Академический Документы
Профессиональный Документы
Культура Документы
Fig. 1 Fig. 2
Fig. 3
KH 6900
Safety instructions 4
Package contents 4
Intended use 5
Technical data 5
Startup 5
Operation 6
Setting the time 6
Recording voice messages 6
Using the automatic pet feeder 7
Inserting a portion-sized dish into the automatic pet feeder 7
Programming feeding times 8
Programming fewer than four feedings 8
Starting the automatic pet feeder timer immediately 8
Starting the automatic pet feeder timer for tomorrow 9
Replacing the batteries of the automatic pet feeder 9
Cleaning 9
Disposal 10
Read the operating instructions carefully before using the appliance for the first
time and preserve this booklet for later reference. Hand over the manual to anyone
you pass on the appliance to.
-3-
KH 6900
-4-
KH 6900
-5-
KH 6900
and
-6-
KH 6900
Using the automatic pet feeder The pins on the bottom side of the
cover must fit into the holes on the
➩ Loosen the lid on the top side of inner edge of the casing .
the automatic pet feeder. Do not ➩ Now place the lid back on the
apply force when doing so, other- automatic pet feeder. The pins on
wise it may be damaged. Then the bottom side of the lid must fit
remove the lid from the automatic into the holes on the outer edge of
pet feeder. the casing . Press carefully on the
➩ Remove the cover with water dish lid until it rests firmly.
from the automatic pet feeder. Do not apply force when doing so,
➩ Now fill the food chambers with wet otherwise it may be damaged.
or dry food. You can add food for up
to four feedings. If you would also like to provide water
in addition to food, leave the lid off
Note: At the programmed feeding times, the automatic pet feeder. Add water to
the food chambers open in the order of the insert in the cover .
the numbering. You also have the option of inserting
typical wet food portion-sized dishes in-
If you would like to … to one of the food chambers. To do this,
• program only a single feeding: Add use rectangular wet food portion-sized
the food to chamber 1. dishes (e.g. Lidl Coshida) and the adap-
• program only two feedings: Add food ter for wet food portion-sized dishes .
to chambers 1 and 2.
• program only three feedings: Add Inserting a portion-sized dish into the
food to chambers 1 to 3. automatic pet feeder:
➩ Slide the cover flap for the food ➩ Remove the lid of the portion-sized
chambers back to its original dish.
position. ➩ Slide the portion-sized dish into the
➩ Place the cover with water dish adapter for wet food portion-sized
back on the automatic pet feeder. dishes as shown in Fig. 1 and 2.
➩ Insert the adapter including
portion-sized dish into food
chamber 1 (see Fig. 3).
-7-
KH 6900
1. Make certain that … First set the time(s) for the desired
• the main switch on the bottom side feedings. Then confirm the indicated
of the automatic pet feeder is set to times for the additional feedings by
ON and pressing the SET button .
• the time has been set correctly – as
described under "Setting the time". ➩ To subsequently change one or more
of the programmed times: Follow
2. To program the first feeding: Press steps 2 to 5 in this section again.
the MODE button
once.
The following appears in the display : Starting the automatic pet feeder timer
• 1 for the first feeding to be pro- immediately:
grammed
• The time currently set for the first Press the START NOW button once. If
feeding to be programmed you have recorded a voice message, this
will be played once. The bowl with the
3. Hold down the SET button until food chambers now turns to the start
the indicated time begins to blink. position. The bell symbol is shown in the
4. Press the MODE button
until the display .
hour indicator shows the desired
time. Please note that you can only
program feedings on the hour
(e.g. 8 o'clock, 9 o'clock, 10 o'clock, etc.).
5. To confirm the set time, press the SET
button once. The display will
then show:
• 2 for the second feeding to be pro-
grammed
• The time currently set for the sec-
ond feeding to be programmed
-8-
KH 6900
Starting the automatic pet feeder timer ➩ Loosen the lid on the top side of
for tomorrow: the automatic pet feeder. Do not apply
force when doing so, otherwise it
Instead of pressing the START NOW but- may be damaged. Then remove the
ton , press the START TOM button . lid from the automatic pet feeder.
If you have recorded a voice message, ➩ Remove the cover with water dish
this will be played once. The bowl with from the automatic pet feeder.
the food chambers now turns to the ➩ Remove the cover flap for the food
start position. The bell symbol and Zz chambers .
are now shown in the display . ➩ Lastly, remove the bowl with the
four food chambers from the
Replacing the batteries of the automatic casing .
pet feeder ➩ To clean the casing, use only a damp
cloth and a mild cleanser. Then
If the battery status display LO BATT carefully dry the casing.
lights up, the inserted batteries are low
on charge. Always replace all four Danger! Never hold the casing under
batteries with new type C/baby/1.5 V flowing water or immerse it in water!
batteries. To do this, follow steps 2 to 5 Otherwise the automatic pet feeder may
in the section "Operation". be irreparably damaged. There is also
the risk of an electric shock!
Note: Do not dispose of batteries in house-
hold waste! Drop off used batteries at a ➩ The lid , cover , cover flap and
collection or disposal site. Used bowl can all be cleaned with hot
batteries can also be returned to the water and cleanser. Be sure to rinse
shop where they were purchased. the parts thoroughly to remove any
cleaning product residue.
➩ Dry the lid , cover , cover flap
Cleaning and bowl carefully. Then place
them back into the casing in their
Clean the automatic pet feeder and its original positions.
components regularly. For daily use, we ➩ Set the main switch on the
recommend a cleaning at least once per bottom side of the automatic pet
week. feeder back to ON.
For cleaning:
➩ Set the main switch on the
bottom side of the automatic pet
feeder to OFF.
-9-
KH 6900
Disposal
Kompernaß GmbH
Burgstrasse 21
D-44867 Bochum
www.kompernass.com
- 10 -