Академический Документы
Профессиональный Документы
Культура Документы
Simulator
itexamanswers.net/dhcp-sim-troubleshooting-ccna-200-125-labs-simulator.html
August 14,
2018
You can download this lab and practice with Packet Tracer:
Download
This content is locked!
Please support us, use one of the buttons below to unlock the content.
like
tweet
share
follow us
error
or wait 398s
1. Refer to the topology below and answer the questions.
1/8
Examine the DHCP configuration between R2 and R3, R2 is configured as the DHCP
server and R3 as the client. What is the reason R3 is not receiving the IP address via
DHCP?
Explanation/Reference:
First we should check which interface on R3 that is connected to R2 via the show run
command.
2/8
Therefore we can conclude this interface does not have any IP address and there is no
configuration on this interface (except the “description Link to R2” line).
3/8
R2 router Ethernet interface that is connected to R1 is placed in shutdown
condition.
The NTP server command not configured on R2 router.
The IP address that is used in the NTP configuration on R2 router is
incorrect.*
Explanation/Reference:
First we should verify if the ports connected between R1 and R2 is in “up/up” state with
the show ip interface brief command on R1 & R2.
Note: We learn R1 & R2 connect to each other via E1/0 interface because the IP
addresses of these interfaces belong to 192.168.10.0/30 subnet. Both of them are
“up/up” so the link connecting between R1 & R2 is good.
Next we need to verify the ntp configuration on R2 with the show running-config
command.
4/8
Why applications that are installed on PC’s in R2 LAN network 10.100.20.0/24 are
unable to communicate with Server1?
Explanation/Reference:
The ping worked well so maybe R1 is good so we should check R2 first. We notice on R2
there is an access-list:
5/8
This access-list is applied to E0/2 interface with inbound direction. The purpose of this
access-list is to block traffic with source IP address of 172.16.200.0/24 so it will block all
traffic sent from Server 1 to us.
6/8
Users complain that they are unable to reach internet sites. You are
troubleshooting internet connectivity problem at main office. Which statement
correctly identifies the problem on Router R1?
Explanation/Reference:
If all users cannot access internet then R1 is most likely to cause the problem so we
should check it first. From the show running-config command we will see:
We notice that interface E0/0 (connected to ISP) has been configured as nat inside while
interfaces E0/1 & E1/0 (connected to our company) have been configured as nat outside .
This is not correct because nat inside should be configured with interfaces connected to
our company while nat outside should be configured with interfaces connected to the
internet. Therefore we can conclude the NAT configuration on these interfaces is not
correct.
7/8
8/8