Академический Документы
Профессиональный Документы
Культура Документы
Bookmarks X
*This document is best viewed at a
Options
screen resolution of 1024 X 768.
Features
Cover Page
To set your screen resolution do the following:
Tables RIGHT CLICK on the DESKTOP.
Component Select PROPERTIES.
Connector
CLICK the SETTINGS TAB.
Schematic
Machine Views
MOVE THE SLIDER under SCREEN RESOLUTION
Chassis View until it shows 1024 X 768.
Cab View CLICK OK to apply the resolution.
Engine View
*Due to different monitor sizes and PDF reader preferences
The Bookmarks panel will allow you to there may be some variance in linked schematic locations
quickly navigate to points of interest.
EC-C1
When only one callout is showing on a
machine view, clicking on this button will
Click on any text that is BLUE and make all of the callouts visible. This
underlined. These are hyperlinks button is located in the top right corner
that can be used to navigate the of every machine view page.
schematic and machine views.
FUNCTION KEYS
Switch Switch Switch Switch Circuit Breaker
or Motor Variability
CHECK
Control
ACCUMULATORS Unidirectional Bidirectional
Valves
Line Restriction
(Variable)
VARIABLE DISPLACEMENT
Basic Spring Shuttle NON- COMPENSATED
Pilot
Symbol Loaded Line Restriction
Controlled Spring Loaded Gas Charged Restriction
(Fixed)
Unidirectional Bidirectional
MAIN AUX.
Line Restriction
PILOT CONTROL 2-Section
RELEASED PRESSURE ROTATING SHAFTS Variable and Pressure
Compensated
Pump
Unidirectional Bidirectional
External Return Internal Return
Attachment Pump: Variable and
REMOTE SUPPLY PRESSURE Pressure Compensated
COMBINATION CONTROLS
LINES MEASUREMENT
Solenoid Solenoid Solenoid Solenoid and Servo Thermal Detent Crossing Joining
or Manual and Pilot Pilot or Manual Pressure Temperature Flow
Push-pull Lever Manual Shutoff General Manual Push Button Pedal Spring Vented Pressurized Return Above Fluid Level Return Below Fluid Level
Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the contacts of Harness Connector Serialization Code: The "C" stands for
"Connector" and the number indicates which connector in the
a normally open reed switch; it opens the contacts of a normally closed reed switch.
harness (C1, C2, C3, ...)
L-C12
Sender: A component that is used with a temperature or pressure gauge. 3E-5179
The sender measures the temperature or pressure.
T Its resistance changes to give an indication to the gauge of the temperature or pressure. 5A
Component
Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity. Fuse (5 Amps) 9X-1123 Part Number
It has a coil that makes an electromagnet when current flows through it.
The electromagnet can open or close the switch part of the relay. 325-AG135 PK-14
Harness identification code:
This example indicates wire group 325, Wire Gauge
Solenoid: A solenoid is an electrical component that is activated by electricity. wire 135 in harness "AG". Wire Color
It has a coil that makes an electromagnet when current flows through it.
The electromagnet can open or close a valve or move a piece of metal that can do work. 1 Deutsch connector: Typical representation
of a Deutsch connector. The plug contains all
2 sockets and the receptacle contains all pins.
Magnetic Latch Solenoid: An electrical component that is activated by electricity and held latched by a
permanent magnet. It has two coils (latch and unlatch) that make electromagnet 1 Sure-Seal connector: Typical representation
when current flows through them. It also has an internal switch that places of a Sure-Seal connector. The plug and receptacle
2 contain both pins and sockets.
the latch coil circuit open at the time the coil latches.
UENR3202
November 2013
Tap Locations
Pressure, Sampling, and Sensor
Tap Schematic
Description
Number Location
AA Front Axle Cross-Axle Differential Pressure B-2
BB Center and Rear Axle Cross-Axle Differential Pressure B-1
CC ATAAC Fan Pressure E-1
TP1 Fan, Brake, and Hoist Pump Pressure D-6
TP2 Steering Pump Pressure D-6
TPBR Brake Accumulator Charge Pressure E-7
TPDL Cross-Axle Differential Pressure E-5
TPF Fan Drive Pressure E-7
TPHP Hoist Pilot Pressure F-6
TPST Steering Pressure D-6
8 7 6 5 4 3 2 1
(10) BRAKE GP
PARKING
160-8009 (17) CYLINDER GP
SUSPENSION (RH)
341-4122 (12) CYLINDER GP
(43) VALVE GP (33) SENSOR GP HOIST (LH)
MAIN CONTROL PRESSURE (PARKING BRAKE WARNING) 285-4031
437-1480 344-7391 (7) BRAKE GP
HYDRAULIC CALIPER (RH CENTER AXLE)
347-9761 (9) BRAKE GP
F (2) ACCUMULATOR GP RAISE HYDRAULIC CALIPER (RH REAR AXLE) F
BRAKE (PARKING) (MAIN CONTROL VALVE) FB RB PB S1 347-9761
163-5632
RAISE
LOWER
(32) SENSOR GP
PRESSURE (BRAKE OIL) (S3) (42) VALVE GP
TPBR HOIST CONTROL (4) BRAKE GP (6) BRAKE GP
344-7391 HYDRAULIC CALIPER (LH CENTER AXLE) HYDRAULIC CALIPER (LH REAR AXLE)
TPDL 281-3307
347-9761 347-9761
DL
LOC C-2
T
P
H
(8) BRAKE GP
TPF T
CC
LS
(19) MOTOR GP
ATAAC
395-0530
(44) VALVE GP
(14) CYLINDER GP SOLENOID (ATAAC CONTROL)
LSH STEERING (LH) 211-2092
349-8518
TPH
T LEFT
TURN
(20) MOTOR GP
RIGHT MAIN HYDRAULIC FAN
TURN 293-6517
R
(24) PUMP GP
ATAAC
LSST LS (37) VALVE AS 371-9334
CONTROL (HYDRAULIC OIL) PRIME
360-5604 F
LOC E-7
TRANSMISSION
(23) PLUG
ORIFICE
166-4057
ST
LEFT
D D
TURN
TPST P
(5) BRAKE GP L
HYDRAULIC CALIPER (LH FRONT AXLE) RIGHT
347-9761 TURN (21) OIL COOLER
366-8881
(38) VALVE GP
LS1 P1 LS2 P2 SW1 P3 LS3
BRAKE PEDAL (27) PUMP GP
373-4532 SECONDARY STEERING (15) CYLINDER GP
369-7919 STEERING (RH) TRACTOR TRAILER
TP1 349-8517
TP2 HITCH
(34) SENSOR GP
(25) PUMP GP PRESSURE (STEERING) (26) PUMP GP
(28) PUMP GP
FAN, BRAKE, AND HOIST 313-5104 METERING (HMU)
STEERING
240-2647 240-2647 223-7718
B B
P1
B1
(Dimensions: 39 inches x 28 inches)
T1
(39) VALVE GP
1 2
CHECK (HYDRAULIC OIL COOLER BYPASS)
145-8983
3 4
B2
P2 M DL
LOC E-6
1
UENR3202
C T2
L1 L1 C
2
S S (35) SWITCH GP (41) VALVE GP P T P T (40) VALVE GP
PRESSURE (HYDRAULIC TANK RETURN BYPASS) 3 CROSS-AXLE DIFFERENTIAL CONTROL CROSS-AXLE DIFFERENTIAL CONTROL
(11) BREATHER (CENTER AND REAR AXLE)
HYDRAULIC TANK 253-2673 (FRONT AXLE) 432-1661
356-7423 4 432-1661
TP C TP C
(36) TANK GP
HYDRAULIC
381-3512
AA BB
(16) CYLINDER GP
SUSPENSION (LH)
341-4122
8 7 6 5 4 3 2 1
STEERING COMPONENTS
VIEW ALL CALLOUTS
26 23
REAR FRAME COMPONENTS
VIEW ALL CALLOUTS
BB
40
7
10
9
4
6
MAIN CONTROL VALVE
VIEW ALL CALLOUTS
D 43 FRONT OF MACHINE
FRONT OF MACHINE
43
33 TP1 TPBR
32
34
31
TPDL
TPF TPST
TP2
TPHP
35
39
11
18
30
22
36
29 3
FRONT FRAME COMPONENTS
VIEW ALL CALLOUTS
38
A
AA
42
5
41
VIEW OF AREA “A”
(ROTATED FOR CLARITY)
CYLINDERS
VIEW ALL CALLOUTS
14 16
12
17
15
13
BELOW CAB COMPONENTS
VIEW ALL CALLOUTS
24 20
25
28
B
C
27
2 37
21
VIEW OF AREA “C”
(ROTATED FOR CLARITY)
ATAAC FAN
VIEW ALL CALLOUTS
CC
PRIME
19 44