Академический Документы
Профессиональный Документы
Культура Документы
TASK 79−12−05−000−801
1. Removal of the Airframe−Mounted Oil−Tank Drain Valve
A. Reference Information
REFERENCE DESIGNATION
REFERENCE DESIGNATION
C. Job Set−Up
(2) In the flight compartment, on the EMS CDU, close the circuit breakers that follow
(TASK 24−00−00−863−801):
EFFECTIVITY: ALL
ACCESS DESIGNATION
NOTE: Do the above procedure only to the point where the airframe−mounted oil
tank is fully drained, then continue with the procedure that follows.
D. Procedure
(4) Put a protective cover on the open port of the airframe−mounted oil tank (1).
EFFECTIVITY: ALL
FS922.86
GMM7912054_001
EFFECTIVITY: ALL
TASK 79−12−05−400−801
2. Installation of the Airframe−Mounted Oil−Tank Drain Valve
A. Reference Information
REFERENCE DESIGNATION
REFERENCE DESIGNATION
Commercially Available Wrench, Torque 28.8 to 106 lbf in (3.26 to 11.97 Nm)
C. Consumable Materials
EFFECTIVITY: ALL
D. Parts
3 Packing 1 79−12−05−40−010
E. Job Set−Up
(1) Make sure that the aircraft is in the same configuration as in the removal task.
NOTE: Make sure that the mating surfaces are clean with no corrosion, paint,
grease, or preservation fluids.
F. Procedure
(1) Lubricate the packing (3) with lubricating oil and install it on the drain valve (2).
(3) Torque the drain valve (2) from 28.8 to 106 lbf in (3.26 to 11.97 Nm)
(SPM−MM 20−22−00−910−801).
(4) Safety the drain valve (2) with lockwire (SPM−MM 20−50−00−400−801).
(5) In the flight compartment, on the EMS CDU, set the circuit breakers that follow to IN
(TASK 24−00−00−863−802):
(6) Do the servicing of the oil supply at the airframe−mounted oil tank
(TASK 12−14−05−612−801).
EFFECTIVITY: ALL
G. Close Out
(1) Remove all tools, equipment, and unwanted materials from the work area.
ACCESS DESIGNATION
EFFECTIVITY: ALL