Академический Документы
Профессиональный Документы
Культура Документы
Practical Example
whatispiping.com/aveva-e3d-tutorial-equipment-modeling
Pravin
Govindraj
1/8
In E3D, we should first create a Site, Zone, etc. similar to AVEVA-PDMS. For the “Site”
creation go to Create click on Site In the General tab (Refer to Fig. 1B) and provide a
name as you want. Here, I am giving the name as AvevaE3D. Don’t provide space
between words. Click on Ok.
For Zone creation click on the Zone Tab under Create, and give a suitable name for the
Equipment (Refer to Fig. 2A) and click OK. Next, Go to the Equipment Tab, and in
create tab click on Equipment. Give name as C-1101 as per equipment datasheet and hit
Enter. In the Position tab, Keep East, North, and Up as 0 mm for the time being. We
will fill these values later. Refer to Fig. 2B. Now, Under attributes, Give Description
name as Cracking Tower. You can fill the remaining details if you have, otherwise, you
can keep it blank and press OK to continue further.
2/8
In Method 1, we will be creating the equipment by Primitives (Not Standard
Equipment). So, Select Cylinder shape from the Create tab. Refer to Fig. 3A.
Here you can see the drawing, same as AutoCAD the cursor will be displayed (Fig. 3B).
Now give the value for East : 0 mm and hit the Tab button in keyboard it will lock the
position, you can see the red lock symbol in each Easting, Northing, Up, tab after Hit
Enter.
Now its time to specify the diameter and height of the column. Enter 1413 mm as
diameter and 14076 mm as height as shown in Fig. 3C.
3/8
should be at the bottom, not center. So, Give command as
By u 7038 (half the height of cylinder) and hit Enter.
U means up. Now the cylinder is placed above as you can see in Fig. 4.
Now before proceeding for the next section, Let’s learn a few settings.
For wireframe view press the F11 key on the keyboard.
Or else go to the View tab and click on the Current view in the settings tab.
The view settings window will open.
Under effects section, uncheck shaded then apply and cancel. Refer to Fig. 5.
4/8
Fig. 5: Settings for E3D
Next, go to Project tab -> click Options -> View -> Selection & Snaps
Click Advanced under Snap Settings and Under Object tab uncheck P-point and press
OK. Refer to Fig. 6
For the next steps of the cylinder, Select Cylinder shape from Create tab.
Go to the cone, again click on top P-point of cone
Now give Diameter as 1067 hit Enter and Height as 7849 Hit Enter as per the datasheet.
Refer to Fig. 7B and 7C
Now give diameter as 1067mm enter. After that, E3D will ask for the height of the dish.
Now press down arrow in the keyboard you will be able to see in window two boxes
which are knuckle radius & back.
Click on the knuckle radius and give value as 20 mm and press Enter.
After knuckle radius, provide the height of the dish as 200mm and Hit Enter.
6/8
Fig. 8: Modeling the dish of column in E3D
8/8