Вы находитесь на странице: 1из 20

SHARI= SERVICE MANUAL

S2627G F320ABK

G F=320A( B K)
G F=320A( R)
G F=320A( P)
G F-320A(Y)
G F-320A( B L)
PHOTO: GF-320A(BK)

in the interests of user-safety the set should be restored to its


original condition and only parts identical to those specified be
used.

/ INDEX TO CONTENTS
Page
SPECIFICATIONS . . . . . . . . . . . . .
........ 2
STRINGING OF DIAL CORD . . . . . . . .
. . , . . . . . . . . . . . . 2
NAMES OF PARTS . . . . . . . , . . . . . . . . . . . . ........ 3
DISASSEMBLY . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . 4
BLOCK DIAGRAM . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . 5
CIRCUIT ADJUSTMENT . . . . . . . . . . .
. . . . . . . . . . . . 6-8
MECHANICAL ADJUSTMENT . . . . . . . .
. . . . . . . . . . 8
EXPLODED VIEW . . . . . . . . . . . . . .
. . . . . . . . . 9, IO
SCHEMATIC DIAGRAM . . . . . . . . . .
. r . . . . . . II,12
W I R I N G S I D E O F P.W.BOARD . . . . . . I . .
. . . I . . . . . . 13,14
NOTES ON SCHEMATIC DIAGRAM . .
. . . , . . . . . . . . 15
TYPES OF TRANSISTOR AND LED . . . .
1 . . . . . . . . . . 15
REPLACEMENT PARTS LIST . . . . . . . . . . . . . . . . . . 16-19

SHARP CORPORATION
L PLEASE REFER TO THE OPERATION MANUAL

SPECIFICATIONS

GENERAL RADIO
Power source: AC 240 V, 50 Hz Frequency range: FM; 87.6 - 108 MHz
DC 9 V (UM/SUM-1 or R20 x 6) A M ; 5 2 6 . 5 - 1,606.5 kHz
Output power: P M P O ; 2 0 W ( l o w + low) TAPE RECORDER
(AC operation) Tape: Compact cassette tape
MPO; 8W (4W + 4W) Frequency response : 100 Hz - 10,000 Hz
(AC operation) Signal/noise ratio: 36 dB
RMS; 3.8W (1.9W + 1.9W) Wow and flutter: 0.2% (WRMS)
(DC operation, 10% distortion) SPEAKER
(nput impedance: External mic; 600 ohms Speakers: 10 cm (4”) woofer x 2
Loaded impedance: Headphones; 8-25 ohms Horn type tweeter x 2
External speakers; 4-8 ohms Impedance: 4 ohms
Dimensions: W i d t h ; 4 9 4 m m (19-l/2”) Maximum power
Height; 180 mm (7-l/8”) handling capacity: 5 W (maximum)
D e p t h ; 130 m m (5-l/8”)
Weight: 2.8 kg (6.2 Ibs.) without I
batteries Specifications for this model are subject to change without
prior notice.

STRINGING OF DIAL CORD

Dial Cord Assembly (201)

1. Wind the dial cord over the tuning control and attach the
tuning control to the front cabinet.
2. Set the dial cord over the boss (A).
3. Set the dial cord over the bosses (B) and (C).

(A)

Tuning control shaft (Knob) Dial Poind &kg Point /


(215) (209)

Figure 2- 1

-2-
NAMES OF PARTS

1. Cassette Compartment
2. Headphone Jack
3. Volume Control
4. Balance Control
5. Power Indicator
6. FM Stereo indicator
7. Tuning Control
8. Function Selector Switch
9. Record Button
10. Play Button
11. Rewind Button
12. Fast Forward Button
13. Stop/Eject Button
14. Pause Button
15. Graphic Equalizer Control
16. Speaker Cord Holder
17. Speaker Release Lever
18. External Microphone Jack
19. External Speaker Terminals
20. Telescopic Rod Antenna
2 1. Battery Compartment
22. AC Power Supply Socket

1 234 56 7 8
7 18 19 20

21 22 17 16

Figure 3- 1 Figure 3-2

-3-
DISASSEMBLY
Record/Playback Selector Lever
Caution on Disassembly \/-----I
Follow the below-mentioned notes when disassembling the
unit and reassembling it, to keep its safety and excellent
performance:
1 . T a k e cassette out of the unit.
2. Be sure to remove the power supply plug from the wall Switch
outlet before starting to disassemble the unit and remove
the batteries from the unit. :/PB Head
3. Take off nylon bands or wire holders where they need
b e removed when disassembling the unit. After servic-
ing the unit, be sure to rearrange the leads where they
were before disassembling.
4. Take sufficient care on static electricity of integrated cir-
cuits and other circuits when servicing.

STEP REMOVAL PROCEDURE FIGURE $3 x 8mm


Figure 4-2
Main body section
I -
Front Cabinet 1. Battery comparment 4-l
lid .............................. (Atxl
2. Open the cassette
holder ............................ (B)
3. Screw ........................ (C)x5

Mechanism Block 1. Screw ........................ (01x2 4-2


2. Socket.. ...................... tE)x2
3. Tip ............................. (F)x2
-
Main P.W.Board ;. ~,“~o~d;,,,,a,k.~,l,,tbr(G)xl 4-3

sprmg......................... (Hlxl

Speaker section
/ I I
1 Front Cabinet / 1. Screw . . . . . . . . . . . . . . . . . . . . . . . . . (11x5 4-4

Note:
Set the mechanism in such a way as that the record/playback
selector lever is positioned as shown in Fig. 4-2.

Figure 4-3

Front Cabinet

(I)
@3 x 25mm

Figure 4- 1 Figure 4-4

-4-
SWIOI-A-F FUNCTION SELECTOR SWITCH
SWIOZ-A-J RECORD/PLAYBACK SWITCH

Figure 5 BLOCK DIAGRAM

-5-
CIRCU IT ADJUSTMENT (TUNER SECTION
AM IF/RF ADJUSTMENT Ckcilloscope
T e s t AM
- .
SWITCH AM
POSITION

SIGNAL 400 Hz, 30%. AM modulated


GENERATOR

TEST FRE- DIAL AD-


STEP STAGE QUENCY P O I N T E R JUST- REMARKS
S E T T I N G MENT Figure 6- 1 AM IF

1 IF 455 kHz High T3 Adjust for


frequency best “IF”
cu we. 455 kHz

2
Band
- coverage
3
510 kliz

1,650
kHz
Lowest
frequency

Highest
frequency
L8

TC8
Adjust for
maximal
output.

Repeat steps 2 and 3 until no further improvement can


A
Figure 6- 2 AM IF CURVE

Signal Test
Generator Loop Bar Antenna

Figure 6-3 AM RF

Figure 6- 4 ADJUSTMENT POINTS

-6-
FM IF/RF ADJUSTMENT 10.7 MHz Oscilloscope

WITCH FM mono
?OSITION I

SIGNAL 400 Hz, 30%. FM modulated.


GENERATOR
-
I 1 I 1
TEST AD-
;TEP STAGE JUST- REMARKS
MENT Figure 7-l FM IF
1. Using a minus
driver, turn
the core of

-Y- -%f
T2 counter-
1 IF Tl clockwise
before taking
10 .7 MHz High it out of the
frequency bobbin.
2. Adjust for
best “IF”
curve. Figure 7-2 IF CURVE Figure 7-3 FM S CURVE
Detection T2 Adjust for best
“S” curve.
Electronic
Repeat steps 1 and 2 until no further improvement can 1 / FM Signal Rod Antenna
External
Speaker
Voltmeter
be made. Generator
t 1 I~ ,( Terminal

Unit
‘I
Band frequency
coverage
5 109 MHz Highest TC2 maximal output. Dummy
frequency (See Figure 7-6)
1
6 Repeat steps 4 and 5 until no further improvement can Figure 74 FM RF
be made.
-

7 88 MHz 88MHz L2 Adjust for Electronic


Trackmg maximal
FM Signal
B 108 MHz 108 MHz TCl output.
Generator Rod Antenna
9 Repeat steps 7 and 8 until no further improvement can
7 be made.
I

VCO FREQUENCY ADJUSTMENT Dummy


GN/D
(See Figure 7-6)
SIGNAL 400 Hz, 30%. FM modulated
Figure 7-5 VCO FREQUENCY
GENERATOR (mono signal)
I I

A To Telescopic Rod Antenna

FM mono position FM stereo position (unmodulated) R2

98 MHz at 98 MHz VRl Adjust for


60 dB 38.00 kHz + 100 Hz. To Chassis GND

Rl = 500hms
z = 5o OhmsLR2 = 5. ohms
2: Output impedance of signal generator

Figure 7-6 FM DUMMY

-7-
CIRCUIT ADJUSTMENT (AUDIO SECTION)

. Volume control. Maximum External


SETTING Oscilloscope
POSITION l Graphic equalrzer control: Center
OF SWITCH l Balance control. Center

AND KNOB l Function selector switch: Tape

Test Tape
ADJUST- MTT-118
ITEM INPUT MENT REMARKS (CHECK)
POINT
Head
PLAY BACK Test tape ( 1 . 2 V *3 dB)
AMPLIFIER M T T - 1 1 8 __
SENSITIVITY F i g u r e 8- 1 PLAYBACK AMPLIFIER SENSITIVITY

MECHANICAL ADJUSTMENT

ITEM JIG 1 ADJUSTMENT Ruba3Ks (CHECK) E.V: ELECTRONIC VOLTMETER Dual-trace


POINTS External Svncroscope
I
Driving
power -
z&fjq (More than 140 g)

Test 1 ‘ape
Torque Torque meter (Play: MTT-1 13C
Play TW-2111 30 - 60 g-m)
Fast-forward (Fast-forward:
TW-223 1 55 - IlOgcm)
Rewind (Rewind: Head
TW-223 1 55- 1lOgcm)
Figure 8-2 A Z I M U T H
Azimuth Test Tape Azimuth Sine waveform
MTT-113C attains the External
adjusting screw
maximum. Speaker

Tape 3,000 *90 Hz


speed
Test Tape
MTT-111

, Record/Playback
Head

Figure 8- 3 TAPE SPEED

-8-
2 I 3 I 4 I 5 I 6
1 I

63

I
&,.49 ]
44,

57x3

v5
73
;c.

60mm 103
-‘
\,-&
/’
<
‘1
‘.

203

605
/

/ii&
214x6

/204(LEFT)
205fRIGHTl

GRAPHIC EOALIZER PWB-B /

‘“T 238
@ 21

Figure 10 CABINET EXPLODED VIEW


- 10 -

.
-,_ --- ._..---..---.._--
-__. I__.
-...-~__--_--- -III--2 .---_.. _ I
0103 290655 E
RIPPLE FILTER

l NOTES ON SCHEMATIC DIAGRAM can be found on page 15.

1 I 2 I 3 I 4 I 5 I 6
Figure 11 SCM
-ll-
I M A I N PWB-Al -
I

c44
Ill25”
P701, 0702
ZSCl815 G R
GRAPHIC EQUALIZEF
a703,0704
X:2;; G R

J III I I

<----J
/ POWER SUPP LY PWR-A,/

I 7 I 8 I 8 I 10 I 11 I 12
1 SCHEMATIC DIAGRAM
-12-
I 4 I 5 I 6 I
1 I 2 1 3
Figure 13 WlRiNG Sir
7 I 8 I 9 1 IO I II I I2

GRAPHIC EQUALIZER PW B - B

I 7 I 8 I 9 I IO I I I I I2
3 SIDE OF P.W.BOARD
- I4 -
NOTES ON SCHEMATIC DIAGRAM
l Resistor: l The indicated voltage in each section is the one measured
To differentiate the units of resistors, such symbol K and by Digital Multimeter between such a section and the
M are used: the symbol K means 1000 ohm and the symbol chassis with no signal given.
M means 1000 kohm and the resistor without any symbol is ( ): AM mode
ohm-type resistor. Besides, the one with “Fusible” is a fuse Marking except for ( ): FM mode
type. . Schematic diagram and Wiring Side of P.W.Board for this
0 Capacitor: model are subject to change for improvement without
To indicate the unit of capacitor, a symbol P is used: this prior notice.
s y m b o l P means micro-micro-farad and the unit of the l Parts marked with ” f!L ” (’ ) a r e i m p o r t a n t f o r m a i n -
capacitor without such a symbol is microfarad. As to elec- taining the safety of the set. Be sure to replace these parts
trolytic capacitor, the expression “capacitance/withstand with specified ones for maintaining the safety and perfor-
voltage” is used. mance of the set.
(CH), (TH), (RH), (UJ): Temperature compensation

2SC1815 GR
250655 E GL5PA6061F

E C 8

000
0
Figure 15 TYPES OF TRANSISTORS AND LED

-15-
Ll REPLACEMENT PARTS LIST
e
“HOW TO ORDER REPLACEMENT PARTS”

To have your order filled promptly and correctly, please furnish the following information.
S
1. MODEL NUMBER 2. REF. NO.
t
3. PART NO. 4. DESCRIPTION
I- NOTE:
S Parts marked with “A” are important for maintaining the safety of the set. Be sure to replace these parts with
‘_ specified ones for maintaining the safety and performance of the set.

REF.NO. PART NO. DESCRIFTION CODE REF.NO. PART NO. DESCRIPTION CODE
INTEGRATED CIRCUITS CONTROLS

ICI VHiTA7335P/-I FM Front-End, TA733.5 P AG VCl -4 RVC-R0085AFZZ


Variable Capacitors, Tuning AL
IC2 VH iAN7224//- 1 FM IF/AM Circuit, AN7224 AH with Trimmers:
IC3 VHiTA7343P/-1 PLL FM Stereo Multiplex, AG TCl: FM RF Trimmer
TA7343 P TC2; FM Oscillator Trimmer
ICl 01 VHiM51164Y-1 Pre Amp., M51 164L AG TC4; AM Antenna Trimmer
IC201 VHiBA5406//-1 Power Amp., 8A5406 AU TC8; AM Oscillator Trimmer
VRl RVR-M0390AFZZ 5 kohms(B) AB
TRANSISTORS VR202 92LVR-523A 50 kohms (G) AD
VR203(A,B) 92LVR-523B 20 kohms (U) AF
Q103 VS2 SD655 E/l- 1 Silicon, N P N , 2SD655 E AC VR701-703 RVR-Q0207AFZZ 1 0 0 k o h m ( B ) AE
Q701 VS2SC1815GR-1 Silicon, NPN, 2SC1815 GR AB
0702 VS2SC1815GR-1 S i l i c o n , NPN. 2SC1815 GR AB ELECTROLYTIC CAPACITORS
0703 VS2SC1815GR-1 Silicon, NPN, 2SC1815 GR A8 [All electrolytic capacitors are +20% type.)
Q704 VS2SC1815GR-1 Silicon, NPN, 2SC1815 GR AB
Q801 VS2SC1815GR-1 S i l i c o n . NPN. 2SC1815 GR AB Cl 2 RC-EZA476AFl A 4 7 /.LF, 1OV AB
Q802 VS2SC1815GR-1 Silicon. NPN, 2SC1815 GR AB Cl 5 RC-EZAI 06AFl C 1 0 pF, 1 6 V AB
c20 RC-EZA476AFl A 4 7 /LF, 1OV AB
DIODES C25 RC-EZA107AFl A 1 0 0 pF, 1OV AB
C26 RC-EZA475AFl E 4 . 7 ,u.F, 25V AB
Dl VHDl SSI 33//-l Silicon, 1 SS133 AA c40 RC-EZA106AFl C 1 0 pF, 1 6 V AB
03 VHDl SS133//-1 Silicon, 1 SS133 AA c41 RC-EZA335AFl E 3 . 3 /LF, 2 5 V AB
D4 VHDl SS133//-1 Silicon, 1 SS133 AA C42 RC-EZAI 05AFl H 1 P-F. 5 0 V AB
D5 VHDI SS133//-1 Silicon, 1 SSI 33 AA c44 RC-EZA475AFl E 4 . 7 pF, 2 5 V AB
D6 VHDl SS133//-1 Silicon, 1 SS133 AA c47 RC-EZA105AFl H 1 PF, 5 0 V AB
D7 VHDl SS133//-1 Silicon, 1 SS133 AA C48 RC-EZA105AFl H 1 PF, 5 0 V AB
DlO VHPGffiPR6061 F LEO, Red, GffiPR6061 F AC c49 RC-EZA227AFl A 2 2 0 pF, 1OV AB
DlOl VHPGL5PR6061 F LED, Red, GL5PR6061 F AC c74 RC-EZAI 06AFl C 1 0 pF, 1 6 V AB
D102 VHERDGR8JB2-1 Zener, 6.8V, RD6.8JB2 AB c75 RC-EZA476AFl A 4 7 pF, 1OV AB
D103 VHDl SS133//-1 Silicon, 1 SS133 AA Cl13 RC-EZA107AFl A 1 0 0 pF, IOV AB
D106 VHERDSRl JB2-1 Zener, 5.1 V, RD5.1 JB2 AA Cl14 RC-EZA107AFl A 1 0 0 ,uF, IOV AB
A D301 VHDS5566G//-1 Silicon, S5566G AB Cl 17 RC-EZA335AFl E 3 . 3 @F, 2 5 V AB
A D302 VHDS5566G//-1 Silicon, S5566G AB Cl 18 RC-EZA335AFl E 3 . 3 pF, 2 5 V AB
8 D303 VHDS5566G//-1 Silicon. S5566G AB Cl19 RC- EZA106AFl C 1 0 ~.LF, 1 6 V AB
8 0304 VHDS5566G//-1 Silicon, S5566G AB Cl20 RCGZA477AF0J 4 7 0 ~.LF, 6.3V AB
Cl 21 RC- EZA476AFl A 4 7 pF, 1OV AB
COILS Cl25 RC-EZAI 07AFl A 1 0 0 pF, IOV A8
Cl26 RC-EZAl06AFl C 1 0 /LF, 1 6 V A8
Ll RCiLA0652AFZZ FM Band Pass Filter AD Cl 34 RC-EZA476AFl C 4 7 PF. 1 6 V AB
I2 92LCdiLR-197A FM RF AA Cl 42 RC-EZA226AFl C 2 2 ,uF. 16V AG
L3 92LCijiL&158A FM Oscillator AA C207 RC-EZA105AFl H 1 pF, 5 0 V AB
LJ RCilAO796AFZZ AM Bar Antenna AH C2OB RC-EZA105AFl H 1 PF, 5 0 V AB
L8 92LCbiL&200A AM Oscillator AC c211 RC- EZA336AFl C 3 3 /LF, 1 6 V AB
c212 RC-EZA336AFl C 3 3 pF, 1 6 V AB
TRANSFORMERS C213 RC-EZA476AFl A 4 7 pF, 1OV AB
C214 RC-GZA337AFl C 3 3 0 pF, 1 6 V AC
Tl 92LiFT-258A FM IF AC C215 RC-EZA476AFl A 4 7 pF, 1OV AB
T2 92LiFT-1 97A FM Detector AC C216 RC-EZA476AFl A 4 7 pF, 1OV AB
T3 92LiFT-523A AM IF AC c219 RC-EZA227AFl A 2 2 0 pF, 1OV A8
bT301 92LPT-531 A Power AT c220 RC-EZA227AFl A 2 2 0 P-F, IOV AB
c221 RC-GZV228AFl C 2 2 0 0 pF, 1 6 V AE
FILTERS C223 RC-EZA224AFl H 0 . 2 2 P-F, 5 0 V AB
C224 RC- EZA224AFt H 0 . 2 2 ,I.LF, 50V AB
CFl RFiLFO080AFZZ Ceramic, FM IF 10.7 MHz AD C727 RC-EZAl05AFl H 1 /LF. 5 0 V AB
CF2 RFiLA0057AFZZ Ceramic, AM IF, 455 kHz AD C728 RCEZAl05AFl H 1 PF, 5 0 V AB

- 16-
REF.NO. PART NO. DESCRIPTION CODE REF.NO. PART NO. DESCRIPTION CODE
C729 RC-EZA476AFl C 4 7 pF, 1 6 V AB c701 VCTYMFl EX822K 0 . 0 0 8 2 pF, 2 5 V AA
c731 RC-EZAI 05AFl H 1 pF, 5 0 V AB C702 VCTYMFl EX822K 0 . 0 0 8 2 pF, 2 5 V AA
C732 RC-EZAl05AFl H 1 pF, 5 0 V AB c707 VCKYMFl HB102K 0.001 PF. 5 0 V AA
c733 FiGEZA335AFl E 3 . 3 ,uF. 2 5 V AB C708 V C K Y M F l HB102K 0.001 PF. 5 0 V AA
c734 RC-EZA335AFl E 3 . 3 /LF, 2 5 V AB c711 VCKYMFl H B 5 6 1 K 560 pF, 5 0 V AA
C801 RC-EZA475AFl E 4 . 7 PF. 25V A0 C712 V C K Y M F I HB561 K 560 pF, 5 0 V AA
c715 V C T Y M F l CY223M 0.022 pF, 16V AA
CAPACITORS C716 V C T Y M F l CY223M 0.022 pF, 16V AA
There are two types of capacitors available and they can be Identified from each C721 V C T Y M F I EX822K 0.0082 pF, 2 5 V AA
other by reading their Part Numbers. C722 V C T Y M F I EX822K 0.0082 FF. 2 5 V AA
l Ceramic type capacitor: C725,726 VCTYMFl HVl52K 0 . 0 0 1 5 pF, 5 0 V AA
Asymbol”C” or”K”IS givenat the3rd dlgitof its Part Number like”VCC(or
K).**.**.J.” RESISTORS
0 Semiconductor type capacitor; (Unless othenwse specified, resistors are f5%, carbon type.)
Asymbol”T’is gwen at the3rd digitof its PartNumberiike”VCTo..... (Tubular type carbon film resistor &5% is identified the symbol MF of the part
l J.” No. VRD-MFOOOOOOO: this MF does not mean lead wire.)
The capacitance error of each capacttor is Indicated by the symbol given at the
13th digit of the Part Number as follows:“~’(*5%). “K”(&lo%), “M”(&ZO%), VRPMF2EEOOOC 0 o h m , 1/4W, kO.25 o h m s , A A
“N” (f30%), “C” ( f 0 . 2 5 pF). “D” j&O.5 pF), “T’ (+80-20%). Jumper
(Tubular type ceramic-capacnor is Identitled by the symbol MF of the part No. Rl VRDST2CD681 J 680 ohms, 1/6W AA
VCOOMFOOOOOOO; this MF does not mean the lead wire.) R4 VRDMF2EE824J 820 kohms, l/4W AA
R5 VRDST2CD562J 5.6 kohms, 1/6W AA
Cl VCCSBTl H L18OJ 1 8 pF. 5 0 V AA R6 VRDMF2EE822J 8.2 kohms. 1/4W AA
c2 VCTYMFl HV472K 0 . 0 0 4 7 pF, 5 0 V AA R7 VRDMF2EE272J 2.7 kohms, 1/4W AA
c3 V C T Y M F I HV472K 0.0047 pF, 5 0 V AA R8 VRDST2CD680J 68 ohms, 1/6W AA
c4 VCCCMFl HH220J 2 2 pF(CH), 5 0 V AA R9 VRDST2CD471 J 470 ohms, 1/6W AA
C6 VCCRMFI HH220J 22 pF( R H ) , 5 0 V AA RIO VRDMF2EE152J 1.5 kohms, 1/4W AA
c7 VCCCPUl HH330J 3 3 pF(CH), 5 0 V AA Rl 1 VRDMF2EE471 J 470 ohms, 1/4W AA
C8 VCCCMFl HH3R9C 3 . 9 pF(CH), 5 0 V AA R41 VRDST2CD102J 1 kohm. 1/6W AA
c9 V C T Y M F l HV472K 0.0047 pF, 5 0 V AA R42 VRDMF2EE103J 10 kohm, 1/4W AA
Cl3 V C T Y M F l CY223N 0.022 pF, 1 6 V AA R43 VRDST2CD224J 220 kohms. 1/6W AA
Cl4 VCTYMFlCY223N 0.022 f*F, 16V AA R44 VRDMF2EE471 J 470 ohms, 1/4W AA
Cl 9 V C T Y M F I EXlO3N 0.01 pF, 2 5 V AA R45 VRDST2CD332J 3.3 kohms. 1/6W AA
c21 V C T Y M F I CY223N 0.022 pF, 1 6 V AA R46 VRDST2CD332J 3.3 kohms, 1/6W AA
c22 VCTYMFl CY223N 0.022 pF, 1 6 V AA R47 VRD-ST2CDl02J 1 kohm, 1/6W AA
C23 V C K Y M F l HB221 K 220 pF, 5 0 V AA R48 VRDMF2EElO2J 1 kohm, 1/4W AA
C24 VCTYMFl C Y 2 2 3 N 0.022 pF, 16V AA R49 VRDMF2EElOl J 100 ohm, 1/4W AA
C29 V C T Y M F l CY223N 0.022 pF, 16V AA R51 VRDST2CD471 J 470 ohms, 1/6W AA
c30 V C T Y M F I CY223N 0.022 ,uF. 1 6 V AA R63 VRDMF2EE470J 47 ohms, 1/4W AA
c43 VCQSMAl HLI 02J 0.001 ,u.F, 5OV. Styrol AB R65 VRD MF2EElOl J 100 ohm, 1/4W AA
c45 V C T Y M F l NY333N 0.033 pF, 1 2 V AA R105 VRPMF2EE182J 1.8 kohms, 1/4W AA
C46 V C T Y M F l NY333N 0.033 pF, 1 2 V AA R109 VRDST2CD822J 8.2 kohms, 1/6W AA
c73 V C T Y M F l CY223N 0.022 pF, 16V AA RllO VRDMF2EE822J 8.2 kohms. 1/4W AA
c77 VCCRMFI HH6R8D 6 . 8 pF(RH), 5 0 V AA Rll 1 VRDST2CDlOl J 100 ohm, 1/6W AA
Cl 03 VCCSMFl HLIOI J 100 pF, 5 0 V AA R112 VRDMF2EElOl J 100 ohm, 1/4W AA
Cl04 VCCSMFI HLl 01 J 1 0 0 pF, 5 0 V AA RI 13 VRDMF2EE222J 2.2 kohms, 1/4W AA
Cl 05 VCKYMFl HB102K 0 . 0 0 1 pF, 5 0 V AA R114 VRDST2CD222J 2.2 kohms, 1/6W AA
Cl 06 V C K Y M F l HB102K 0.001 pF, 5 0 V AA R117 VRDMF2EE123J 12 kohms, 1/4W AA
Cl 07 V C T Y M F l HV152K 0.0015 pF, 5 0 V AA R118 VRDMF2EE123J 12 kohms, 1/4W AA
Cl 08 VCTYMFl HVI 5 2 K 0 . 0 0 1 5 pF, 5 0 V AA R125 VRD-ST2CD15OJ 15 ohms, 1/6W AA
Cl 11 VCTYPAl EX683K 0.068 /LF, 2 5 V AA Rl26 VRDST2CD15OJ 15 ohms, 1/6W AA
Cl 12 VCTYPAl EX683K 0.068 ,oF, 2 5 V AA R127 VRDST2CDl82J 1.8 kohms. 1/6W AA
Cl 22 V C T Y M F I EX103N 0.01 ,tcF, 2 5 V AA R128 VRD- MF2EE182J 1.8 kohms, 1/4W AA
Cl 24 VCTYMFlCY223N 0.022 pF, 1 6 V AA RI 29 VRDST2CD473J 47 kohms, 1/6W AA
Cl 29 V C K Y M F I H B 8 2 1 K 820 pF, 5 0 V AA R130 VRDMF2EE473J 47 kohms, 1/4W AA
Cl 30 VCKYMFl H B 8 2 1 K 820 pF, 5 0 V AA R134 VRDMF2EE122J 1.2 kohms, 1/4W AA
Cl 31 VCCSMFl HL470J 4 7 pF, 5 0 V AA R135 VRDMF2EE222J 2.2 kohms, 1/4W AA
Cl 32 VCCSMFl HL470J 4 7 pF, 5 0 V AA RI 43 VRDMF2EE473J 47 kohms, 1/4W AA
Cl 37 V C T Y M F l CY223N 0.022 PF. 1 6 V AA RI44 VRDMF2EE473J 47 kohms. 1/4W AA
Cl38 VCTYATl CY223N 0.022 PF. 16V AA RI47 VRDST2CD125J 1.2 Mohms, 1/6W AA
Cl 41 VCNBTl CY103N 0 . 0 1 pF, 1 6 V AA R149 VRDMF2EE333J 33 kohms, 1/4W AA
C209 V C K Y M F I HBl02K 0.001 ELF, 5 0 V AA RI 50 VRDMF2EE102J 1 kohm. 1/4W AA
c210 V C K Y M F l HB102K 0.001 PF. 5 0 V AA R153 VRDMF2EE393J 39 kohms, 1/4W AA
c217 VCTYPAl EX104K 0 . 1 pF, 2 5 V AB R154 VRDMF2EE393J 39 kohms, 1/4W AA
C218 VCTYPAl EXI 04K 0 . 1 FF, 2 5 V AB R201 VRD-MFZEEI 82J 1.8 kohms, 1/4W AA
c222 VCTYPAI EXI 52K 0 . 0 0 1 5 pF, 25V AA R202 VRDMF2EE182J 1.8 kohms, 114W AA
c301 VCKZPAl HF103Z 0 . 0 1 pF, 5 0 V AA R203 VRD- MF2EE332J 3.3 kohms, 1/4W AA
C302 VCKZPAI HF103Z 0 . 0 1 pF, 5 0 V AA R204 VRDMF2EE332J 3.3 kohms, 1/4W AA
c303 VCKZPAl HFl03Z 0 . 0 1 pF, 5 0 V AA R207 VRD-MF2EE221 J 220 ohms, 1/4W AA
c304 VCKZPAl HF103Z 0 . 0 1 ,uF, 5 0 V AA R208 VRDMF2EE221 J 220 ohms, 1/4W AA

- IiI-
REF.NO. PART NO. DESCRIPTION CODE REF.NO. PART NO. DESCRIPTION CODE

I3209 VRDST2CD2R2J 2.2 ohms, 1 J6W AA 10 94R18210168 Lever, Rewind AC


R210 VRDST2CD2R2J 2.2 ohms, 1/6W AA 11 94R18210115 Lever, Pause AC
R211 VRDMF2EE151 J 150 ohms, 1/4W AA 12 94R18210116 Spring, Pause Lever AB
R212 VRDMF2EE151 J 150 ohms, 1/4W AA 13 94Rl8210134 Stopper, Pause AA
R213 VRDMF2EE332J 3.3 kohms, 1/4W AA 14 94Rl8210123 Spring, Button Lever AB
R214 VRDMF2EE332J 3.3 kohms, 1/4W AA 15 94Rl8210119 Sub-Chassis AD
R601 VRDSTZCD473J 47 kohms, 1/6W AA 16 94R18210124 Spring. Button Lever AB
R602 VRDST2CD473J 47 kohms, 1/6W AA 17 94R18210150 Spring, Play Button Lever AB
R701 VRDMF2EE473J 47 kohms, 1/4W AA 18 94R18210138 Spring, Switch Actuator AC
R702 VRDMF2EE473J 4 7 k o h m s , 1/4W AA 19 94R18210122 Spring, Actuator AB
R703 VRDMF2EE473J 4 7 k o h m s , 1/4W AA 20 94R18210162 Lever, Auto AC
R704 VRDMF2EE473J 47 kohms, 1/4W AA 21 94R18210121 Sprtng, Auto Lever AB
R707 VRDMF2EE272J 2 . 7 k o h m s , 1/4W AA 22 94Rl8210113 Spring, Button Lever AB
R708 VRDMF2EE272.l 2 . 7 k o h m s , 1/4W AA 24 94Rt 8290110 PR Stopper AC
R715 VRDMF2EE223J 22 kohms, 1/4W AA 25 94Rl8210306 Spring, MG Arm AB
R716 VRDMF2EE223J 2 2 k o h m s , 1/4W AA 26 94R18210310 Head Panel AD
R717 VRDMF2EE223J 22 kohms, 1/4W AA 27 94R18210302 Head Base AC
R718 VRDMF2EE223J 2 2 k o h m s , 1/4W AA 28 94R182903301 Sensing Plate Ass’y AD
R719 VRDMF2EE153J 15 kohms, 1/4W AA 30 94R18210312 Spring, Head Panel AB
R720 VRDMF2EEl53J 15 kohms, 1/4W AA 31 94R18210305 MG Arm AC
R727 VRDMF2EE123J 12 kohms, 1/4W AA 33 94R18211305 Screw, P.M. E. AA
R728 VRDMF2EEl23J 1 2 k o h m s , 1/4W AA 34 94R18210307 Spring, Azrmuth AB
R729 VRDMF2EEl23J 12 kohms, 1/4W AA 35 94R182104301 Pinch Roller Arm Ass’y AG
R730 VRDMF2EEl23J 12 kohms, 1/4W AA 36 94R18210408 Spring, Pinch Roller AS
R731 VRDMF2EE271 J 270 ohms, 1/4W AA 37 94Rl8213912 MS Screw AC
R732 VRDMF2EE271 J 270 ohms, 1/4W AA 39 94R182107302 RF Pulley Arm Ass’y AH
R733 VRDST2CD392J 3.9 kohms, 1/6W AA 40 94R18210704 Spring, RF Pulley Arm AB
R734 VRDST2CD392J 3.9 kohms, 1/6W AA 4! 94R18670405 Caller, Arm AB
R735 VRDMF2EE684J 6 8 0 k o h m s , 1/4W AA 42 94Rl8210703 RF Belt AG
R736 VRDMF2EE684J 680 kohms, 1/4W AA 44 94R182109301 Flywheel Ass’y AK
R737 VRDMF2EEl22J 1.2 kohms, 1/4W AA 45 94R182910501 A Reel Base Ass’y AG
R738 VRDMF2EE122J 1.2 kohms, 1/4W AA 46 94R182110503 Take-Up Gear Plate Ass’y AD
R739 VRDST2CD221 J 220 ohms, 1/6W AA 47 94Rl8670310 Gear, Take-Up Roller AB
R741 VRDMF2EE824J 820 kohms, 1/4W AA 48 94R18211008 Plate Spring, T.G. AB
R742 VRDMF2EE824J 820 kohms, 114W AA 49 94R18670309 Gear, Fast Forward AB
R745 VRDMF2EE561 J 560 ohms, 1/4W AA 50 94R18211012 Spring, Back Tension AB
R746 VRDMF2EE561 J 560 ohms, 1/4W AA 51 94R182110301 Supply Reel Ass’y AF
R801 VRDST2CD472J 4.7 kohms, 1/6W AA 52 94 RI 82910302 Take-Up Reel Ass’y AF
R802 VRDST2CD472J 4.7 kohms, 1/6W AA 53 94 RI 8000201 Lever, Record Safety AC
54 94R18000517 Spring, Back Tension AB
CIRCUIT PARTS 55 94R18211212 Bracket, Motor AE
56 94Rl8201306 Rubber, Motor AA
CNSlOl QCNWN0005AFZZ Connector Assembly, 3Pin AD 57 94R18211202 Screw, Motor Caller AA
CNS102 QCNWN0006AFZZ Connector Assembly, 3Pin AC 59 94 RI 7200905 Belt, Main AG
CNPlOl QCNCMI 36CAFZZ Plug, 3 Pin AB 62 94R18211304 Lever, Eject Slide AC
CNP102 QCNCMl36CAFZZ P l u g , 3Pin AB 63 94R18211311 Spring, Eject Slide Lever A8
Jl 01 QJAKEO157AFZZ Jack External Microphone A8 64 94R18291001 Plate Spring, Pack AC
JlO7 QJAKJOl64AFZZ J a c k H e a d p h o n e s AE 66 RHEDHO152AFZZ Head, Record/PIayback AM
JlO9 QTANZOBOBAFZZ Terminal, External Speaker AE 67 RHEDZ0060AFZZ Head, Erase AG
Ml RM5TV0235AFOl Motor, Assembly AT 70 94R90760000 T a m s S c r e w , @2 X 3mm AA
8 so301 QSdCE0596AFZZ Socket, AC/DC Power AH 71 94 R91800000 T a p p i n g S c r e w , 42 X 4mm AA
Supply (with AC/DC 73 94R96790000 Tapping Bind Screw, $2 X AA
Selector Switch) 5mm
SPl.2 92LSP-523A Speaker, Woofer AM 74 94R97650000 S c r e w , Q1.7 X 4mm AA
SP3.4 RALMB0057AFZZ Speaker, Ceramic Tweeter AC 75 94 R90040000 S c r e w , @2 X 6mm AA
SW1 01 QSW-BO212AFZZ Switch, Slide Type AH 77 94R98200000 S c r e w , (p2 X 7mm AA
SW1 02 QSW-SO512AFZZ S w i t c h , Slide T y p e AF 78 94R99220000 Screw, Azimuth AA
SW401 94RMSW-1541 ACV Switch, Leaf Type AD 82 94 R94210000 W a s h e r , $1.2 X $13 X AA
0.25mm
MECHANICAL PARTS 83 94R98880000 W a s h e r , $1.2 X @3 X AA
0.4mm
1 94R18210160 Main Chassis - 84 94R98750000 W a s h e r , $1.55 X G3.8 X AA
2 94R18210167 Switch Plate AC 0.5mm
3 94R182107 501 Push Button Actuator Ass’y AD 85 94R99370000 W a s h e r , gj2.05 X 94 X AA
4 94R18210128A Lever, Record Button AC 0.4mm
5 94R18210129 Lever, Play Button AC 87 94R18213107 Lever, Operation AC
6 94R18210130 Lever, Rewind Button AC 88 94R18213106’ Frame AF
7 94R18210131 Lever, Fast Forward Button AC 89 94R18293103 Shaft, Button Lever AD
8 94R18210132 Lever, Stop Button AC 90 94R99820000 S c r e w , $2 X 7mm AA
9 94R182101503 Lever Ass’y, Pause Button AD 96 94R91810000 S c r e w , $2 X 5mm AA

- 18 -
REF.NO. PART NO. DESCRIPTION CODE REF.NO. PART NO. DESCRIPTION CODE
101 LANGTl397AFZZ Bracket, Button Lever Shaft AB 210 92LHNDL571 A-RD H a n d l e , (R) AE
102 92LMANG523A Bracket, Record AB 210 92LHNDl572A-PK Handle, (P) AE
103 LHLDWI 075AFZZ N y l o n B a n d AA 210 92LHNDL573A-YW Handle, (Y) AE
210 92LHNDL574A-BL Handle, (BL) AE
CABI NET PARTS 211 JKNBKO303AFSA Knob, Band Selector AB
212 92LKN5B523B Knob, Volume AB
201 CSPRTI 206AFO2 Dial Cord Assembly AD 213 92LKN5B523C Knob, Balance AA
202 92LCAB523FFiTOl Front Cabinet Assembly. (BK) AV 214 92LM-BUT5N523A Button, Mechanism Operation AB
202 92LCAB571 FRTOI Front Cabinet Assembly, (R) AV 215 92LKNoB523A Knob, Tuning AE
202 92LCAB572FRTOl Front Cabrnet A s s e m b l y , ( P ) A V 216 92LKN5B523E Knob, Graphic Equalizer Al3
202 92LCAB573FRTOl F r o n t C a b i n e t Assemblv, in A V 217 92LSUPT523B Bracket, Mechanism AB
202 92LCAB574FRTOl Front Cabinet Assembly, (BL) AV Retaining
202-l Front Cabinet, (BK) - 218 MLiFm034AFZZ Damper AC
202-l Front Cabinet, (R) - 219 MSPRC0559AFFJ Spring, Batten/ (+) AB
202-I Front Cabinet, (P) - 220 92LBSPR523A Spring, Batten/ (i-,-i AA
202-I Front Cabinet, (Y) - 221 92LBSPR523B Spring, Battery (-) AA
202-I Front Cabinet, (BL) - 222 92LCSPR523A Spring, Cassette Holder Up AA
202-2 92LPANEL523A Operation Plate AK 223 92LCSPR523B Spring, Record/Playback AB
202-3 HDECAOGI SAFSA Decoration Plate, Graphic AG Selctor
Equalizer, (BK) 224 92LWHEL523B Drum AE
202-3 HDECAOGI SAFSE Decoration Plate, Graphic AG 226 PFLT-0132AFDO Felt, Cabinet 50mm AA
Equairzer, (R) 227 PFLT-0668AFZZ Felt, Cabinet 70mm AA
202-3 HDECAOGI SAFSB Decoration Plate, Graphic AG 228 QANTROI 11 AFZZ FM Telescopic Rod Antenna AM
Equalizer, (P) 229 92LC5NE-523E Speaker Cord AC
202-3 HDECAOGI SAFSD Decoration Plate, Graphic AG 230 QLUGPDll 1 CEFW Lug Terminal, 13mm AA
Equalizer, (Y) 231 QTANZOI 92AFZZ Terminal, Antenna AA
202-3 HDECAOGI SAFSC Decoration Plate, Graphic AG 232 RC5RF0053AFZZ C o r e AB
Equalizer, (BL) 233 PCUSUOl28AFZZ C u s h i o n , F M RF/Osc. C o i l AA
202-4 92LPANEL523B Operation Plate, Mechanism AC 234 92LTiP-523A Tip, with Lead Wire AB
202-5 HPNLHl 1 OSAFSA Transparent Plate AC 238 92LSPEC531 A Label, Specifications, (BK) AB
203 92LSCAB523A-BK Speaker Front Cabinet, (BK) AM 238 92LSPEC571 A Label, Specifications, (R) AB
203 92LSCAB571 A-RD Speaker Front Cabinet (R) AM 238 92LSPEC572A Label, Specifications, (P) AB
203 92LSCAB572A-PK Speaker Front Cabinet (P) AM 238 92LSPEC573A Label, Specifications, (Y) AB
203 92LSCAB573A-YW Speaker Front Cabinet, (Y) AM 238 92LSPEC574A Label, Specifications, (BL) AB
203 92LSCAB574A-BL Speaker Front Cabinet. (BL) AM 601 LX-BZ0308AFFD Screw with Washer AA
204 92LSCAB523BLBK Speaker Back Cabinet, Left, AM 602 LX-CZOO17AFFD S c r e w , +3 X 2 5 m m AA
(BK) 603 XBPSD26PO6JOO S c r e w , $2.6 X 6mm AA
204 92LSCAB571 BLRD Speaker Back Cabinet, Left, AM 604 XCBSD30Pl DDOO S c r e w , $3 X 1Omm AA
(RI 605 XCBSD30P12000 S c r e w , $3 X 12mm AA
204 92LSCAB572BLPK Speaker Back Cabinet, Left, (P) AM 606 XHBSD30PO8000 S c r e w , $3 X 8mm AA
204 92LSCAB573BLYW Speaker Back Cabinet, Left, AM
(V ACCESSORIES/PACKING PARTS
92LSCAB574BLBL Speaker Back Cabinet, Left, AM
(W PSHEK0095AFZZ Sheet, Cassette AB
205 92LSCAB523BRBK Speaker Back Cabinet, Right, AM 92LC5DE004B AC Power Supply Cord AL
(W 92LLABL523A Label, Special Feature, AC
205 92LSCAB571 BRRD Speaker Back Cabinet, Right, AM Cassette Holder
( RI 92LiNST531 A Operation Manual AC
205 92LSCAB572BRPK Speaker Back Cabinet, Right, AM 92LG-CARD004B Warranty Card AA
( P) 92LP-CASE531 A Packing Case, (BK) AN
92LSCAB573BRYW Speaker Back Cabinet, Right, AM 92LP-CASE571 A Paking Case, (R) AN
(v) 92LP-CASE572A Paking Case, (P) AN
205 92LSCAB574BRBL Speaker Back Cabinet, Right, AM 92LP-CASE573A Paking Case, (Y) AN
(84 92LP-CASE574A Paking Case, (BL) AN
206 92LCAB531 B-BK Back Cabinet, (BK) AQ 92LCAUT531 A Label, Caution, (BK), (R), (BL) AC
206 92LCAB571 B- RD Back Cabinet, (R) AQ 92LCAUT531 B Label, Caution, (P), (Y) AC
206 92LCAB572B- PK Back Cabinet, (P) AQ 92LP-AD523A Packing, Add., Unit AF
206 92LCAB573B-YW Back Cabinet, (Y) AQ 92LBAG329B Polyethylene Bag, Operation AA
206 92LCAB574B-BL Back Cabinet, (BL) AQ Manual
207 92LCT-H6LD523A Cassette Holder Assembly AH 92LBAG523A Polyethylene Bag, Unit AB
Cassette Holder - 92LBAG523B Polyethylene Bag, Speaker AB
izz-- 92LPANEL523D Operation Plate, Cassette AC 92LP-AD523B Paking Add., Speaker AE
Holder
208 92LLiD523A-BK Battery Compartment Lid, (BK) AD P.W.B ASSEMBLY(Not Replacement Item)
208 92LLiD571 A-RD Battery Compartment Lid. (R) AD
208 92LLiD572A-PK Battery Compartment Lid, (P) AD PWB-Al/A2 92LPWB531 MAN01 Main/Power Supply PWB -
208 92LLiD573A-YW Battery Compartment Lid, (Y) AD (Combined
208 92LLiD574A-BL Battery Compartment Lid, (BL) AD Assembly)
209 92LPiNT523A Dial Pointer AB PWB- B 92LPWB523GEQSl Graphic Equalizer PWB -
210 92LHNDL523A-BK Handle, (BK) AE

-19-
SHARP

A8603-749NS’IS*M

Writer and Editor: Quality & Reliability Control Center of Audio Systems Group, Sharp Corp. Printed in Japan

Вам также может понравиться