Академический Документы
Профессиональный Документы
Культура Документы
:10BT10101
Fig. 1
2. a) Define the following with examples: (i) Coplanar and Non-Coplanar forces (ii) Collinear and
Non-Collinear Forces
b) In the Fig.2, three spheres each with 20 N weight and each 350 mm in diameter rest in a box
760 mm wide. Find (a) the reaction of В on A, (b) the reaction of the wall on C, and
(c) the reaction of the floor on B.
Fig.2
3. a) Define cone of friction and wedge friction. Write the laws of friction.
b) The coefficient of friction between a copper block A and an aluminum block В is 0.3, and
between the block В and the floor is 0.2. The weight of block A is 30 N and of block В is 20 N
as shown in Fig.3. What force P will cause the motion of block A to impend?
Fig.3
1
4. a) What is perfect frame and imperfect frame? Write the advantage of method of sections as
compared to method of joints.
b) Determine the forces in FH, HG, IG, and IK in the truss shown diagrammatically in Fig. 4.
Each load is 2 kN. All triangles are equilateral with sides of 4 m.
Fig.4
Fig. 5
6. Find the area moment of inertia about x and y axes of the plane area shown in Fig.6.
Fig. 6
7. A bus starts from rest at point A and accelerates at the rate of 0.9 m/s 2 until it reaches a speed of 7.2 m/s. It
then proceeds with the same speed until the brakes are applied. It comes to rest, at point B, 18 m beyond the
point where the brakes are applied. Assuming uniform acceleration, determine the time required for the bus
to travel from A to B. Distance between A and B is 90 m.