Академический Документы
Профессиональный Документы
Культура Документы
Specific Weight
at 20 °C 1.0
The above given values are product describing data. Please consult the ‘delivery specification’ for binding product
specifications. Further data about product properties, toxicological, ecological data as well as data relevant to safety can be
found in the safety data sheet.
Properties
TUBIGUARD® 30-F serves as water repellency, oil repellency and soil repellency on synthetic and natural fibres
as well as their blends. The achieved effects are fast to washing and dry cleaning.
On basic material with a flameproof finish the flame protection is only minimally influenced by the finish with
TUBIGUARD® 30-F.
Under acid conditions TUBIGUARD® 30-F is compatible with most common cationic, non-ionic and anionic textile
auxiliaries. In any case, preliminary trials for checking the liquor stability or the flame protection are absolutely
necessary.
Application Fields
Application
The fabric to be finished shall be largely free from surface-active substances. Residues from previous working
processes such as finishes, dyeing auxiliaries as well as cleaning agents must be removed through an intense
rinsing process or post-scouring with anionic products such as e.g. SUBITOL ASN or SUBITOL AS 6.
The product should not be allowed to enter drains, water courses or the soil.
Waste, including liquor and rinsing baths, as well as containers must be disposed of in a secure manner (see
also SDS).**
Application Amount
The necessary application amount depends on the fabric composition as well as the desired effect and is to be
determined in preliminary trials. The following application quantities only serve as a general guideline:
Padding process
20.0 - 80.0 g/l TUBIGUARD® 30-F
0.5 - 1.0 g/l KOLLASOL CDO
1.0 g/l acetic acid 60 %
Foaming process
x g/l soft water
1.0 - 3.0 g/l TUBICOAT HEC
0.5 g/l ammonia solution 25 % for swelling
3.0 g/l acetic acid 60 %
40.0 - 200.0 g/l TUBIGUARD® 30-F
3.0 - 5.0 g/l TUBICOAT AOS
When spraying liquids aerosols may develop. Therefore, the spraying device ought to be placed in a separate
encasing to protect the environment from possible aerosols. An optimum suction or room ventilation are also of
utmost importance.
Drying / Fixation
Drying and fixation can be done in one working step provided the drying unit is long enough.
For achieving a good permanency of TUBIGUARD® 30-F to washing and dry cleaning the dry fabric must be
exposed to a minimum temperature of 150 °C for at least 1 ½ min. Higher temperatures decrease the fixation
time.
Our department for applied technique is always at your service for further information and advice.
Our technical advice and recommendations given verbally, in writing or by trials are believed to be correct. They are neither
binding with regard to possible rights of third parties nor do they exempt you from your task of examining the suitability of our
products for the intended use. We cannot accept any responsibility for application and processing methods which are beyond
our control.