Академический Документы
Профессиональный Документы
Культура Документы
3 By using the right-hand rule for motor, you can determine _________
8 _________ has the field circuit connected in shunt (parallel) with the armature
Shunt motor
Series motor
Compound motor
Permanent magnet
The starting current of a DC motor _________ the running current while the motor is
13
operating at its rated speed.
A motor’s capability to maintain a certain speed under varying mechanical loads from
no load to full load
Reverse motor
Vary the speed of a motor
17
SCR
RPM=120F/P
A control circuit
Q.
To counteract the effects of the field distortion in armature reaction in DC motors:
23
These poles are connected in series with the armature circuit or compensating windings
with magnetic field opposite direction armature magnetic field
Q.
The three-phase AC induction motor normally consists of:
24
Q.
In the three-phase AC induction motor with synchronous speed (n1) and rotor speed (n):
25
n1>n
Q. In the three-phase AC induction motor with synchronous speed (n1) and rotor speed (n),
26 percent slip (s):
n1 - n
s=
n1
Wye–delta controller
Soild state
Q. The voltage across each winding by_________ of the line voltage when the windings
28 are connected in wye at the start position
1
3
Q.
Solid-state devices and equipment are used for _________
29
Protection equipment
Other application
Q.
The solid-state, reduced-voltage starter is accomplished by _________
30
Six SCR
Q.
Several types of variable speed drives can be used _________
31
Adjustable-frequency drives
Q.
The stator for a split-phase motor consists of _________
32
Two windings held in place in the slots of a laminated steel core and connected to make
up two windings spaced 90 electrical degrees apart
Q. Observant personnel fully use their senses to diagnose and locate problems in electrical
33 machinery:
Smell directs attention to burning insulation and touch detects excessive heating in
windings or bearings
Hearing detects excessive speed or vibration; and sight detects excessive sparking and
many mechanical faults
Q.
Megohmmeteris used to _________
34
Q.
A growler is used to _________
35
Q.
When does Armature reaction occurs in DC motors occur?
36
The stator magnetic field being distorted, or altered, in reaction to the armature
magnetic field
Q.
37
What does this schematic symbol that refer to?
Q.
In the three-phase AC induction motor:
38
Q.
The speed of the rotating magnetic field depends on _________
39
The number of stator poles and the frequency of the power source
Q.
At no load, the power factor can be _________
40
Q.
41
Wye-connected motor
Star-connected motor
Q.
42
Delta-connected motor
Q.
43 What happened if “O” pushbutton is pressed ?
Jogging capability
Q.
Dynamic braking can also be used to stop an AC motor by _________
44
Q. What is the correct procedure for Troubleshooting ac motors if motor won’t start or
45 motor accelerates too slowly?
Check starter. Is overload protection device opened - Is there power on all lines to
motor – Is voltage to motor more than 10% below nameplate voltage – Check motor
terminal conections. Are nay loose or broken
Q.
What is the correct procedure for Troubleshooting ac motors if motor runs noisy ?
46
Are vibrations and noise from driven machine or power transmission system being
transmitted to motor – Is a hollow motor foundtion acting as a sounding board – Check
motor mounting. Is it loose – is motor mounting even and shaft properly aligned
Q.
What is the correct procedure for Troubleshooting ac motors if motor overheats?
47
Is ambient temperature too high – Is motor too small for present operating conditions –
Is motor started too frequently – check external frame. Is it covered with dirt which acts
as insulation and prevents proper cooling?
Q. What is the correct procedure for Troubleshooting ac motors if motor bearings run hot
48 and noisy?
Every Week
Once a Year
Three years
Q.
Speed control of A squirrel-cage induction motor can be controlled by _________
50
Q.
The two windings of a transformer is
51
Inductively linked
Q. A salient pole synchronous motor is running at no load. Its field current is switched off.
52 The motor will
Q.
The d.c. series motor should always be started with load because
53
Q.
The power factor of a squirrel cage induction motor is …….
54
No torque
Q. The current from the stator of an alternator is taken out to the external load circuit
56 Through
Solid connections
Synchronous motor
Q.
The size of a conductor used in power cables depends on the
58
Current to be carried
Q.
The drive motor used in a mixer, grinder is a
59
Universal motor
Q.
In a capacitor start single-phase induction motor, the capacitor is connected
60
Q.
The synchronous reactance of the synchronous motor is_________
61
Ratio between open circuit voltage and short circuit current at constant field
Current
Universal
Inverse, cannot
Q.
The torque, in a _____________is proportional to the square of the armature current
64
DC series motor
Q. A synchronous motor is operating on no-load at unity power factor. If the field
65 current is increased, power factor will become
Q.
Reduction in the capacitance of a capacitor-start motor, results in reduced
66
Starting torque
Q. If the field circuits of an unloaded salient pole synchronous motor gets suddenly open
67 circuited, then