Академический Документы
Профессиональный Документы
Культура Документы
a) 180 degrees
b) 60 degrees
c) 120 degrees
d) 90 degrees
Total phase shift provided by all phase shift networks in RC phase shift oscillator is ___________
a) 180 degrees
b) 60 degrees
c) 120 degrees
d) 360 degrees
The phase shift network will produce a phase shift of 180 degrees at ___________
a) Three different frequencies
b) One frequency
c) Two different frequencies
d) Infinitely many frequencies
Which of the following is not a reason for beginning oscillations in RC phase shift oscillator?
a) Phase shift network
b) Noise inherent in transistor
c) Minor variations in the voltage DC source
d) Square wave signal
Amplifier gain for RC phase shift oscillation, to obey Barkhausen’s criteria should be minimum of
___________
a) 43
b) 4
c) 10
d) 29
Frequency of oscillation for three section RC phase shift network is given by ___________
a) 1/(ᴨ√6 RC)
b) 2/(ᴨ√6 RC)
c) 1/(2ᴨ√6 RC)
d) 1/(2√6 RC)
Distortion level in the output of RC phase shift network will be less than ___________
a) 1%
b) 2%
c) 5%
d) 10%
Which of these is incorrect for a Wien Bridge oscillator?
a) Low distortion
b) Good stability at the resonant frequency
c) Difficult to tune
d) Based on frequency selective form of a Wheatstone bridge
What will be oscillator frequency, if phase shift network of 3stages of RC phase shift oscillator contains a
capacitor of 7nF and a resistance of 10K in each stage?
a) 928 Hz
b) 1KHz
c) 1.2KHz
d) 895Hz
At the resonant frequency, what is the phase shift for the output in a Wien Bridge oscillator?
a) 0°
b) 45°
c) 90°
d) 180°
Given that R1=20kΩ, C1=2nF, R2=20kΩ, C2=2nF, find the approximate resonant frequency.
a) 4kHz
b) 3kHz
c) 25kHz
d) 15kHz
The following circuit is provided. R1=R2 and C1=C2.
Lower frequencies are not practically possible in the case of Harley oscillator because of the
requirement of low ___________ value.
a) Capacitance
b) Resistance
c) Inductance
d) Gain
Which type of feedback is used by Hartley oscillator?
a) Voltage series feedback
b) Current series feedback
c) Voltage shunt feedback
d) Current shunt feedback
Which of the following network is used to give feedback to transistor of Hartley oscillator?
a) Inductive fixed bias
b) Capacitive fixed bias
c) Inductive voltage divider
d) Capacitive voltage divider
What will be the oscillator frequency of Hartley oscillator if inductance L1, L2 are equal to 1mH and 2mH
respectively and capacitor C is 10nF. (Neglect mutual inductance)
a) 50KHz
b) 29KHz
c) 40KHz
d) 57 kHz
The improvement of Colpitts oscillator over Hately oscillator is, Colpitts oscillator’s performance in
___________
a) All frequency region
b) Mid frequency region
c) High frequency region
d) Low frequency region