has been displayed as a

"blind spot system inspection", blind spot info automation warning

lamp is lit
C

The shift position is ( R When the system does not work.

operation

Continued on next page 263


uu Driving operation u Blind Spot Information

■ When the system detects a vehicle Blind Spot Information WARNING 1 Blind Spot Information

The alarm sounds, you can customize the settings for the alarm
Lighting
Tsugeto: There is on both sides of the door mirror mirror. display.
2 Customization features P.114

Conditions that blind spot information warning lamp is turned


The following case, there is a possibility of such a system is not
Flashing on: exactly shown Table affected.
• Other vehicles, when entering from behind the detection range for • When you are right or left turn at an intersection

• Installation of the roadside (guardrail, utility poles, trees, parked car vehicle,
overtaking vehicle speed difference of about 50 km / h hereinafter
building, wall, etc.) when it is detected
vehicle speed than the vehicle
• And when the motorcycle enters the detection range, when the one that does not
• When hurts have additionally the other vehicles in the vehicle speed
reflect the radio wave is in the detection range

difference of up to about 20 km / h • When you are traveling on a curved road

• When another vehicle is approaching from the outer side than the
Blind Spot Information warning flashes tell lamps, condition adjacent lane
operation
alarm sounds: detecting the range when there is another vehicle, • When there is close to emit strong radio equipment

is operated in a direction where there is detected vehicles • Rear bumper and radar sensors around corruption, when it is

deformed
directional indicators (the blinker switch), alarm sound sounds
• When bad weather (rain, snow, fog, etc.)
three times or be.
• In order to operate the system properly when you are inclined vehicle body by the

unevenness of the turning and the road surface, please be sure to observe the following

things.

• The side portion of the rear bumper should always be clean

• No Paste seal and the side surface portion of the rear bumper

When performing or repair when an impact is applied to the


peripheral rear bumper and radar sensors, please consult your
Honda dealer.

264
Honda sensing

A radar sensor installed in the back of the front grill, the front sensor camera installed above the front 1 Honda sensing

window part, two types of driving support system configured with sensors of different characteristics.
w
Honda sensing, please use as an auxiliary system.
The Honda sensing, has the following features. It is not automatic operation system. Last is the
system in order to assist the driver.
■ Switch operation is not required functions in order to operate

• Collision mitigation brake (CMBS) 2 P.268

• Improper start suppression function 2 P.275 The ability (cognitive ability and control ability) of each function

• Pedestrian accident reduction steering 2 P.277 there is a limit.

• Road departure suppression function 2 P.310 Lead to an accident, such as a collision operation that relied on

• The preceding vehicle start notification function 2 P.316 function, there is a Ruosore was in death or serious injury. Always

• Sign Recognition function 2 P.320 around the situation Check, please travels heart cliff a safe driving
operation

• Auto high beam 2 P.176 maintaining a sufficient distance between vehicles.

■ Switch operation function that needs to operate


• Congestion following function with ACC (adaptive cruise control) 2 P.283
• LKAS (lane keeping support system) 2 P.299

265
uu Honda sensing u Display and switches for operating each function

Display and switches for operating each function

■ Steering switch

Distance switch ■ MAIN switch


RES / + switch ACC with congestion following function, make the settings in the standby

state of the LKAS.

■ LKAS switch

CANCEL Make the ON and OFF settings of the LKAS.


switch
■ RES / + Switch / - / SET switch
Carriage return and set the speed of the ACC with congestion following

function, make adjustments of the set speed.

MAIN LKAS
switch switch ■ Distance switch
operation
Make a set of vehicle-to-vehicle distance.

- / SET switch
■ CANCEL switch
Make the release of the ACC with congestion following function.

266
uu Honda sensing u Display and switches for operating each function

■ Display of multi-information display

ACC with congestion following function, to display the current state of the

LKAS.
3
1

a ACC with congestion following function, the standby state of the LKAS
2
5

b ON and OFF of the state and the control state of LKAS


4

c Detection state of a leading vehicle

d Set vehicle speed

e Set inter-vehicle
operation

267
uu Honda sensing u Collision mitigation brake (CMBS)

Collision mitigation brake (CMBS)

Vehicle is, when there is a risk of colliding with the and pedestrian when there is a risk of collision or when there is a risk of collision 1 Collision mitigation brake (CMBS)

from almost directly behind the front of the vehicle, from the front to the oncoming vehicle, helping the driver's brake operation , it is a

system to reduce the impact or to avoid a collision.


w
Collision mitigation brake (CMBS) is not a system can
■ The operation of the system avoid a collision in every situation. Radar and camera
may weather and speed, it is difficult to detect by road
Radar sensor and the camera when the vehicle speed of the vehicle becomes equal to or higher than about 5km / h starts the detection of the
front of the vehicle or pedestrian.
conditions.

camera
of the front glass front sensor
Equipped with a camera at the top If you do not use in accordance with the instruction manual, it

leads to an accident, such as a collision, there is a risk of death or

serious injury.

operation
Check the surrounding conditions, please go to safe driving Chi holding
In the back of the front grill, equipped
a sufficient distance between vehicles.
with a radar sensor of CMBS

Please see below for the handling of the radar sensor.

In danger Rutoki of the collision to the vehicle and pedestrian speed difference between the vehicle is equal to or greater than about 5km / h, 2 Radar sensor P.329
CMBS will be activated.
Oncoming vehicle, for stopping the vehicle and a pedestrian, when there is a risk of collision during driving the vehicle is not more than
about 100km / h, CMBS is activated.
CMBS is activated, after it is determined that the risk of collision or after the vehicle stops is lost, the automatic brake
is released.
It should be noted that, in an attempt to avoid the collision, the driver steering wheel, brake pedal, when you operate
the Akuserupe Dar, it is that the system is released.

268
uu Honda sensing u Collision mitigation brake (CMBS)

■ Way of warning of CMBS 1 Collision mitigation brake (CMBS)

For the handling of the camera that is mounted on the front glass

Pipipipi ... top refer to the following.


By the following method, CMBS is that there is
a risk of collision, informs the driver.
2 Front sensor camera P.327

• Warning display and warning buzzer of the


multi-information Display occurs When the depression amount of the accelerator pedal is large, the

system might not operate.

You can select the alarm distance of CMBS from the far-Me-standard and near the eyes of three stages.

2 Customization features P.114

Far The first is to warn in the distance against a standard. It warns close to the near eye standard. operation

Continued on next page 269


uu Honda sensing u Collision mitigation brake (CMBS)

■ Flow of CMBS working


The operation of the CMBS There are three stages depending on the possibility of a collision. However, in some circumstances it may be operated from the middle of the stage.

Distance of the vehicle and the vehicle Status Warning by buzzer and display brake

standard
Warning display further closer blinks twice, an alarm by
the warning display and buzzer
Far Me Near because
Situation that came out is a risk of
First stage vehicle

collision of the vehicle u You can change the collision warning distance
It is.
my car 2 Customization features P.114

vehicle
Situations where the risk of collision

operation The second stage increases, has become less margin until Light brake
the collision
my car

An alarm by warning display and buzzer


vehicle

Third stage Avoid difficult situations Strong brakes

my car

※: When the brake is operated by the CMBS braking lights up.

270
uu Honda sensing u Collision mitigation brake (CMBS)

■ ON and OFF of CMBS 1 Collision mitigation brake (CMBS)

In the following cases, it may CMBS automatically stops, the


By pressing the CMBS OFF switch to the "beep" until the
warning light is illuminated.
buzzer sounds, switch the ON and OFF of the system.
• When a long period of time traveling on a mountain road and bad road

• When traveling over a parking brake

• Rain, fog, when it is bad weather, such as snow


CMBS is CMBS warning light is lit when switched to
• When the temperature of the camera is in the high temperature

OFF, the multi-information display as "CMBS OFF" • Front grille or windshield Ri dust-free, mud, fallen leaves,
message will be displayed. covered with such wet snow Rutoki

• If a state that CMBS can operate when it detects an abnormality

In a state where the CMBS to OFF even when the power of the tire, CMBS will automatically return.

mode to OFF, automatically will be ON and ON the


power mode again. operation
At the time of maintenance and inspection of the vehicle, when

using a chassis dynamometer and free roller, please OFF the

CMBS.

Continued on next page 271


uu Honda sensing u Collision mitigation brake (CMBS)

The following cases, can not be detected radar sensors and camera vehicle, a pedestrian or road conditions, 1 Collision mitigation brake (CMBS)

it may CMBS is not working correctly. After battery reconnection, congestion following function with ACC warning

Tsugeto and CMBS warning light, road departure suppression function

■ Cases of radar sensors and a camera can not be correctly detected by the environment warning light, VSA warning light, VSA OFF warning light, when the brake

• Rain, fog, in the case of bad weather, such as snow system warning light (orange) are temporarily turned there is. Will be turned

• And tunnel entrances, when the tree, and in the brightness of the shadow of the building has changed off for a while traveling at a speed 20km / h or more. Please have it

inspected at the Honda dealer when it is not turned off.


• When the backlight

• When a strong light is reflecting vehicles and pedestrians, the road surface

• When there is a wind-up of splashes and snow by the front of the vehicle

• Dark lighting at night or in a tunnel, Itoki such are illuminated the entire vehicle-pedestrian
Such as frequent alarm is activated, when you feel an abnormality

in the system, please have it inspected by Honda dealer.

■ Cases of radar sensors and a camera can not be correctly detected by the state of the road
operation
• Curve, undulating road, when such a slope
• When the road surface there is a water reservoir and a water film

• When the road with a rut, such as snow-covered road or unpaved road

• Such as when the vehicle is traveling on a narrow iron bridge, when there are things you strongly reflected radio waves around the

vehicle and pedestrian

■ Cases of radar sensors and a camera can not be correctly detected by the state of the vehicle
• When the front grill is dirty
• Of the front glass cloudy, rain drops, when such as the front of the camera is covered with a seal

• Cargo space and the second seat, third seat ✤ Laden with heavy luggage, when it is tilted car

• When you are not using the proper tire


• When it is equipped with a tire chain
• In the dark such as at night or in a tunnel, when traveling the headlights OFF
272
✤ : Due to the type and options, different equipment.
uu Honda sensing u Collision mitigation brake (CMBS)

■ Cases where the front of the vehicle and the oncoming vehicle, radar sensors and cameras by the state of the pedestrian can not 1 Collision mitigation brake (CMBS)

be detected correctly Please do not suspension of remodeling. There is a possibility that

• When the extremely short distance between the front of the vehicle or a pedestrian the system is not working properly.

• In front of the vehicle when the vehicle is interrupted suddenly

• When the oncoming vehicle or pedestrian ran out in front of the vehicle
Tires are the same size specified with four-wheel, the same species
• When a portion of the pedestrian (such as the head and limbs) is hidden by such as luggage
such, please use the tire not of the same brand and wear difference.
• Pedestrian under cover in the background, when the camera can not detect a pedestrian
Size, type, and to use a different tire of the brand and the degree of
• When a pedestrian is taking a slouch or squatting posture, or raise your hand, when you are running
wear case, there is a possibility that the system is not working correctly.

• Height of the pedestrian is about 1m or less, or when more than about 2m

• When a pedestrian is in front of a group

• When the front of the vehicle is without lights in the dark

operation
■ Other, it can not be operated cases
• In an attempt to avoid the collision, when the driver operates the brake and handle

• While the rapid acceleration and steering, in front of the vehicle or an oncoming vehicle, when approaching the pedestrian

• Front of the vehicle or an oncoming vehicle, when a pedestrian is not in front of the vehicle

• When the big speed difference between the front of the vehicle and pedestrian

• When the front of the vehicle has been rapid deceleration

• Bicycles and motorcycles, wheelchairs, when such as a vehicle of a special shape

• When the vehicle ran out in front of the vehicle at an intersection

• When the camera can not be correctly detected as a form of pedestrian

Continued on next page 273


uu Honda sensing u Collision mitigation brake (CMBS)

■ The operation of the absence of possibility of collision


Even if there is no possibility of a collision, when the following, you may CMBS is activated.

• Turn left, or when there are front vehicle which is turning • If you are traveling in close proximity to the vehicle when
right, or when there are right turn waiting vehicles overtake the preceding vehicle
• If the intersection, such as you travel in close proximity to
the vehicle

operation

• Passing to Utosuru time at a rate that exceeds the speed limit between such low gate and narrow gate

• When traveling road having steps, line, over such steel plate construction

• When the side of the road in the middle of the curve, and the • When the oncoming vehicle are cornering or the like in front
like signs and guard rail of the vehicle

• Such as when parking, when approaching the vehicle and the wall that is stopped

274
uu Honda sensing u Improper start suppression function

Improper start suppression function

By a camera that is installed in the radar sensor and the windshield top that is installed in the back of the front grill, 1 Improper start suppression function

when traveling below the standstill and about 10 km / h, an obstacle such as a vehicle substantially squarely to the

vehicle is Despite, if depresses the accelerator pedal, to suppress the engine output, thereby preventing a sudden
w
start, is driving support function for informing by sound and display. It should be noted that the steep slope and the Improper start suppression function is not something a collision

selector lever ( P , ( R , ( N When, it does not work. due to erroneous application or stepping too much Akuserupe Dar

can be prevented or Hesi light in all situations.

Operating condition
During the function is active buzzer sounds (Pipipi) is, of the multi-information display Lead to an accident, such as a collision operation that relied on
warning will flash.
function, there is a Ruosore was in death or serious injury. The

driver to check the status of the surrounding and position us of

Pipipipi ... the select lever and pedal, please be safe driving the mind is only

running.

operation

Improper start suppression function uses the same sensor as the CMBS.

CMBS can to be turned OFF, the improper start suppression function

does not work. Also, to protect in order to successfully operate the

improper start suppression function, the situation can not be normal

operation, such as the handling of the operation and radar sensors in the

absence of the possibility of collision is the same as CMBS.

Suppress the engine output

Please see below for the handling of the radar sensor.

2 Radar sensor P.329

Does not work when the amount of depression of the For safety releasing the accelerator pedal,
accelerator pedal to prevent a sudden acceleration due please depress the brake pedal if necessary. Please see below for the handling of the camera that is mounted on

to erroneous application or stepping too much of the the front glass top.
accelerator pedal is small. 2 Front sensor camera P.327
Continued on next page 275
uu Honda sensing u Improper start suppression function

■ Conditions of deactivation 1 Improper start suppression function

- When you release the accelerator pedal Please OFF the CMBS if improper start suppression function is

- When it continued down the accelerator pedal about 4 seconds activated, can not exceed Ri multiplied by the difference in level on the

- When I stepped on the brake pedal road.

- By operating the handle, when it tried to avoid a collision


When confined within railroad crossing, there is possible to detect
- When you turn OFF the CMBS
breaker as obstacles. If this happens, or continue stepping on the

accelerator pedal to not panic, please pushes away the breaker

OFF the CMBS.

operation

276
uu Honda sensing u Pedestrian accident reduction steering

Pedestrian accident reduction steering

Detects a pedestrian and a white line (yellow line) by the radar and the camera, it will prompt the collision avoidance operation of 1 Pedestrian accident reduction steering

the driver by to assist the steering operation.


w
Pedestrian accident reduction steering function is a system to
■ The operation of the system
support the driving operation of the driver. A pedestrian accident

in every situation, not something that can be avoided Ri was

reduced.

If you do not use in accordance with the instruction manual, it

leads to an accident, such as a collision, there is a risk of death or


avoidance maneuver
serious injury.

the driver's
The driver to check the surrounding circumstances, pedestrian and
operation
Alarm and support proper keeping a switching distance and then perform a safe driving.

When not traveling in the lane, pedestrian accident reduction

steering function does not work.

Please see below for the handling of the radar sensor.

The camera recognizes the lane, to If there is a risk of collision with the shoulder of a pedestrian, and the
detect the pedestrian by the radar and alarm in the display and the alarm sound, and further, encourage the 2 Radar sensor P.329
the camera avoidance maneuver in steering assistance, please sure that you take
evasive action. Depending on the positional relationship of the vehicle
Please see below for the handling of the camera that is mounted on
and pedestrian might operation of the CMBS is a priority.
the front glass top.

2 Front sensor camera P.327

Continued on next page 277


uu Honda sensing u Pedestrian accident reduction steering

■ The operating conditions of the system 1 The operating conditions of the system

Pedestrian accident reduction steering operates in the following state. There is that assistance is not felt when the operation by the driver

• When the pedestrian is walking the shoulder, when the vehicle is going to deviate from the lane toward the pedestrian is being performed.

• When the solid line of the white line (yellow line) is continuous

• When the vehicle speed is running at about 10 ~ 40km / h

• When you are traveling on a straight road

Pedestrian accident reduction steering does not work in the following state.

• When to operate the wiper with continuous

• When issuing direction indicator (the blinker)

1 System of ON and OFF


■ System of ON and OFF
operation
Use the multi-information display, you can customize the
Pedestrian accident reduction steering, road departure suppression
configuration of the road departure suppression function. If you
function is activated at the time of ON. Press the road departure
select the "steering assist without warning only" in customization
suppression switch, please you switch the ON and OFF of
features, pedestrian accident reduction steering does not perform
pedestrian accidents reduced steering. the steering control.

u When the ON, the road departure suppression switch 2 Customization features P.114

Indicator lights, multi-in conformation display in the


message will be displayed.

switch indicator

Road departure suppression

278
uu Honda sensing u Pedestrian accident reduction steering

■ Conditions and restrictions of the pedestrian accident reduction steering system

Under the following conditions, or support a delay of pedestrian accident reduction steering, you may not be able to support.

The driver to check the status of the surrounding, please go the safe driving keeping the pedestrian and the appropriate distance.

■ Cases of radar sensors and a camera can not be correctly detected by the environment
• White line when it is not possible to distinguish between (yellow line) and the road surface

• Rain, fog, in the case of bad weather, such as snow

• When it is wet or there are still snow on the road surface

• When traveling toward the sun at the time of dawn and dusk

• When a strong light is reflecting on pedestrian and road

• Such as the tunnel of the entrance, when the brightness of the peripheral changes suddenly operation

• When after the rain, etc. there is and puddles when you are shining wet road surface

• White line when it is reflected in the shadow in the vicinity of the (yellow line) (trees, buildings, guard rail, vehicle, etc.)

• Dark places, such as at night or in a tunnel

• When there is a wind-up of splashes and snow by the front of the vehicle

Continued on next page 279


uu Honda sensing u Pedestrian accident reduction steering

■ Examples that radar sensor and the camera can not be correctly detected by the state of the road

• When traveling on the section in which there is a lane restrictions and temporary lane

• For road repair and the old white line (yellow line), blurred and overlapping, when the tire marks, a variety of white line (yellow line)

is on the road

• When traveling a section a section or lane number of lanes such as an intersection or crosswalk is increased or decreased being

highly cross

• When time and width of the lane is extremely narrow, or when changing
• When such vehicle is hiding a part of the white line (yellow line)

• When the slope and, approaching the top of the hill

• When the vehicle is swaying widely with step


• Those on the street (curb, guardrail, such as pylon) and was recognized as a white line (yellow line) can

operation
• Curve, undulating road, such as slope, if you can not correctly recognize the white line (yellow line) and the pedestrian by road

conditions

• When you are traveling on a road with an unpaved road or a rut

• Such as when traveling on a narrow iron bridge, when there is one that strongly reflect radio waves around the pedestrian

• When traveling on a road lane is depicted in double


• When traveling, etc. branching and merging path

• When traveling on a slippery road surface, such as a frozen road and snow road

• When traveling on the roads and rough roads that have not been paved

• When the paved road in the snow, puddles of snow road or a street is partially visible

280
uu Honda sensing u Pedestrian accident reduction steering

■ Examples that radar sensors and cameras by the state of the vehicle can not be correctly detected

• Front glass outside dirt, mud, when you are covered, such as in the wet snow

• When the front glass inside is cloudy


• When there is wiped of the wiper
• When irradiation dirty lens of the headlight is deviated weak or when the optical axis

• Cargo space and the second seat, third seat ✤ Laden with heavy luggage, when it is tilted car

• Size and type, or not wear the tire and wheel of a different structure, when the tire air pressure is not

appropriate

• In an attempt to avoid the collision, when the driver operates the brake and steering
• When the front grill is dirty
• When it is equipped with a tire chain operation

• When the inter-vehicle distance to the preceding vehicle is short

■ Cases of radar sensors and a camera can not be correctly detected by the state of pedestrian

• Such as pedestrian pops out in front of the vehicle, when the pedestrian began to appear suddenly

• When a portion of the pedestrian (such as the head and limbs) is hidden by luggage, etc.

• Pedestrian under cover in the background, when the camera can not detect a pedestrian

• When a pedestrian is taking a slouch or squatting posture, or raise your hand, when you are running

• Height of the pedestrian is about 1m or less, or when more than about 2m

• When a pedestrian is in front of a group

Continued on next page 281


✤ : Due to the type and options, different equipment.
uu Honda sensing u Pedestrian accident reduction steering

■ Other, it can not be operated cases


• While the sudden acceleration and steering operation, when it is close to the front of the pedestrian

• When the camera can not be correctly detected as a form of pedestrian

• Bicycles and motorcycles, wheelchairs, when such as a vehicle of a special shape

operation

282
uu Honda sensing u Congestion following function with ACC (adaptive cruise control)

Congestion following function with ACC (adaptive cruise control)


1 Congestion following function with ACC (adaptive cruise Con

Troll)
ACC with congestion following function, the camera in the radar sensor and the front glass top that is installed in the back of the front

grill are installed is to measure the distance to the preceding vehicle, the appropriate acceleration and deceleration at the time of
w
congestion of highway carried out, while maintaining the set inter-vehicle distance, traveling without the driver operates the accelerator
Improper use of the ACC with congestion following function will
and brake, is a system that helps to be able to stop.
lead therefore thing. Please operate according to the procedure

of the operation manual. Please use only high-speed roads and


When the brake by the ACC with congestion follow-up function is activated, brake lights will light up.
motorways.

To activate the ACC with congestion following function:

ACC system with congestion following function, the shift position is, to you
D can Suse when.

operation

Continued on next page 283


uu Honda sensing u Congestion following function with ACC (adaptive cruise control)

1 Congestion following function with ACC (adaptive cruise Con


■ Shift position, which can be used Equipped with a camera to the front Troll)
D , When
S glass top

w
ACC with congestion following function, please use as an

auxiliary system. ACC with congestion following function is

not an automatic operation system. Merely is a system to

assist the driver. If you do not use the instruction manual, it

unexpected therefore lead, there is a fear upcoming are in


In the back of the front grill, death or serious injury. Always check the surrounding
equipped with a radar sensor
circumstances, safe driving the mind only, please traveling.

operation And during deceleration by operating the brake pedal, the can is when there is a parking brake, ACC with congestion

following function does not work.

Bad weather, etc., when the radar sensor is unable to measure the distance to the preceding vehicle,
the system might not work.
w
From the vehicle that was stopped during the operation of the

congestion following function with ACC, there and go outside the vehicle

may start moving without the operation at the appropriate parking

operation without.

Vehicle to move without the appropriate parking operation can lead to

unexpected accidents, there is a risk of death or serious injury. Please

do not go out to the absolute from the vehicle, which was parked in the

congestion following function with ACC.

284
uu Honda sensing u Congestion following function with ACC (adaptive cruise control)

■ In order to operate the system 1 Congestion following function with ACC (adaptive cruise Con

Troll)
ACC (green) lights up in the meter, ACC
For the handling of the camera that is mounted on the front glass
with congestion following functions can be
operated top refer to the following.

2 Front sensor camera P.327

■ handle MAIN The switch


Push Please see below for the handling of the radar sensor.

2 Radar sensor P.329

Precautions:

ACC with congestion following function is a system to help the

driver. It may not work depending on the weather and the


operation
environment. When necessary, use the brake pedal, please keep

always a safe following distance.

Continued on next page 285


uu Honda sensing u Congestion following function with ACC (adaptive cruise control)

1 To set the vehicle speed


■ To set the vehicle speed
After battery reconnection, congestion following function with ACC warning

When the ACC is with congestion Tsugeto and CMBS warning light, road departure suppression function

following function is working warning light, VSA warning light, VSA OFF warning light, when the brake

system warning light (orange) are temporarily turned there is. Will be turned
Set vehicle speed
off for a while traveling at a speed 20km / h or more. Please have it

inspected at the Honda dealer when it is not turned off.


- / SET switch

MAIN When you press the switch, both the ACC and LKAS with

congestion following function will switch to ON and OFF.

operation
Push
When the following circumstances It is, Do not use the ACC with congestion

following function Please .

• In the traffic situation, such as repeating the many roads and frequent acceleration and

deceleration of the traffic, it can not be traveling at a speed that matches the traffic

When not operating the brake pedal - / SET The current vehicle speed by pressing the switch
situation.

It is a set vehicle speed, congestion follow-up ACC is activated with function, icons and set the vehicle speed to • It is on the road with a sharp curve can not be traveling at a speed that matches the

the multi-information display appears. road conditions.

When the vehicle speed is traveling at less than 30km / h: • In the steep downhill you may exceed the set speed. In such a

case, the brake does not work by the ACC with congestion
Only if you are detecting the preceding vehicle that can be operated, set vehicle speed regardless of the current
following function.
vehicle speed is set to about 30km / h. If the vehicle is not moving, it can be operated even if not stepping on the
• Such as a highway, tollgate, interchange, service area, when you
brake pedal.
enter the parking area Susumu, so it starts accelerated up to the

set vehicle speed by it will be no preceding vehicle from the front

of the vehicle.

286
uu Honda sensing u Congestion following function with ACC (adaptive cruise control)

Straight Driving Assist When you use the ACC with congestion following function (Straight steering holding support function) 1 To set the vehicle speed

There will be activated. • When bad weather (rain, fog, snow, etc.) can not accurately measure

This is a function of the EPS (electric power steering), to reduce the handle steering hold force in straight ahead, to make it easier the distance to the preceding vehicle.

to straight-ahead running. • On a slippery road surface, such as a frozen road and snow road

you could lose control of the car idles tire.

operation

Continued on next page 287


uu Honda sensing u Congestion following function with ACC (adaptive cruise control)

■ The operation of the ACC with congestion following function


1 The operation of the ACC with congestion following function

Preceding vehicle or sudden deceleration, when you can interrupted


■ When there are preceding vehicle
by slow vehicle, warning of the warning sound to vision in the sounds
If the congestion following function with ACC is the preceding vehicle enters the detection range of the radar sensor, according to the of the multi-info mation display a warning is displayed.

leading vehicle of the vehicle speed change, to follow-up running want while maintaining an inter-vehicle distance within the range of

the set vehicle speed.

Stepping on the brake, please keep an appropriate distance between vehicles.


The detection range of the ACC with congestion following function: 120m

operation

When the preceding vehicle and interrupt vehicle traveling at a slower than Pipipipi ...

the set speed rate appeared ahead, the system will perform the

deceleration control.

Car icon is displayed in the


multi-information display
Preceding vehicle or the speed of the cut-in vehicle is faster than the

vehicle, if gradually away, the alarm even short distance to the preceding

vehicle is not out, it may follow it. Using the multi-information display you

can set the presence / absence of the preceding vehicle detection sound.

2 Customization features P.114

288
uu Honda sensing u Congestion following function with ACC (adaptive cruise control)

■ When the preceding vehicle is not 1 The operation of the ACC with congestion following function

If the preceding vehicle is not, and constant-speed running at a vehicle Restrictions:

In order to keep a safe distance between vehicles, using the brake pedal,
speed that is set.
even while using the ACC with congestion following function you need to
When the preceding vehicle is no longer stomach such as a lane change,
apply the brakes. In addition, it may ACC with congestion following function
after gradually accelerated to a set vehicle speed, and constant-speed due to weather and the environment is not sincerely working apply.

running.
2 Limits and conditions of the ACC with congestion following function P.290

2 To set up an inter-vehicle distance P.295

Multi-information display on the


dotted line of the car icon is • Depending road conditions (curves, etc.) and vehicle conditions
displayed (handle manipulation or position within the lane) and may perform
vehicle distance control for things car or around the lane temporarily
becomes.

■ When I stepped on the accelerator pedal


• When depressing the accelerator pedal, ACC with congestion following function will increase temporarily released the vehicle operation

speed. In this case, can have the preceding vehicle in the warning range of the ACC with congestion following function does not

come out warning sound and multi-information display of the warning display.

• When you release the accelerator pedal, congestion following function with ACC will resume the follow-up running or constant

speed travel and return.

• When the preceding vehicle enters such as interchanges and service area A,

when no longer had the preceding vehicle from the front of the vehicle is, there

are times when the inter-vehicle distance control is to continue for a little while.

Continued on next page 289


uu Honda sensing u Congestion following function with ACC (adaptive cruise control)

■ When the preceding vehicle stops at a reduced speed When the preceding vehicle stops, the vehicle also stopped automatically

You. Message is displayed on the multi-information


disk-play. When the preceding vehicle begins to move,
multi-info mation display of the icon flashes.

RES / + Switch or - / SET Scan

Press the switch, then start with a child stepping on the accelerator pedal,

and then add follow traveling within the range of the previous set vehicle

speed.

■ Limits and conditions of the ACC with congestion following function

operation System under certain conditions is automatically released, it might congestion following function with ACC warning light is illuminated. In

the following conditions you may not be able to exert a part of the function of the congestion following function with ACC.

2 Front sensor camera P.327

■ Cases where the radar sensor can not be properly detected by the environment

• Rain, fog, in the case of bad weather, such as snow

• When there is a wind-up of splashes and snow due to the preceding vehicle

290
uu Honda sensing u Congestion following function with ACC (adaptive cruise control)

■ Cases where the radar sensor can not be properly detected by the state of the road
• Curve, undulating road, when such a slope

• Road with a rut, such as snow-covered road or unpaved road

• Narrow such as when traveling on a railway bridge, those which strongly reflects radio waves around the vehicle there Rutoki

operation

Continued on next page 291


uu Honda sensing u Congestion following function with ACC (adaptive cruise control)

■ Cases radar sensor according to the state of the vehicle can not be correctly detected
• When the front grill is dirty
• When you are not using the proper tire
• Cargo space and the second seat, third seat ✤ Laden with heavy luggage, when it is tilted car

• When it is equipped with a tire chain

■ Cases where the radar sensor can not be properly detected by the state of the front of the vehicle
• In front of the vehicle when the vehicle is interrupted suddenly

• When the extremely short distance between the front of the vehicle

operation

292
✤ : Due to the type and options, different equipment.
uu Honda sensing u Congestion following function with ACC (adaptive cruise control)

■ Others, case the system does not work properly


• Front of the vehicle or not parked, when the speed difference between the vehicle is large

• When the front of the vehicle has been rapid deceleration

• When the vehicle in front of a vehicle panel trucks and special shapes

Panel trucks and tank


It detects the top of the track
trucks, etc.

• When the vehicle or the front of the vehicle, running biased to one side of the lane operation

• When the front of the vehicle is a narrow vehicle width such motorcycles

• When ground clearance of the front of the vehicle is extremely high

Continued on next page 293


uu Honda sensing u Congestion following function with ACC (adaptive cruise control)

1 To adjust the set vehicle speed


■ To adjust the set vehicle speed
If the vehicle speed of the detected preceding vehicle is slower than the set vehicle
Hand of RES / + Switch and - / SET In the operation of the switch, to raise / lower the set vehicle speed
speed the vehicle is raised, it may not accelerate the speed of the vehicle. This is
can do.
the order to maintain the inter-vehicle distance to the preceding vehicle has been

RES / + set.
vehicle speed

Increase the vehicle speed

Stepping on the accelerator pedal, - / SET Press the switch

Strike, the current vehicle speed becomes the set vehicle speed.

operation Switch to lower the

- / SET switch

RES / + switch
• Increases set by 1km / h speed Each time you press 1 times

• Press and hold one by 10km / h raise the set vehicle speed, fixed to the set vehicle speed when you release the hand

- / SET switch
• Drops set by 1km / h speed Each time you press 1 times

• Press and hold 10km / h by setting the vehicle speed is lowered and secured to the set vehicle speed when you release the hand

294
uu Honda sensing u Congestion following function with ACC (adaptive cruise control)

■ To set up an inter-vehicle distance

Distance switch Press the distance switch, and set the vehicle-to-vehicle

distance.

Vehicle-to-vehicle distance setting of the preceding vehicle, you can switch

to the four stages.

Each time you press the distance switch, the longest

→ It will change the length → medium → short. Be sure to determine the

appropriate setting of the inter-vehicle distance.

operation

Continued on next page 295


uu Honda sensing u Congestion following function with ACC (adaptive cruise control)

As the vehicle speed is low, the inter-vehicle distance is shorter. A measure of the distance between vehicles is as follows.

Always check the surrounding circumstances, try to safe driving, select an inter-vehicle distance in accordance with the actual traffic

conditions, please traveling.

Vehicle-to-vehicle distance setting When the vehicle speed 100km / h when the vehicle speed 80km / h

Short About 25m About 30m

During ~ About 34m About 42m

operation
The length About 47m About 58m

The longest About 63m About 80m

Preceding vehicle stops, vehicle-to-vehicle when the vehicle was also stopped automatically, will change by the vehicle-to-vehicle

distance setting.

296
uu Honda sensing u Congestion following function with ACC (adaptive cruise control)

1 To cancel
■ To cancel
In to restore the set speed of the previous release:
If any of the following, ACC is with congestion following
CANCEL switch
After releasing the ACC with congestion following function, even in the stop state
function will be canceled.
RES / + Set before releasing and pressing the switch
• CANCEL Pressing the switch
You can start the operation by the vehicle speed. However, in the
• MAIN Pressing the switch
case of the following does not return.

u ACC (green) goes off in the meter • MAIN After OFF the ACC with congestion following function by

You. pressing the switch


MAIN
switch • Stepping on the brake pedal • 30km / h preceding vehicle in the following Outside When there is no

u If it is stopped, the brake pedal


It stepped in does not release ACC with congestion following

function.

operation

Continued on next page 297


uu Honda sensing u Congestion following function with ACC (adaptive cruise control)

■ Automatic release of the ACC with congestion following function 1 To cancel

In the following cases, is displayed as "ACC OFF" to the multi-information display, a buzzer sounds and the "copy", ACC Released parked:

with congestion following function will be canceled automatically. If it is congestion following function with ACC collapsed except

• When bad weather (rain, fog, snow, etc.) when by congestion following function with ACC and the vehicle is

automatically stopped, a warning to the multi-in conformation


• When the front grill is dirty
display warning tone sounds might be displayed.
• If you can not detect a stable manner the preceding vehicle

• When it detects an abnormality of the tire

• When a long period of time traveling on a mountain road and bad road

• When the sudden steering wheel operation Pipipipi ...


• When the ABS and VSA, or CMBS, was activated
• When the VSA warning light is lit

• When you are stopped at the steep slopes

operation
• When applying the parking brake
• When the vehicle-to-vehicle distance between the detected preceding vehicle is too short

• When the preceding vehicle was gone in a stopped state

• When the sudden acceleration Quickly the brakes, please keep an appropriate distance between
• When the vicinity of the front glass top of the camera or the camera is dirty vehicles.

• Cargo space and the second seat, third seat ✤ Come and have gained a heavy luggage

• When you travel the dark of night or in a tunnel


• When you remove the seat belt of the driver's seat in the vehicle is stopped

• When the vehicle is stopped for more than 10 minutes

• When the power mode to the OFF mode


• When the brake system warning light (orange) is lit

298
✤ : Due to the type and options, different equipment.
uu Honda sensing u LKAS (lane keeping support system)

LKAS (lane keeping support system)


LKAS is a camera that is installed on the front glass top, capturing the right and left white lines (yellow 1 LKAS (lane keeping support system)

line), the movement of the electric power steering assist, a system for auxiliary lane keep running.
w
LKAS is should be used as an auxiliary system. LKAS is

■ The operation of the system not a automatic operation system. Last is the system of

assistance to order the driver. If you do not use the

Front sensor camera instruction manual, it unexpected therefore lead, there is

a fear upcoming are in death or serious injury. Always

check the surrounding situation, please travel safe

driving is mind only.

operation
Please do not place any objects on the instrument panel top. There
are cases where things can not be accurately detect the lane is
reflected in the front glass. LKAS will alert only when it detects a
lane change without issuing direction indicator (the blinker). LKAS
is, you may not be able to detect all of the lane lines and lane
departure. The time weather and fast, by road conditions, it is that
the system does not work. The driver to check the road situation
around, please traveling try to safe driving.

If you change lanes, LKAS will momentarily canceled state is operated direction indicator (the blinker). Then, detect
the white line is traveling in the center lane camera (yellow line) Then, LKAS will return. When you change lanes
without getting a turn signal, the lane departure warning LKAS is not released will be activated.

LKAS, in the repetition of steep curves and acceleration and deceleration


is followed by road, there is a Re hyperemesis the system does not
function properly. LKAS, please use when operating the high-speed roads
and motorways.

Continued on next page 299


uu Honda sensing u LKAS (lane keeping support system)

■ Lane keeping support function 1 LKAS (lane keeping support system)

Car to assist so as to run the center of the lane, the stronger the steering force of the electric power steering and closer to LKAS is there you will if you do not operate normally depending on the conditions.

the white line (yellow line).


2 Conditions and restrictions of LKAS P.306

Please see below for the handling of the camera that is mounted on

the front glass top.

2 Front sensor camera P.327

If the camera can not detect lane, temporary system will be

canceled. The system will automatically reset when detecting the

lane.

■ Lane departure warning function


operation
The car will do in the fall when the vibration of the steering wheel the warning of lane departure and display displayed in the alarm area.

Warning area

Warning area

300
uu Honda sensing u LKAS (lane keeping support system)

1 To activate the LKAS is


■ To activate the LKAS is
When the system is operating, if biased to the left and right of the
LKAS system will operate under the following conditions.
white line (yellow line), please have it inspected at the Honda dealer
• When the vehicle speed is running at about 65 ~ 100km / h
of specified to stop the system.
• When white (yellow line) is running near the center of the lane that is pulled to the left and right

• When traveling straight or radius 230m more gentle curve of the road White line you may not be able to correctly set the running position it can not

• When not actuated the wiper in a continuous properly detect the (yellow line).

• If you do not step on the brake pedal 2 Conditions and restrictions of LKAS P.306

• When not out direction indication device (blinker)

operation

Continued on next page 301


uu Honda sensing u LKAS (lane keeping support system)

■ System method of working 1 To activate the LKAS is

1. MAIN Pressing the switch In order to operate the system properly, please be sure to observe
MAIN switch u LKAS system is turned ON, Maruchii the following things.

LKAS indicator (green) will light down • Glass in the vicinity of the camera should always be clean

conformation in the display. • When you clean the windshield, so that such as glass cleaner

does not adhere to the lens of the camera

• Do not touch the camera lens

• Not put the sticker on the glass in the vicinity of the camera

2. Pressing the LKAS switch

LKAS switch u LKAS system will be in a standby state.


Lane displayed on the multi-information Display b
operation (dotted line) lights up.

3. Traveling in the vicinity of the center of the lane

u The camera is both sides while traveling in the vicinity of the center of the lane

Upon detection of a white line (yellow line), LKAS will start

the control.

302
uu Honda sensing u LKAS (lane keeping support system)

1 To cancel
■ To cancel
MAIN When you press the switch, it will also be released ACC with a follow-up
When one of the following, will be LKAS collapsed
MAIN function residence bitter at the same time as LKAS.
removal.
switch
• MAIN Pressing the switch

• Pressing the LKAS switch

Even in LKAS the ON state at the time of the previous traveling, LKAS

every time the power mode to the OFF mode is turned OFF.

LKAS
switch

operation

Continued on next page 303


uu Honda sensing u LKAS (lane keeping support system)

■ Temporary release of LKAS

In the case of the following, lane displayed on the

multi-information di splay is displayed by a dotted line, LKAS is

automatically canceled.

• When the wiper and continuous operation

u When you turn OFF the wiper, LKAS the return

To do.
• When the wiper switch is continuously operated wiper
is at the AUTO is, LKAS is canceled automatically.

Operating stop of the wiper, or comes to intermittent

operation dynamic, LKAS will return.

operation
• When the brake operation
u When stepping on the brake pedal deceleration, etc.

LKAS is released, it is or become a stand-by state. Release the

foot from the brake pedal, when the system detects the left and

right of the white line (yellow line) LKAS will return

automatically.

• When the vehicle speed is equal to or less than 60km / h

u When the vehicle speed is less than or equal to 60km / h, LKAS is

Automatically canceled. When the vehicle speed is greater than or

equal to 65km / h, LKAS will return.

304
uu Honda sensing u LKAS (lane keeping support system)

■ When the LKAS is automatically released momentarily 1 When the LKAS is automatically canceled

• If you can not detect the white line (yellow line) You can set the ON / OFF of the automatic release buzzer by using

• When the sudden steering wheel operation the multi-information display.

• When you do not have a handle operation


2 Customization features P.114
• When traveling on a steep curve

• When traveling in exceeding the speed limit speed

If these conditions last long, the system will resume automatically.

■ When the LKAS is automatically canceled


In the case of the following, lane displayed on the multi-information display is displayed by a dotted line,
the buzzer sounds, it may LKAS is automatically canceled.
• When the temperature of the camera has become a high temperature above a certain

• When the front glass in the vicinity of the camera or the camera is dirty
operation
• When the ABS, VSA is working

Continued on next page 305


uu Honda sensing u LKAS (lane keeping support system)

■ Conditions and restrictions of LKAS

In the following conditions, the system can not detect the white line (yellow line), it may LKAS is not such function properly.

■ Cases where the camera can not be correctly detected by the environment

• White line when it is not possible to distinguish between (yellow line) and the road surface

• Rain, fog, in the case of bad weather, such as snow

• When it is wet or there are still snow on the road surface

• When traveling toward the sun at the time of dawn and dusk

• When a strong light is reflecting on the road

• And tunnel entrances, when the tree, and in the brightness of the shadow of the building has changed

• When after the rain, etc. there is and puddles when you are shining wet road surface

operation • White line when it is reflected in the shadow in the vicinity of the (yellow line) (trees, buildings, guard rail, vehicle, etc.)

306
uu Honda sensing u LKAS (lane keeping support system)

■ Cases where the camera can not be correctly detected by the state of the road

• When traveling on the section in which there is a lane restrictions and temporary lane

• For road repair and the old white line (yellow line), blurred and overlapping, when the tire marks, a variety of white line (yellow line)

is on the road

Line is thin Left off of the old lane Tire marks

• When traveling a section a section or lane number of lanes such as an intersection or crosswalk is increased or decreased being

highly cross

• When time and width of the lane is extremely narrow, or when changing

Lane width is extremely wide / narrow operation

• When such vehicle is hiding a part of the white line (yellow line)

• When the slope and, approaching the top of the hill

• When the vehicle is swaying widely with step


• Those road (curb, guardrail, pylon, etc.) when the recognized white lines (yellow line)
• When the road is not foresee or earlier when the look distorted lane undulate

• When traveling on the roads and rough roads that have not been paved

• When traveling on a road lane is depicted in double


• When traveling on a slippery road surface, such as a frozen road and snow road

• When the paved road in the snow, puddles of snow road or a street is partially visible

• When you are traveling on a road with an unpaved road or a rut


Continued on next page 307
uu Honda sensing u LKAS (lane keeping support system)

• When traveling, etc. branching and merging path

Branches that are not drawn the line

operation

308
uu Honda sensing u LKAS (lane keeping support system)

■ Cases where the camera can not be correctly detected by the state of the vehicle

• When irradiation dirty lens of the headlight is deviated weak or when the optical axis

• Front glass outside dirt, mud, when you are covered, such as in the wet snow

• When the front glass inside is cloudy


• When there is wiped of the wiper
• Size and type, or not wear the tire and wheel of a different structure, when the tire air pressure is not

appropriate

• Cargo space and the second seat, third seat ✤ Laden with heavy luggage, when it is tilted car

• If you change the suspension


• When the inter-vehicle distance to the preceding vehicle is short

• When it is equipped with a tire chain

operation

309
✤ : Due to the type and options, different equipment.
uu Honda sensing u Road departure suppression function

Road departure suppression function

Road departure suppression function The system detects potential lane departure of the vehicle, this function notifies in 1 Road departure suppression function

supporting the operation to avoid lane departing de warning.


w
Road departure suppression function, please use as an
■ The operation of the system
auxiliary system. Road departure suppression function, rather
This system detects the white line or yellow line depends a
than the automatic operation system, not a substitute to
camera mounted on the front glass top, when it is determined
handle operation of the driver. Oh it is the system in order to
that deviates from the white line (yellow line) without using the
assist the driver in bear.
turn signal a (blinker) operates you.

Performs by Ri warning to the multi-information display,


If you do not use the instruction manual, it unexpected
prompting the operation of a driver by causing short vibration
therefore lead, there is a fear upcoming are in death or
handle, to support want the handle operation in a direction to
serious injury.
operation prevent further deviation.

Always check the surrounding situation, please travel safe


When also required a large steering wheel to avoid deviations, also driving is mind only.
performs support of the brake operation to support together with the
Road departure suppression function warns when it detects the lane
steering wheel operation. Support of the brake operation, the detected
departure that do not use direction indicator (the win car).
line is done only when the solid line.

There are cases where lane lines not detect a (white line or yellow line) and

lane departure. In addition, the weather, depending on the speed and road

conditions, you may not be able to support.

Please see below for the handling of the camera that is mounted on

the front glass top.

2 Front sensor camera P.327

310
uu Honda sensing u Road departure suppression function

In support of the system if the driver operates to prioritize the 1 Road departure suppression function

operation of the driver. If the driver has not operated during Road departure suppression function may not operate normally.

support to display the left Symbol warning.


2 Conditions and restrictions of the road departure suppression function P.313

And when the operation by the driver is being carried out, depending on

the situation of the road surface it may not feel the support.

It is displayed repeatedly left of warning, if there is no operation of the

driver, and then interrupted the support audible alarm will sound.

Select "Me assist timing early" in customization, if not actuate the


operation
LKAS (lane keeping assistance system), to the following message is

displayed and detects the possibility of lane departure.

2 Customization features P.114

Continued on next page 311


uu Honda sensing u Road departure suppression function

■ The operating conditions of the system


1 The operating conditions of the system

Road departure suppression function is automatically turned OFF, there is a case where
Road departure suppression function, when the following conditions are met, will be activated.
off-road deviation suppression function warning light is illuminated.
• When the vehicle speed is running at about 60 ~ 100km / h

• When you are traveling on a straight line or gentle curve of the road
2 Warning light P.65
• When not in use the direction indicator a (blinker)
• When the wiper is not operating in a continuous Under the conditions of the following it has to suppress the road departure suppression

• When the system determines the accelerator, brake, and there is no driving intention from the amount and frequency of operation of function.

the steering wheel • When not traveling in the lane

• On the inside curve, when they've been traveling protrudes

• When the lane width is narrow

1 System of ON and OFF


■ System of ON and OFF
operation
To use the multi-information display you can customize the
Press the road departure suppression switch, please switch the
configuration of the system.
ON and OFF of the system.

u When the system is ON, road departure suppression If you select the "steering assist without warning only" in the
Switch the indicator lights up, a message is customization features, the system does not perform the handle you

displayed on the multi-information display. and brake control.


2 Customization features P.114

After battery reconnection, congestion following function with ACC warning

Tsugeto and CMBS warning light, road departure suppression function


indicator
warning light, VSA warning light, VSA OFF warning light, when the brake
Road departure suppression switch
system warning light (orange) are temporarily turned there is. Will be turned

off for a while traveling at a speed 20km / h or more. Please have it

inspected at the Honda dealer when it is not turned off.

312
uu Honda sensing u Road departure suppression function

■ Conditions and restrictions of the road departure suppression function

In the following conditions, the system can not detect the white line (yellow line), the system might not function

properly.

■ Cases where the camera can not be correctly detected by the state of the environment

• White line when it is not possible to distinguish between (yellow line) and the road surface

• Rain, fog, in the case of bad weather, such as snow

• When it is wet or there are still snow on the road surface

• When traveling toward the sun at the time of dawn and dusk

• When a strong light is reflecting on the road

• And tunnel entrances, when the tree, and in the brightness of the shadow of the building has changed

• When after the rain, etc. there is and puddles when you are shining wet road surface

• White line when it is reflected in the shadow in the vicinity of the (yellow line) (trees, buildings, guard rail, vehicle, etc.) operation

Continued on next page 313


uu Honda sensing u Road departure suppression function

■ Cases where the camera can not be correctly detected by the state of the road

• When traveling on the section in which there is a lane restrictions and temporary lane

• For road repair and the old white line (yellow line), blurred and overlapping, when the tire marks, a variety of white line (yellow line)

is on the road

• When traveling a section a section or lane number of lanes such as an intersection or crosswalk is increased or decreased being

highly cross

• When time and width of the lane is extremely narrow, or when changing
• When such vehicle is hiding a part of the white line (yellow line)

• When the slope and, approaching the top of the hill

• When the vehicle is swaying widely with step


• Those road (curb, guardrail, pylon, etc.) when the recognized white lines (yellow line)

• When the road is not foresee or earlier when the look distorted lane undulate

operation
• When traveling on the roads and rough roads that have not been paved

• When traveling on a road lane is depicted in double


• When traveling on a slippery road surface, such as a frozen road and snow road

• When traveling, etc. branching and merging path

• When the paved road in the snow, puddles of snow road or a street is partially visible

• When you are traveling on a road with an unpaved road or a rut

314
uu Honda sensing u Road departure suppression function

■ Cases where the camera can not be correctly detected by the state of the vehicle

• When irradiation dirty lens of the headlight is deviated weak or when the optical axis

• Front glass outside dirt, mud, when you are covered, such as in the wet snow

• When the front glass inside is cloudy


• When there is wiped of the wiper
• When the camera temperature is hot

• Size and type, or not wear the tire and wheel of a different structure, when the tire air pressure is not

appropriate

• Cargo space and the second seat, third seat ✤ If you are inclined vehicle loaded with heavy luggage

• When it is equipped with a tire chain


• When the inter-vehicle distance to the preceding vehicle is short

• If you change the suspension operation

315
✤ : Due to the type and options, different equipment.
uu Honda sensing u The preceding vehicle start notification function

The preceding vehicle start notification function

In such as waiting for a signal, when the preceding vehicle continues to stop without noticing that you have starting, is a system that 1 The preceding vehicle start notification function

informs the driver with sound and display.


w
The preceding vehicle start alert function is an auxiliary
system to Assist the driver. Not a system to inform the
situation that you can safely start.
Leading vehicle

If you do not use in accordance with the instruction manual, it can

lead therefore it unexpected.


Stop Stop Take-off

When you start, the driver is enough to check the surroundings and the

front side of safety visually, please drive to keep the proper distance
operation
■ The operating conditions of the system
between vehicles.
The preceding vehicle followed by a stop (vehicle-to-vehicle distance in a stopped state within about 10m, and the subject vehicle, the

preceding vehicle while stopped) continues to recognize the result preceding vehicle, the preceding vehicle detected even if the vehicle As with other driver assistance systems, the preceding vehicle start

the start of the stop It will be activated when continued to. notification function, it may not function depending on the weather and the

environment.

■ Select lever ( D , ( S in the case of


The preceding vehicle start notification function can be to OFF.
Brake holding function or automatic brake hold has stepped on the brake pedal is operated.

2 Customization features P.114

When the congestion following function with ACC (adaptive Kuruzuko

Control) warning light is lit, it does not work the previous line cars start

notification function.

2 Congestion following function with ACC (adaptive crew

'S control) P.283

316
uu Honda sensing u The preceding vehicle start notification function

■ Select lever ( N in the case of 1 The preceding vehicle start notification function

Brake holding function or or automatic brake hold the parking brake is applied has stepped on the Please see below for the handling of the radar sensor.

brake pedal is operated. You can select the operation timing of the system from the standard-early
2 Radar sensor P.329

two-step.
2 Customization features P.114 For the handling of the camera that is mounted on the front glass

top refer to the following.


Standard will be activated when the preceding vehicle has advanced about 3m or more from the stop state. Early

it will be activated when it detects the start of the preceding vehicle.


2 Front sensor camera P.327

operation

Continued on next page 317


uu Honda sensing u The preceding vehicle start notification function

■ The operating state of the system

When the system is activated, the buzzer sounds as a


"pawn", a message is displayed on the multi-information
pawn
display.

■ Conditions and limitations of the preceding vehicle start notification function

The following cases, if no preceding vehicle is starting or even operating system, even if the preceding vehicle
operation
is not to start the system might not work.

■ Cases radar sensor according to the state of the vehicle can not be correctly detected
• Cargo space and the second seat, third seat ✤ Laden with heavy luggage, when it is tilted car

• When the front grill is dirty


• When the time you are stopping of the vehicle is short

■ Cases where the radar sensor can not be properly detected by the environment

• Rain, fog, in the case of bad weather, such as snow

• When there is a wind-up of splashes and snow by the front of the vehicle

318
✤ : Due to the type and options, different equipment.
uu Honda sensing u The preceding vehicle start notification function

■ Cases where the radar sensor can not be properly detected by the state of the road
• Curve, undulating road, immediately after the right or left turn, when such a slope

• Narrow such as when traveling on a railway bridge, those which strongly reflects radio waves around the vehicle there Rutoki

■ Cases where the radar sensor can not be properly detected by the preceding vehicle of state

• When the time you are stopping of the preceding vehicle is short

• When the distance to the preceding vehicle is extremely short

• When the preceding vehicle is moving at an extremely slow speed

• When the preceding vehicle has been right or left turn or sharp turn

■ Others, cases where the radar sensor can not be detected correctly
• Pedestrian and bicycle, motorcycle, such as a vehicle of a special shape
operation
• Another vehicle and pedestrians between the preceding vehicle and the vehicle, when a've been interrupted, such as bicycle

• When the preceding vehicle is not in the front of the vehicle

319
uu Honda sensing u Sign Recognition function

Sign Recognition function

Sign Recognition function displays a road sign information recognized during traveling in multi-information 1 Sign Recognition function

display, it is the ability to inform the driver. Road signs to be displayed is one 4 below.
w
• maximum speed Sign recognition function will be used as an auxiliary function.

• Protruding traffic ban Sign recognition function is not a function to operate in all

• pause situations. Last, This function is used to assist the driver.

• Vehicle entry ban Always check the surrounding circumstances, safe driving
the mind only, please traveling.

■ Way of working
Recognize specific road signs with a camera on the front glass top while the vehicle is running, the This feature, but it has been designed to recognize the road signs
multi-information display to display a road sign information. of Japan, not all of the label is displayed.

operation
Please see below for the handling of the camera that is mounted on

the front glass top.

2 Front sensor camera P.327

320
uu Honda sensing u Sign Recognition function

Sign recognition function will operate under the following conditions.

• Maximum speed / squeeze-out traffic ban: working regardless of the speed

• Pause / vehicle entry ban: when the speed of the vehicle is less than or equal to about 60km / h

When the following, will switch to those road sign information is another.

• When we recognize the maximum speed label that is different from the maximum speed in the display

• Stop sign, or, when it recognizes the vehicle no entry sign

The following road sign information will disappear when.

• No traffic protrusion and top speed, when the passes through the labeled traveled distance of (several hundred to one thousand

and several hundred m) set for each indicator, or when the auxiliary label indicating the end recognized

• Pause, when passing through the label


operation
• Vehicle entry ban, when passing through the labeling does not enter

• When you right-left turn while out direction indication device (blinker) at the intersection

Continued on next page 321


uu Honda sensing u Sign Recognition function

If you can not or if the recognized road sign is not recognized during operation you may receive the following screen is 1 Sign Recognition function

displayed. When the multi-information display in the "can not be part of the use

of luck rolling support system camera is hot" is displayed, without

labeling recognition function is activated, it is displayed.

• Sai that will lower the temperature inside the vehicle by using the

air conditioning. If the window glass is cloudy, if necessary,

please use the defroster.

• To drive the vehicle, please lower the front glass and the

temperature around the sensor camera.

Come with the multi-information display "part of the luck rolling

support system can not use front Ntogarasu have dirt" is displayed,

without labeling recognition function is activated, it is displayed.


operation

Please drop a safe place to park the car, the front glass Re-fouling.

Clean the front glass, if you do not disappear message even after

running for a while, please accept the inspection by Honda dealer.

322
uu Honda sensing u Sign Recognition function

■ Conditions and limitations of the sign recognition function 1 Sign Recognition function

If you sign recognition function has failed will be displayed in the


In the following, such as the case is, it might have to recognize the signs or delay, can not be recognized.
multi-info mation display.

If the message does not disappear, please have it inspected by

Honda dealer.
■ Cases where the camera can not be correctly detected by the state of the vehicle

• When irradiation dirty lens of the headlight is deviated weak or when the optical axis

• Front glass outside dirt, mud, when you are covered, such as in the wet snow

• When the front glass inside is cloudy


• When there is wiped of the wiper
• Size and type, or not wear the tire and wheel of a different structure, when the tire air pressure is not

appropriate

• Cargo space and the second seat, third seat ✤ Laden with heavy luggage, when it is tilted car
operation

■ Cases where the camera can not be correctly detected by the environment

• When traveling toward the sun at the time of dawn and dusk

• When a strong light is reflecting on the road

• And tunnel entrances, when the tree, and in the brightness of the shadow of the building has changed

• Dark places, such as at night or in a tunnel

• Rain, fog, in the case of bad weather, such as snow

• When there is a wind-up of splashes and snow due to the vehicle ahead

Continued on next page 323


✤ : Due to the type and options, different equipment.
uu Honda sensing u Sign Recognition function

■ Cases where the camera can not be correctly detected by the position and status of the label

• If the periphery of the label is difficult to find a complicated and labeling

• Labels in a position far away from the vehicle

• Labels in the light hardly reaches the position of the vehicle headlights

• Label that has been installed in the previous corner and curve

• Faded signs and bent label


• Orientation has been changed signs and damaged labels

• Mud, snow, or, covered with, such as frost labeling

• Labeling a part or hidden, such as in the trees, it became a shadow of a vehicle or the like

• If the light (such as street lighting) and shadows are in reflected on the label on the surface

• Or too bright, dark labels (lightning formula labels)

• Of small size labels (such as an auxiliary indicator indicating the end)

operation

324
uu Honda sensing u Sign Recognition function

■ Others, cases where the camera can not be correctly detected

• When the vehicle is traveling at a high speed

In the following, such as case, the label recognition does not work properly, or to a different display and regulatory

content for the track of the vehicle, in fact, this may cause a display for there is no sign of interest.

(At the highest speed indicator, or display a higher value than the actual speed limit, you may or display
a lower number.)
• On top of or under the label, the point of regulation (start, such as the end) and conditions (day of the week, such as time zone) when

there is a supplementary indicator showing

• Hard luck to discriminate A numeric indicator (lightning-type labels, the numbers were faint signs, etc.)

• Is not a label against the vehicle runway, located near the runway of the vehicle, if the label is facing runway of the vehicle

(such as a stop sign at the point where the side road joins the main line)
operation
• Labeled color recognition target, the shape, if there is something similar to figure (similar label, an electric bulletin board, billboard,

climb flag, structure, etc.)

Continued on next page 325


uu Honda sensing u Sign Recognition function

1 Display of multi-information display


■ Display of multi-information display
When entering the vehicle breach zone vehicle entry ban icon
Displays the road sign information to two at the same time. Maximum speed or stop sign on the right side, to
flashes. About After flashing for 5 seconds, vehicle entry ban icon
display the traffic ban or traffic-sign sticking out on the left side.
will disappear.

Display example of when the selection display mode

Multi-information display, in addition to the selected display mode,

you can select the resident display mode.

2 Display of switching how P.104

2 Customization features P.114

Road signs display of the resident display mode

When the resident display mode state, can be a multi-info mation


Display example when the resident display mode
operation
display continues to display a road-labeled icons of reduced size.

Left the vehicle entry ban, the right takes precedence display a temporary stop.

326
uu Honda sensing u Front sensor camera

Front sensor camera

Front sensor camera The camera has been installed in the front glass top. 1 Front sensor camera

Scratches on the front glass of the camera's field of view, dents, if


there is damage, the system may stop working properly. If you

Such as when it is parked in the hot sun, the room temperature encounter this problem, we recommend the replacement of the
front glass.
becomes a high temperature, it there if the camera function is

paused. In order to prevent a pause, during parking it is System and you want to use the front glass other than the Honda

genuine products may no longer operate normally.


recommended that you park in the shade to avoid the sun light. If

you want to use the reflection sunshade, please do not cover the
If you want to repair or replacement of the front glass, please
camera. There is a possibility that the camera to concentrate the consult your Honda dealer.

heat and cover. Or attach the film to the front glass, Do not install
Please do not damage or contaminate the camera's lens.
the ones that block the field of view of the camera.

2 Cleaning of car P.377


operation

Please do not place any objects on the instrument panel top.

Sticker is not There are cases where things can not accurately detect the lane or the like

possible to paste is reflected in the front glass.


range

Please do not remove the camera. There are times when the

system is not working properly. Please consult your Honda dealer

in the following cases.

• When an impact is applied to the camera and the peripheral portion

Please take a cloudy If the front glass is cloudy.

Use a defroster as necessary.

Continued on next page 327


uu Honda sensing u Front sensor camera

1 Front sensor camera

Please do not wear those that interfere with the camera's field of

view on top of the hood and front grill. System interfere with the

field of view of the camera may not operate normally.

If the multi-information display in the "luck rolling supported in part

is you can not use the camera of the system is the

high-temperature" is displayed:

• Sure to lower the temperature inside the vehicle by using the air

conditioning. Use the defroster, if necessary, do as the wind

toward the camera.

• To drive the vehicle, please lower the front glass and the
operation
temperature around the sensor camera.

If the multi-information display "part can be used No windscreen of

luck rolling support system is dirty" is displayed:

• Park the car in a safe place, please drop the dirt of the front

glass. Clean the front glass, if you do not disappear messages

even after traveling for a while, please have it inspected by

Honda dealer.

328
uu Honda sensing u Radar sensor

Radar sensor
Radar sensors have been installed at the back of the 1 Radar sensor

front grill. Please do not give a strong shock to the periphery of the front grill.

Radar In order to operate the system properly, please be sure to observe


sensor the following things.

• The front grille should always be clean


• Benzine to clean the front grill, thinners such, do not I use a
polish such as cleanser

• Not put paint or stickers the front grill

• Do not replace the front grill

In the case of the following, please consult your Honda dealer.

• When an impact is applied to the radar sensor operation


• When performing the repair of the peripheral front grill

When the following, for which there is a case in which radar sensor
is not working correctly, please have it inspected by Honda dealer.

• The front grill is a step, curb, ring closure, when in contact, such as

in Sheng Ri soil

• When entering into a deep puddle


• Vehicle front collision, when contacted

When the power mode to ON mode, please let stationary car. Such
as on a parking lot turntable of, and in ON mode the power mode
when the vehicle is in motion, there is a case where each function
does not work.

329
Brake operation

Brake system

■ Electronically controlled parking brake 1 Brake system

Is a brake which mainly used at the time or parking the vehicle is stopped. You can cancel and manual operation of the automatic. When I stepped on the brake pedal, for the operation of the brake
device, you may like hear motor sound from the engine room, but
this is not a malfunction.

■ When you manually operated

In operation of the parking brake switch, and you can cancel or apply the parking brake. 1 Electronically controlled parking brake

Do not apply the parking brake, operating sound you will hear in the

Such as during the start of the steep downhill, and manually release the parking brake, you can make period and was released. This is not an abnormality in the sound of

the brake system is operating.


smoothly for starting.

■ Manually apply the parking brake


Do not apply the parking brake, it is released it may brake pedal
Please slowly and surely pull the parking brake switch.
moves. This is not a malfunction due to the operation of the brake

operation system.
u When the parking brake is actuated, blanking
Rake warning light (red) lights up.
When the battery is up, or multiplied by the parking brake can not

Parking brake switch be released.

2 Jump Start P.403


■ Manually release the parking brake
1. When the power mode is ON mode, the right foot
And continue to pull the parking brake switch during travel, during
In stepping firmly on the brake pedal. which borrows whether the parking brake.
2. Press the parking brake switch.
u Parking brake is released, blanking
Rake warning light (red) will go off. When the 10 minutes or more congestion ACC or Automatic tick
brake hold system with follow-up function is stopped in a state in
Parking brake switch
which to operate, parking brake will take automatically.

330
uu Brake operation u Brake system

■ Automatic parking brake function 1 Electronically controlled parking brake

When the automatic parking brake function is turned ON: When the congestion following ACC or automatic brake hold

Parking brake will take on automatically when the power mode to the OFF mode. That is under the system with function is to remove the seat belt in a state that is

parking brake, please check the brake warning light (red). operating, it takes Parkinson ring brake automatically. When the

congestion following ACC or automatic brake hold system with

function has the power mode to the OFF mode in a state in which to
2 To turn ON / OFF the automatic operating function P.332
operate, it will take the parking brake in automatically.

■ When automatic release


Operation and parking brake release of the accelerator pedal are linked. It is convenient to the start of

the traffic jam and uphill.


Trees and can not release the parking brake automatically, please

manually release.
Do stepped slowly the accelerator pedal.
Accelerator pedal
When the next warning light is lit, it can not be automatically
operation
u Parking brake is released, blanking released.

Rake warning light (red) will go off. Automatic release of • PGM-FI warning lamp

the parking brake can be done when the following conditions


• Transmission warning light

are met.
When the next warning light is lit, you may not be able to automatic
• When wearing the driver's seat belt
cancellation.
• When the engine has been started
• Brake warning light (red)
• The shift position is, when other
P N
than • VSA warning light

• ABS warning light

• Air bag system warning light

Continued on next page 331


uu Brake operation u Brake system

■ To turn ON / OFF the automatic operating function 1 Electronically controlled parking brake

Auto operating functions of the parking brake, power mode can be switched ON and OFF in the following During the cold, and apply the parking brake, it may be frozen. And

operation at the time of the ON mode. the automatic operating functions to OFF, please refer to the ring
closure such as in stone. In addition, in the case of towing, OFF the
1. A select lever ( P Put in.
self-action motion function, if necessary, please do not to apply the
2. Without going through the brake pedal, pull up the parking brake switch.
parking brake.
u Please make sure that the brake warning light (red) is on.
3. To remain raised the parking brake switch.
Release your finger begins to ring with the "beep beep beep - - - -", again it is left to raise the parking
brake switch for less than 3 seconds.
Four. Operation complete sound releasing the hand from the switch When you hear.

u When the automatic operating function is turned ON, you will hear the "beep beep".

u When the automatic operating function is OFF, you will hear a "peak".

u State of operation of the parking brake, continue to check the brake warning light (red)
operation
Please.

In addition, by performing the following operation, you can temporarily turn OFF the automatic operation of the parking

brake.

1. To stop stepping on the brake pedal.


2. After the power mode to the OFF mode, the parking brake switch within two seconds
push.
u ON / OFF setting of automatic operating functions does not change.

u Congestion following function with ACC and automatic brake hold system machine of
Please go in a state in which the function is turned OFF.

u State of operation of the parking brake, continue to check the brake warning light (red)

Please.

332
uu Brake operation u Brake system

1 Foot brake
■ Foot brake
When traveling on a puddle, please check the degree of
This is the main brake for the deceleration and stopping of the car. It works with the brake pedal.
effectiveness of the brake.

When effectiveness is poor, please stepped on blanking Rekipedaru lightly several


Emergency brake assist to generate a large braking force by the time of braking is equipped with.
times until the effectiveness condition is returned.

2 Electronically controlled brake assist P.338 While stepping on the brake, if a constantly metallic grinding

Kosuoto hear you need to replace the brake pads.


In addition, in the ABS to prevent the locking of the brakes (anti-lock brake system), we are working to
improve safety. Please have it inspected by Honda dealer.

2 ABS (anti-lock brake system) P.337


If you continue down the brake pedal in the long downhill, brake to

overheat, no longer is a danger effectiveness of the brakes is evil.

operation
For this reason, long in such as downhill, use the engine brake.

S In to, make sure you use the engine brake.

And when the brake more automatic collision mitigation brake

(CMBS) such as functions of the vehicle operated, holds the brake hand

When the state or of these working have been released have, brake

pedal you can motion.

Continued on next page 333

Вам также может понравиться