Вы находитесь на странице: 1из 15

6/8/2020 AND

A.A.Shpilman

MAGNETODYNAMIC AXION FIELD GENERATOR


In the active generators of the axion field, previously published in the joint venture ( No. 3/95 , No. 5/95 ,
No. 2/96 ), mechanical rotation of the active material was used, which significantly reduces the reliability of
the device. Naturally, to increase reliability, try replacing mechanical rotation with the rotation of an
anisotropy source (electromagnetic field or vector potential).

The attached figure suggests the design of a magnetodynamic generator of an axion field in which a rotating
or “precessing” magnetic field with a vortex vector potential can be excited. (See also the prepatent of the
Republic of Kazakhstan No. 5366 G01N23 / 00 Bull. No. 4 dated 10/15/97)

The generator consists of:


- Hollow ferromagnetic cylinder 5 (for
example, from two ferromagnetic rings
20x12x6 M2000NM);
- Aluminum (foil) gaskets 4, covering the
ferromagnetic cylinder 5 around the
perimeter and designed to reduce the
dispersion of an alternating magnetic field
outside the cylinder;
- An electric cylindrical coil 6 creating a
magnetic field ("axial") parallel to axis 7
inside the cylinder;
- An electric cylindrical coil 1, minimizing
the magnetic field in the walls of the
ferromagnetic cylinder 5 created by the coil
6;
- Ferromagnetic (iron) screen 1, intended for
magnetic shielding of the device;
- A toroidal electric coil 3, wound on a
ferromagnetic cylinder 5 (as shown), designed to create, together with the cylindrical coil 6, a vortex vector
potential along axis 7;
- A toroidal multi-sectional closed electric coil 9, with electric taps from each section, to which a multiphase
(at least three-phase) voltage is applied so that a magnetic field is created inside the ferromagnetic cylinder,
rotating in a plane perpendicular to axis 7.

A sample of substance 8 is placed inside the described construction, in which axion fields and radiation are
induced due to the combination of the vortex vector potential and the precessing magnetic field relative to
axis 7.

The operation of the device in many ways resembles the operation of devices for obtaining NMR and EPR
spectra, but, in contrast to them, the main task is to orient the vectors of spins of the elements of a substance
in one direction.

The advantage of this generator design compared to previously described in the joint venture ( No. 3/95 , No.
5/95 , No. 2/96 ) is the possibility, by varying the parameters of the vortex vector potential and the
precessing magnetic field, to create sample 8 in and through the material surrounding space, axion fields
with characteristics tunable in wide aisles.

The maximum strength of the axion field is achieved if the precession frequency of the magnetic field is
chosen, which is twice as large as the Larmor frequency of the nuclei (electrons) of the atoms.

As experiments have shown, when a rotating magnetic field with a single frequency is used in this generator,
the flux of “axion” radiations is much larger than in generators with mechanical rotation, which may be
associated with a significant increase in the temperature of spin vibrations of the substance of sample 8, but
spinfield.idhost.kz/ALMANACH/N3_96/Na_2.htm 1/2
6/8/2020 AND

at the same time, the strength of the resulting axion field is obtained of the same order as in the described
generators using mechanical rotation, despite the possibility of using significantly higher rotation speeds.
Possible causes of this phenomenon and ways to further increase the axion field strength are described in the
article " Multi-frequency excitation of axion field generation ".

Continuation of the topic, see in No. 2/97

Attention ! When experimenting with the described axion field and


radiation generators, observe the safety precautions ! Remember,
diseases resulting from the action of axion fields cannot be cured with
tablets! Remember, the damaging effect on a person begins much earlier
than the well-known physical devices react, and biological and mental
diseases can occur both immediately and after a few months. (For more details
see "Safety measures for working with axion generators", and also see No.4/96"Protection against axion
radiation")

Concluding observations

An unexpected result of experiments with a magnetodynamic axion field generator was the
discovery of the possibility of generating a unidirectional axion beam without using any
reflector. From which we can conclude that the spin and magnetic moment of electrons (protons)
are not the same thing, and the properties of the axion field are qualitatively different from the
properties of the magnetic field.

In conclusion, I want to note that, in the work with the axion field generators described in the
joint venture, P.M. Myachin, O.V. Pankova, S.V. Pisareva, O. A. Savitskaya, V. I. Solozhenkin, A
played a large role .V. Tyurin. I also want to note the help of sponsors - I.S. Lis and V.Kh.
Aminova.

Thematic Content

CONTENT

spinfield.idhost.kz/ALMANACH/N3_96/Na_2.htm 2/2
6/8/2020 EdynamicA

A.A.Shpilman (alexandrshpilman78@gmail.com)
Russian

The Electrodynamic Generator of "Axion (Spin) Field"


In N3/96 (Russian) " the Magnetodynamics generator of axion field" was described. Its work has not given
any special delight. It had high danger of generated field in a combination with low efficiency of generation.
The probable reason was that the main working factor was not a magnetic field, but vortical electrical fields
arising at change of a direction of a magnetic field.
Therefore, naturally, there is an idea to rotate a vector of a direction of an electrical field instead of magnetic.

Fig..1 Fig..2

On Fig.1 the design of the generator based on this idea is represented. In it 1 - iron tube; 2 - electrical
toroidal coil; 4 - ferrite tube; 5 - cylindrical electrical coil; 6 - active element (for example, ferrite with small
electrical conductivity); and 3 - drum with vertical plates of electrodes (see Fig.2) creating in an active
element 6 electrical fields perpendicular axes 7.

The practice has shown what more effective to use rotation of a vector quadrupole of an electrical field.

Therefore, if we use a drum with six electrodes that, it is necessary to close electrically opposite electrodes
and give on them a variable three-phase electrical voltage.

If an element 6 – a ferrite cylinder with a diameter ~ of 1 centimeter, that optimum frequency of a three-
phase voltage ~ 1.5 - 3 megahertz. The frequency depends on speed of distribution of indignation of "axion
field" in an element 6 and its diameter.

The magnetic field of the cylindrical coil is set to two order less than in " the Magnetodynamics generator of
axion field", and it does not play the special role, slightly changing quality and intensity of "axion field".

The most interesting effect in the given design that, the beam of "axion field" changes the direction at change
of frequency of a three-phase voltage (it leaves upwards, downwards).

The intensity of "axion field" grows a little if to add to a three-phase voltage high-frequency voltage of small
amplitude with frequencies ~ 7, 12 and 36 megahertz.
spinfield.idhost.kz/ALMANACH/3n99/EdynamicA.htm 1/2
6/8/2020 EdynamicA

There can be a great number of variations of the given design. For example, in figure
3 the multicascade generator of "axion field" is shown, where 2 –a ferrite core, to
which the electrodes of a drum 1 pressed (see Fig.2) and on which the electrical coils
3 reeled. The electrical coils 3 have counter inclusion, so in a zone of electrodes 1, in
a ferrite core 2, the constant radial magnetic field is formed.

On electrodes 1 the three-phase electrical field moves, so in the next drums the
electrical field rotates in the opposite direction.

For designing this generator it is convenient to use analogy of a string of "axion field"
as charged conductor of an electrical current (see "Physical properties of axion (spin)
fields").

This design has an essential lack: the strings of axion field in a zone of ferrite coils 3,
crossing a magnetic field, get a pulse directed perpendicularly to axis of the device.
For reduction of emission of these strings over scopes of the generator, are used the
toroidal coils 4.

Iron tube 5 improves "feedback" along the "axion field", press tore of "axion field"
from sides. Fig..3
Gennadiy P.Ivanov and Pavel M.Miachin actively took part in experiments with the described generators.

Thematic Contents
CONTENTS

spinfield.idhost.kz/ALMANACH/3n99/EdynamicA.htm 2/2
6/8/2020 EMmechA

Russian

A.A.Shpilman (alexandrshpilman78@gmail.com)

The EM-Mechanical Generator of Axion (Spin) field

Results of experiments on separation a component of


"axion field" (see. N1/99) can be applied to
development of generators of a new class.

Trere is an electro-magnet-mechanical generator of


"axion field" (EMM) on Fig.1. The thin copper disk
3 rotates around an axis Z. The copper disk is made
inside the hollow magnetic disk 2, which it's
magnetized as is shown on Fig.1 and Fig.1a (it is
possible to make a design simpler, which consist of
three-four segments). Thus the magnetic disk have to Fig.1
have small electrical conductivity. The upper and
lower surface of the magnetic disk is covered with
aluminum - electrodes 1 and 4. Trere is the negative
voltage on the electrode 1, and the positive voltage
on an electrode 4, relatively copper disk.

The activity of the generator can be tried to describe


as follows:
"THREAD" of "axion field" 5 (see Fig.2), having a
positive electrical pseudo-charge, interact with a
"negative" electrode 1 and pass upwards. Along this
Fig.1a
"THREAD" positive electrical pseudo-charges move
from the outside to the copper disk 3, crossing area with a perpendicularly directional strong magnetic field,
which created by a constants magnet 2.

"THREAD" of "axion field" 6, having negative electrical pseudo-charge, interact


with a "positive" electrode 4 and pass downwards. Along this "THREAD"
negative electrical pseudo-charge move from the copper disk 3 outside, also
crossing area with a perpendicularly directional strong magnetic field created by
a constants magnet 2.
At motion of the disk 3, how it is shown on Fig.2, in "THREADS", moving
together with the disk perpendicular to a magnetic field of a magnet 2, the
electric current is induced. Pseudo-electrical longitudinal current of pseudo-
charges of "THREADS" is increased by this process (longitudial moment of an
impulse is increasd).

If we shall change a direction of a magnetic field that, the longitudinal pseudo-


Fig.2 current of pseudo-charges will decrease (thus, also will be generated "axion
field", but smaller intensity and the generator will be like "a vacuum cleaner" to involve in itself Quons from
the outside).
In both cases, the energy of "THREADS" is increased similarly to a compressed or stretched spring.

If we shall not submit on electrodes 1 and 4 "large" voltage, that "THREADS" of


"axion field" will move from the generator at some angle to a plane of the disk (see
Fig.3). In result common density of "axion field" will increase, but the longitudinal
spinfield.idhost.kz/ALMANACH/2N99/EMmecha.htm 1/2
6/8/2020 EMmechA

impulse of a beam moving from the generator, will decrease (and length of a beam will
decrease). Such voltage is possible to pick up, at which maximum density of a field in
specific area will be.

In difference from the earlier described generators using mechanical rotation, in the
given generator main is the linear speed of motion of the copper disk (and intensity of a
magnetic field). Therefore, "axion field" will have the form of a pipe moving upwards
and downwards from perimeter of the copper disk.
Fig.3
In generation of "axion field" the main role is played a surface of the copper disk (it is
characteristic for conductors), therefore it is meaningful to make it more thin as it is possible and carefully
clear its surface.
For increasing of intensity of "axion field" it is possible to cover a lower surface of the copper disk with a
thin layer of an "alloy Rose" (or tin), and to cover upper surface with a thin layer (spirituous of a solution)
colophony. Probably, will be the interesting effects, if instead of the copper disk you will rotate fluids
(melts). For example, mercury or gallium. If thus there will be hashing fluid, that the "actuated" nucleuses of
atoms will be continuously move from a surface deep into of fluid, and on a surface will be continuously
occur not actuated ones. Probably, thus, it will be possible to actuate all volume of fluid (melt, and then it is
possible to cool a melt).

How, constants magnets and the ferrite


have not infinitesimal conductivity that,
it is meaningful to feed pulse voltage on
electrodes 1 and 4 to ensure presence of
an electrical field at a body of a constant
magnet 2. But it also can be
unsufficiently. Therefore, it will desirable
to add aluminium (or graphite) covers of
internal planes of the hollow magnetic
disk (electrodes 7 and 8) as it is shown on
Fig.4. In such case, relatively copper disk
it is possible (roughly) to feed the
following voltage on an electrode 1 -
Fig.4 -3100 volts, 7 - -3000 volts, 8 - +3000
volts, 9 - +3100 volts. The maximum voltage moves on electrodes 7 and 8 and it is not causing spark
discharge.

The efficaciousness of the given generator is very high, therefore be cautious and obey the accident
prevention.

(see N3/95 , N5/95 , N2/96 , N3/96 , N2/97 , N1/98 , N2/98 , N1/99)

Thematic Contents
CONTENTS

spinfield.idhost.kz/ALMANACH/2N99/EMmecha.htm 2/2
6/8/2020 ?

Alexander A. Shpilman( alexandrshpilman78@gmail.com )

Russian | Italiano
The author of the data of lines has done a bit of travelling on much to open spaces of former Soviet Union,
met and meets the people engaging "non-traditional" sciences. Unfortunately, at many from them on soil
mania of greatness and hidden of fears to remain with anything, the illness of secrecy was showed, though if
attentively to consider, that they have, it is possible to reach in a conclusion, that contents do not cost and not
worth twopence or anyway that they have is small grain of knowledge, on the basis of which in the single
anything will not achieve. This illness results in self-isolation, to loss of creative activity and at the end
results in apathy.

The way of knowledge is infinite. The creative person always will be than to gift of ambient, and at the
fruitless man and that is present, will not give sprout.

Ferrite-magnetic the Reflector Axion (Spin) of Radiation


The ways are known of change of a direction of propagation of electromagnetic waves with the help of
mirrors constructed on effect of reflection from border of the unit of environments of a type dielectric-
dielectric and a dielectric-conductor at the expense of a difference of parameters of refraction, interference
and diffraction on a regular structure of a crystal lattice for x-ray, gamma, beta and other kinds of radiation.
But they can not be applied for reflection axion of radiation (spin waves), since it is direct with a crystal
lattice (known materials) practically does not cooperate.

As axion of a field and the radiation cooperate, in basic, only with spin of electrons and nucleuses of atoms,
it is meaningful to try to change a direction of propagation axion radiation at the expense of orientation these
spins. That is, the change of a direction of propagation of energy axion radiation is possible to achieve by the
reflector with the induced or internal anisotropy focused perpendicularly to a direction of propagation of
radiation of a source, with deviation from perpendicularity on a angle which is not exceeding of a angle
"precessions" of spin of active elements of the reflector, rather this anisotropy.

Generally, the axion radiation, penetrating in any material and cooperating with backs of its making
elements, orientates them on a direction of an axis of radiation. In result the spin channel is formed, along
which there is a propagation of energy axion of radiation. If of elements of a material are already guided
perpendicularly to direction axion of a field, there is absorption of energy axion of radiation and re-emission
take place in a direction of orientation of interacting a spin (in our case within the limits of a cone of
precession a spin). The average change of a direction of propagation of energy axion radiation makes 90
degrees at such reflection.

In the device described in N3/95 axion the radiation occurs along rotation axis in both directions (two rays of
opposite polarization).

The device (Reflector) shown on figure generates unidirectional axion radiation (See also patent of Republic
of Kazakhstan N5365 G01N23/00, bull. N4, 15.10.97).

In which, hollow the cylinder 2 is made from a ferromagnetic material with built-in constants by magnets
(see N3/95). A cone of the reflector 3 with a covering ring 4, are made of silver or cadmium, with thickness
of walls of 1 mm (the large thickness is not meaningful, as works in a main surface) both angle between an
axis and forming of a cone equality to 30 degrees.

The offered design as follows works:

The return ray of axion radiation 5 hollow of the cylinder 2 radiators, dropping on a surface of a reflecting
cone 3 under a angle to it, equal to precession angle spin of electrons and nucleuses of atoms of a cone
concerning an axis of an anisotropy called by a gradient of concentration on border of the unit of
environments (for example metal - oxide-air), cooperates with last, therefore energy of axion radiation of a
ray 5 re-emit on a direction of the data spin. Thus, is formed axion radiation (reflected) as a ray 6, which as a
result of spatial interaction with a direct ray 7, forms in space closed axion a field in the form of the extended
spinfield.idhost.kz/ALMANACH/N5_95/Reflect.htm 1/2
6/8/2020 ?

ellipsoid of rotation with a main axis conterminous to an


axis of the device (Reflector), in result density of axion
radiation in a near zone considerably grows

At use of the offered reflector axion the radiation 5 drops


on a surface of metal under a angle to it of 30 degrees and
is reflected concerning it on the average under a angle in 60
degrees (reflected ray 6), so the full angle of change of
trajectory of motion of axion a ray makes 90 degrees.

At use of the offered reflector the drive of the radiator can


be located along an axis of the radiator 1, inside a cone of
the reflector 3 with appropriate electromagnetic protective.

It is necessary to note, that the processes, occurring in the


given design, are considerably more complex than the
adduced description, and it is natural, demand the further study.

Translation carrying-out by T.M.Shpilman

(see N3/95 , N2/96 , N3/96 , N2/97 , N1/98 , N2/98 , N1/99 , N2/99)

Thematic Contents
CONTENTS

spinfield.idhost.kz/ALMANACH/N5_95/Reflect.htm 2/2
6/8/2020 The High-Voltage Generator of the "Axion Field"

Alexander A.Shpilman (alexandrshpilman78@gmail.com )

Russian

The High-Voltage Generator of the "Axion Field"


And of DS-state Elements
Was already spoken about DS-state elements (see "Time - Overtime") as about the basic radiant of the "axion
field". The concentration of DS-state (m-state) elements in many respects determines density of the "axion
field" of generators. For attainment of appreciable physical effects the attainment of major density of the
"axion field" is necessary. But greatest density of "field" is reached immediately in a place of concentration
of DS-state elements, therefore it is reasonable, to try to reache appreciable physical effects, immediately
sating by DS-state elements object of experiment. The concentration of DS-state elements from natural
sources is unsufficient for this purpose. It is necessary will learn is artificial them to synthesize.

Presumably, for synthesis of DS-state elements it is necessary to spend energy not less than 10000 eV on one
convertion a proton. Interest to electric fields of a high voltage therefore is natural.
MOUSTACHE of a proton (see "Physical properties of axion (spin) fields") is partly oriented on a direction
of an electric field, twisting in a secondary spiral, but thus, usually there is no necessary quantity of
deformation of its spectrum. Probably, parent in phase auto tuning of pseudo-negative and pseudo-positive
THREADS of the "global line" of a proton.

This problem is solved if separate in space pseudo-


negative 2 and pseudo-positive 1 THREADS (see
Fig.1), for example, as it was described in article
"Separation Axion (Spin) Field".

In the simplified variant the similar construction is


shown in a Fig.2. Where on a polyethylene bobbin 4 the
one-layer reel by the double enameled copper wire (wire
2 and 3 diameter of 0.1 mm and more thin) is densely
reeled the coil to a coil. Inside of a bobbin the copper
wire 1 is inserted. On wires 2 and 3 the difference of a
voltage 100-150V (wire among themselves not closed-
loop). Concerning these wires, on a wire 1 the pulsatory
Fig.1
high voltage not less than 20 kV moves, approximate
shape of a pulsation as in a Fig.5.

spinfield.idhost.kz/ALMANACH/2n01/HVe.htm 1/3
6/8/2020 The High-Voltage Generator of the "Axion Field"

Fig.2 Fig.3 Fig.4

The split in space of pseudo-negative and pseudo-positive THREADS of a proton (material of a wire 1)
occurs in a gap between wires 2 and 3. And the pulsatory high voltage deepens it of split of a MOUSTACHE
of a proton. This action similarly to unfastening of the lock for clothes - "lightning".

The described construction already is a source of the


"axion field" and of DS-state elements. If a
polyethylene bobbin 4 (with windings) to make in
length in some meters and to wind it in a dense coil,
we shall have not directional source of DS-state
elements. If to formed a package from the parallelly
combined bobbins with windings, we shall have a
directional stream of DS-state elements.

For generation of the "axion field" and of DS-state Fig.5


elements of required quality it is necessary by an
exterior a construction to set a new configuration of interaction of pseudo-negative and pseudo-positive
THREADS (to clasp the lock "lightning"). For example, as it is shown in a Fig.3. Where 5 and 6, accordingly
left-hand and right spiral (are shown in a profile) reeled by a thick conductor with a different step. On one
spiral moves approximately -60V concerning a negative wire of the reel 2-3, and on other spiral moves +60V
concerning a positive wire of the reel 2-3. A sign of electrical potential on spirals, direction of winding (left-
hand or right), step of a spiral and relation of a step of winding of spirals set quality of a generated field and
stream of DS-state elements. The arcuation of 7 lower ends of spirals sets a preferred orientation generated
of the "axion field" (upwards in a Fig.3).

For split of a MOUSTACHE of a proton it is possible to use a


great gradient of an electric field in a neighbourhood of a thin
conductor (2 in a Fig.4). For example, in a construction shown
on a Fig.4 the unary reel 2 reeled by a thin wire with a great
step is used. This construction is easier than a construction in
a Fig.2, but is less effective and is critical to quality of a
dielectric of a bobbin 4.

spinfield.idhost.kz/ALMANACH/2n01/HVe.htm 2/3
6/8/2020 The High-Voltage Generator of the "Axion Field"

Using this principle it is possible to transform a construction


shown on a Fig.4, for example, to a construction figured on a
Fig.6. Where on a polymeric dielectric strip 1 double wire,
with a step, reels the reel. Then the windings are cover a
dielectric coat. Between wires 2 and 3 the high pulsate voltage
form similar figured on a Fig.5 moves. Naturally, the
polymeric film 1 and polymeric coat should maintain a high
voltage, excepting an electrical breakdown between wires 2
and 3. The strip with the reel can be turned in a roll. Thus
volume will be more effective to be used.
Fig.6
Taking into account a principle of split of a MOUSTACHE of
a proton the gradient of an electric field, in a new perceives idea "a lusters of Chigevski". On negative
charged needles "a luster's of Chigevski" occurs not only ionization of air, but also synthesis of DS-state
oxygen and nitrogen. This effect is possible will strengthen using a negative pulsate voltage by the shape
similar shown on a Fig.5.

The construction of a Fig.2 can be "simplified" using composite a


dielectric. For example, as a dielectric it is possible to choose a resin
(colophony) in which the powder 1/10 from a weight of a dielectric
consisting from carbonyl of iron and carbonic copper in the ratio 2:1
on a weight is added.
Between grains copper and iron natural electrochemical potential is
formed. This potential small, but the MOUSTACHE of a proton,
transiting set of gap between grains, accumulates a phase displacement
between its pseudo-negative and pseudo-positive THREADS
necessary for split of a MOUSTACHE.
In result the construction becomes simpler up to a usual parallel-plate
capacitor (see Fig.7). Where 1 resin with a filling compound, 2 and 3
lead plates. On a plate 3 positive moves high pulsate voltage (see Fig.
Fig.7 5) concerning a plate 2.

The described construction creates radiation perpendicularly planes of the condenser and along a plane of the
condenser. In all three directions the quality of radiation differs.

It is supposed, that in this construction are generated DS-state elements


at which pseudo-negative and the pseudo-positive THREADS are close
in the eight of a field sort 4 (see Fig.8).

Carbonyl the iron and carbonic copper can be exchanged by sand from
a crystalline quartz. Thus the positive lead plate 3 is exchanged with a
plate from a bismuth or cadmium. In result the intensity of radiations
decreases, but their quality becomes more favorable for the man.

Fig.8
Thematic Contents
CONTENTS

spinfield.idhost.kz/ALMANACH/2n01/HVe.htm 3/3
6/8/2020 The High-Voltage Generator of the "Axion Field"

Alexander A.Shpilman ( alexandrshpilman78@gmail.com )


Russian

The High-Voltage Generator of DS-state Elements


It was already spoken about high-voltage generators of DS-state elements (see "Time - Overtime") in N2/01
Here we shall continue this theme.

The design of the generator of DS-state


elements (DSS elements) which is made
as a capacitor with using of composit
dielectric (see Fig.1) and a pulsing
voltage on electrodes (see Fig.2) is
discribed in N2/01. Our experiments
have shown, that is possible to use plates
made of drusen crystal quartz (see Fig.3) Fig.2
as anisotropic dielectric it with an angle
Fig.1 of a cut is 45О in such a design. There
are frequently cracks between crystals of quartz through which an
electric breakdown between electrodes 2 and 3 occurs (see Fig.1) in
such a plate. Therefore it is necessary to cover such plate (to
impregnate) with colophony (rosin) dissolved in spirit or it is better
to impregnate a mix of colophony with a stearin. Preliminary,
colophony and stearin should be melt in together. Then a little
alcohol is added to the mixture. The mixture should be carefully
mixed up and our plate of a cut of drusen crystal quartz should be
covered by it.

The powder of carborundum (SiC) impregnated by colophony works


rather effectively in "a capacitor" variant of the DSS generator. Such
dielectric has rather big electric conductivity, therefore it is
recommended to use, for example, a long cylinder of such dielectric Fig.3
like with electrodes at the butt-ends (see Fig.4).

It is not clear yet how DSS elements generated by the


carborundum influence on a man, therefore it is not
recommended to experiment the given design in the
apartment. And also it is not recommended to switch
it on for the time more than it is necessary for the
experiment. It is better to carry out researches in the
Fig.4 protective box from an electret film (see Shielding
packing ).

Reasoning from the already known information an attempt to improve "Chizhevsky's luster" is also interested to
us.

For example, electrodes 1-5 are placed


between dielectric plates 6 (see Fig.5).
The electrode 1 is made from
aluminium, 2 is a thin tungstic wire,
3,4,5 are made from silver (or copper
covered by silver).
The pulsing voltage 15 kV + 130V is
Fig.5 fed on the electrode 1.
The pulsing voltage 15 kV is fed on the
electrode 2.
The pulsing voltage -15 kV is fed on
Fig.6 the electrode 3.
Electrodes 4 and 5 have zero potential.
spinfield.idhost.kz/ALMANACH/3n02/HVe.htm 1/3
6/8/2020 The High-Voltage Generator of the "Axion Field"

The corona discharge on a thin tungstic electrode 2 ionizes air, this induces ions with a positive charge. A
difference of a voltage in 130V between electrodes 1 and 2 is strengthened by splitting between components of
the "axion fields" with the negative and positive electric pseudo-charge (see Fig. 6) of these ions (the first act of
DSS elements’ generation). The ions with a positive charge drift to the electrode 3 where their recharge occurs
(change of a sign on a charge on the opposite one). Then the ions with the negative charge in the drift pass the
electrodes 4, 5 and leave our design. The electrodes 4, 5 make the stream of air between the dielectric plates 6
more stable (from the left to the right of figure 5). With a stable stream of ions is provided also.

Thus, the generation of DSS elements


(nitrogen and oxygen) is take place at
a potential difference of a pulsing
voltage in 30kV. The negative charge
of generated DSS elements raises
their stability. (Pay attention, ions and
DSS elements are not the same).
Naturally, it is necessary to expect
that the given device will generate
more negative ions than DSS
elements. Nevertheless this generated
stream of DSS elements is quite
perceptible for a man.

It is tempting to divide generated


DSS elements in space according to
their polarization and to simulate by
it "A Place of POWER". This
function of a small “places force” is
carried out by the construction
represented in Fig.7 (The Imitator of Fig.7
a "Place Power " IPP-1). Where, the
electrodes 1, 2, 3 settle down
between the dielectric disks 7 with
apertures in cent. The electrode 1 is
an aluminium ring, 2 is a ring from a
thin tungstic wire, 3 is "a float" from
silver.
The pulsing voltage 15 kV + 130V is
fed on the ring 1.
The pulsing voltage 15kV is fed on
the ring.
The pulsing voltage -15 kV is fed on
"a float" 3. Fig.8 Fig.9
The pintle from silver passes on the axis of "the float" to which "short moustaches" of several wires from silver
5 are soldered. They are located inside of two toroidal electric coils 11 with are reeled up on the iron cones 9
atop of the cone-shaped electric coils 10. The cone-shaped electric coils 10 create magnetic field H (see Fig.8),
this field is parallel to the axis of the device.
The toroidal coils 11 create (magnetic) vector potential A directed as it is shown in Fig.9. Such combination of
electric coils in the sum creates vector potential of spiral structure with opposite polarization in the top and in
the bottom cone.
The toroidal coils are protected from high-voltage breakdown by the dielectric cones 8.
The grids 6 are located above the pintle and "short moustaches" for stabilization of corona discharge on the ends
of the pintle and the "short moustaches".

As well as in the design in Fig.5, the


corona discharge on the thin tungstic
electrode 2 ionizes air and induces the ions
by a positive charge. The difference of a
voltage in 130V between electrodes 1 and
2 is strengthened by splitting between the

spinfield.idhost.kz/ALMANACH/3n02/HVe.htm 2/3
6/8/2020 The High-Voltage Generator of the "Axion Field"

components of the "axion fields" with a


negative and positive electric pseudo-
charge of these ions (the first act of the
DSS elements’ generation). The ions with a
positive charge carrying away the air, drift
to the electrode 3 where their recharge
occurs (change of a sign of the charge on
the opposite one). Then the ions with a
negative charge together with the stream of
air leave upwards and downwards along
the axis (along the pintle of "the float") of
the device through apertures in the center
of the dielectric disks 7. The corona
discharge above the pintle and "short
moustaches" 5 increases concentration of
negative ions in the air and amplify the
stream of air from the cones.
Fig.10
Against usual ions, the negative DSS ions
go up or down of the design according to their polarization. And then leave the design in the corresponding
direction.

Probably, it is better to place the design it is horizontal position far away from the walls and other dense,
properly sized objects for saturation of a room by DSS ions. It is desirable to orient the design on the magnetic
field of the Earth (the top cone of the design should be directed on the South Pole of the Earth).

General view of a design can be seen in Fig.10.

Thematic Contents
CONTENTS

You can buy the imitator of a "place power" IPP-2


Information on E-mail: alexandrshpilman78@gmail.com

spinfield.idhost.kz/ALMANACH/3n02/HVe.htm 3/3
6/8/2020 The High-Frequency Three-Phase Generator

Alexander A.Shpilman ( alexandrshpilman78@gmail.com )


Russian

The High-Frequency Three-Phase Generator


In the generators of the "axion field" with electrodynamic excitation described in "The Electrodynamic Generator of "Axion (Spin) Field"", "Excitation of
"Axion (Spin) Field" in Water" and "The Generator of the "Axion Field " Sort 5", the high-frequency three-phase generator is usually needed. The simple
and compact variant of such circuit is shown below.

Fig.1

C1, C2, C3, C6, C7, C8 - 0.1mF - ceramic capacitor;


C4* - 100pF - selecting at a choice of a range of tuning of frequency;
C5, C8 - 47mF;
D1 - SN74S124N;
D2 - SN74S175N;
D3 - SN74S10N;
D4, D5, D6 - SN75452N;
L1 - 200 microhenry - radio-frequency choke;
L2,…, L4 - 50 microhenry;
R1, R2, R4 - 3 kOhm
R3 - 4.7 kOhm - The multiturnaround tuning resistor (adjustment of generation's frequency);
R5, R6, R7 - 75Ohm;
V1,…, V7 - the pulse silicon semi-conductor diode
T1, T2, T3 - transformer, for example, ferrite core 12x5x5.5 of mark 1500, electrical windings 1-2 and 2-3 with 6 coils of a copper wire, the winding 4-5
contains 90 coils.
The exact meanings of the transformer depend on frequency, electrical capacity of electrodes and necessary voltage.

Connect point A with contact 16 of microcircuits D1, D2; with contact 14 of microcircuits D3 and with contact 8 of microcircuits D4, D5, D6.
Connect point B with contact 8 of microcircuits D1, D2; with contact 7 of microcircuits D3 and with contact 4 of microcircuits D4, D5, D6.

Points (output of phases) F1, F2 and F3 to connect to the appropriate electrodes.

Connect points (output of phases) F1, F2 and F3 with the appropriate electrodes.

Point C powers from an adjustable source of a voltage + 5 - + 15V.


At adjustment of the electrical circuit use voltage no more than + 5V.

Thematic Contents
CONTENTS

spinfield.idhost.kz/ALMANACH/3n00/ShemaA.htm 1/1

Вам также может понравиться