Академический Документы
Профессиональный Документы
Культура Документы
Previous Screen
Product: EXCAVATOR
Model: 320C EXCAVATOR AMC
Configuration: 320C & 320C L Excavators AMC00001-UP (MACHINE)
POWERED BY 3066 Engine
Troubleshooting
320C, 322C and 325C Excavators Tool Control System
Media Number -RENR3823-13 Publication Date -01/08/2006 Date Updated -28/08/2006
i02581371
Illustration 1 g00869078
Schematic of the circuit for the sensor power supply
This diagnostic code will be recorded when the ECM reads the current for the circuit of the sensor supply as
being above normal.
System Response:
Possible results that may occur for this condition are listed:
Test Step 1. CHECK FOR A SHORT TO GROU"D O" THE WIRE HAR"ESS
A. Turn the key start switch and the disconnect switch to the OFF position.
D. Turn the key start switch and the disconnect switch to the ON position.
E. Measure the voltage between contact CONN46 - 1 of the wire harness and frame ground.
F. Measure the voltage between contact CONN47 - 1 of the wire harness and frame ground.
Expected Result:
Results:
OK - The voltage is 12 volts on both connectors. The circuit is correct. Proceed to Test Step 2.
Repair: The wire harness is shorted to ground. Repair the wire harness or replace the wire harness.
STOP
D. Turn the key start switch and the disconnect switch to the ON position.
Expected Result:
Results:
Repair: The problem does not exist at this time. Check all connectors on the wire harness and clean
all contacts in the connectors.
STOP
Repair: It is unlikely that the controller has failed. Exit this procedure and perform this diagnostic
code procedure again. If the cause of the diagnostic code is not found, replace the Controller. See
Testing and Adjusting, "Electronic Control Module (ECM) - Replace" for the Tool Control System.
STOP
Copyright 1993 - 2008 Caterpillar Inc. Sun Dec 7 13:35:07 UTC+0630 2008
All Rights Reserved.
Private Network For SIS Licensees.