Академический Документы
Профессиональный Документы
Культура Документы
CCNA – W AN
A – AS numbers must be changed to match on all the routers
B – Loopback interfaces must be configured so a DR is elected CCNA – W AN 2
C – The no auto-summary command is needed on R1 and R3
D – R2 needs to have tw o netw ork statements, one for each connected netw ork CCNA – IP Address Questions
B is not correct because neighbor table only contains a list of directly connected EIGRP routers that have an adjacency w ith this CCNA – NAT & PAT Questions
router, it doesn’t contain successor routes.
CCNA – Drag and Drop 1
C is not correct because successor routes are not flagged as “active”, they are alw ays the best route to reach remote netw orks
and are alw ays used to send packets. CCNA – Drag and Drop 2
A and D are correct because successor route is the best and primary route to a remote netw ork. It is stored in the routing table CCNA – Drag and Drop 3
and topology table. If this route fails, a backup route (called feasible successor route) in the topology table w ill be used to route
traffic to a destination. CCNA – Drag and Drop 4
W hich tw o statements are true regarding EIGRP? (Choose tw o) CCNA – Sw itch Questions
A – Passive routes are in the process of being calculated by DUAL CCNA – Sw itch Questions 2
B – EIGRP supports VLSM, route summarization, and routing update authentication
C – EIGRP exchanges full routing table information w ith neighboring routers w ith every update CCNA – Sw itch Questions 3
D – If the feasible successor has a higher advertised distance than the successor route, it becomes the primary route
E – A query process is used to discover a replacement for a failed route if a feasible successor is not identified from the current CCNA – VLAN Questions
routing information
CCNA – VLAN Questions 2
“Support VLSM, route summarization, and routing update authentication” are the features of EIGRP -> B is correct. CCNA – Operations 1
W hen a route fails and has no feasible successor, EIGRP uses a distributed algorithm called Diffusing Update Algorithm (DUAL) CCNA – Operations 2
The file was converted using http://www.convertapi.com Please purchase credits to remove this text http://www.convertapi.com/prices
to discover a replacement for a failed route. W hen a new route is found, DUAL adds it to the routing table -> E is correct.
CCNA – Operations 3
Question 4
CCNA – Troubleshooting 1
W hich type of EIGRP route entry describes a feasible successor?
A. a primary route,stored in the routing table CCNA – Troubleshooting 2
B. a backup route,stored in the routing table
CCNA – W ireless
C. a backup route,stored in the topology table
D. a primary route,stored in the topology table CCNA FAQs & Tips
B. CCIP Website
C.
D.
Answer: B
Explanation
To be the feasible successor, the Advertised Distance (AD) of that route must be less than the Feasible Distance (FD) of the
successor. From the output of the “show ip eigrp topology 10.0.0.5 255.255.255.255″ w e learn that the FD of the successor is
41152000.
Now w e w ill mention about the answ ers, in the “Composite metric is (…/…)” statement the first parameter is the FD w hile the
second parameter is the AD of that route. So w e need to find out w hich route has the second parameter (AD) less than
41152000 -> only answ er B satisfies this requirement w ith an AD of 128256.
Question 6
A netw ork administrator is troubleshooting an EIGRP problem on a router and needs to confirm the IP addresses of the devices
w ith w hich the router has established adjacency. The retransmit interval and the queue counts for the adjacent routers also
need to be checked. W hat command w ill display the required information?
A. Router# show ip eigrp adjacency
The file was converted using http://www.convertapi.com Please purchase credits to remove this text http://www.convertapi.com/prices
B. Router# show ip eigrp topology
C. Router#show ip eigrp interfaces
D. Router#show ip eigrp neighbors
Answer: D
Explanation
Below is an example of the show ip eigrp neighbors command. The retransmit interval (Smooth Round Trip Timer – SRTT) and
the queue counts (Q count, w hich show s the number of queued EIGRP packets) for the adjacent routers are listed:
Question 7
Refer to the exhibit. How many paths can the EIGRP routing process use to forw ard packets from HQ_Router to a neighbor
router?
A. tw o equal-cost paths
B. tw o unequal-cost paths
C. three equal-cost paths
D. three unequal-cost paths
E. four equal-cost paths
F. four unequal-cost paths
Answer: F
Explanation
The “Maximum path: 4″ means EIGRP can use up to 4 equal-cost paths to forw ard packets from HQ_Router to a neighbor
router. But here the variance is set to 3 w hich allow s unequal-cost paths. Therefore in this case EIGRP can use up to four
unequal-cost paths.
Question 8
IP address and routing for the netw ork are configured as show n in the exhibit. The netw ork administrator issues the show ip
eigrp neighbors command from Router1 and receives the output show n below the topology. W hich statement is true?
A. It is normal for Router1 to show one active neighbor at a time to prevent routing loops.
The file was converted using http://www.convertapi.com Please purchase credits to remove this text http://www.convertapi.com/prices
B. Routing is not completely configured on Router3.
C. The IP addresses are not configured properly on the Router1 and Router3 interfaces.
D. The no auto-summary command configured on the routers prevents Router1 and Router2 from forming a neighbor
relationship.
Answer: B
Explanation
From the output of Router1, w e learn that Router1 has not established neighborship w ith R3 yet. Also from the “show running-
config” on Router3 w e notice that the “netw ork 192.168.3.0″ statement is missing -> the configuration on Router3 is not
complete.
Comments
C omment pages « Previous 1 2 3 4
The file was converted using http://www.convertapi.com Please purchase credits to remove this text http://www.convertapi.com/prices
prabu April 26th,
2012
If anyone taken exam please update the status and conform w hether the dumps are valied….
Thanks in advance….
Sarju April 26th,
2012
@Nazty
Diffrence betw een equal cost & unequal cost load balancing
if you have 2 links to the same netw ork of 2 Mbps each, routing protocols w ill bundle them and w ork as 4 Mbps in total,
sending 1 packet on one link and one packet to other. this is equal cost load balancing.
But w hat if you have one link of 2 Mbps and another 4 Mbps?
EIGRP comes to the rescue;It w ill detect one link is half of other, then w ill bundle them and send 2 packet on 4 Mbps w hile 1
packet on 2 Mbps link. this is unequal cost load balancing.
qrsa April 27th,
2012
>>EIGRP comes to the rescue;It w ill detect one link is half of other, then w ill bundle them and send 2
packet on 4 Mbps w hile 1 packet on 2 Mbps link. this is unequal cost load balancing.
It w as my main misunderstanding – I thought that EIGRP cares about every link bandw idth; but it doesn’t! It calculates metric
according to minimum bandw idth of all th links on the path! So, if you are going to load-balance unequally, bandw idth is not a
good choice – it’s w orth to use delay!
And one more point about EIGRP:
In simulations VUE w hats to get it’s answ er (not the correct one). For example, in the routing CCNP exam there is EIGRP sim
and it thinks that defining netw ork by the exact IP (netw ork 10.15.1.1 0.0.0.0) is incorrect, but w hats to see classless net
(netw ork 10.15.1.0 0.0.0.255).
One more my misunderstanding w as about netw ork statement; remember:
1. If it’s w ritten as “netw ork 192.168.0.0″ – it’s equal to “netw ork 192.168.0.0 0.0.0.255″ – so classful mask is applied;
“netw ork 10.0.0.0″ the same as “netw ork 10.0.0.0 0.255.255.255″.
2. If you have tw o interfaces 10.0.1.1/24 & 10.0.2.1/24, then you can use either of declarations:
“netw ork 10.0.0.0″
or “netw ork 10.0.1.0 0.0.0.255″ + “netw ork 10.0.2.0 0.0.0.255″
or “netw ork 10.0.0.0 0.0.3.255″
or “netw ork 10.0.1.1 0.0.0.0″ + “netw ork 10.0.2.1 0.0.0.0″
Best regards!!!
PS: do not forget passive-interface in EIGRP… “passive-int default” rules! :)
lucas May 2nd,
2012
do i have to configurations during ccna exam
Mbwana May 13th,
2012
q7 w hat i understand w hen variance >1 it has unequal-route equal to maximum path
but w hen variance is 1 it has equal-route equal to max path i am right
puneet May 20th,
2012
Hi all, I am taking CCNA 640-802 exam first time on 30/05/2012. Could anyone please send me latest
dumps w hich are valid for UK? My e-mail address is puneet_gill84@yahoo.co.uk. Many thanks.
geedub May 22nd,
2012
Mbw ana — I agree w ith you — variance 1 then possible for equal cost paths is 4??
q7
pelikan May 24th,
2012
@jelenna82
i think you’re right about Q3, ” feasible successor ” w ill become a back-up route and be put in the topology table if it satisfies
the condition, w hich is – it must have a low er AD… :-)
Basav May 24th,
2012
Hi Can anybody send me latest dumps valid for usa to my mail id, basavarajpardi@gmail.com.
thank you
MUHAMMAD May 28th,
RASHID 2012
I PASSED CCNA EXAM TODAY THANKS TO ALL MIGHTY ALLAH
960/1000
Anonymous May 28th,
2012
w hich labs doing in exzam
Ammad June 7th,
2012
Can anyone guide me w hat kind of labs w ould i expect to come, and the netw ork diagram is over there
and w e have to configure that and tick the right answ er. Is that so?
God’s June 21st,
Grace 2012
I passed my ccna exam today Praise be to God! Thank you Jesus! and thanks to 9TUT for the
tutorials and explanations, great site and thanks to xallax for your explanations to questions and thanks to
http://w w w .examcollection.com for the dumps. Pls guys lets donate and help to keep this site up!
48 ques for exams including 3 simulation, I had EIGRP, Acesslist2 and VTP . Make sure you practice the simulation, use packet
tracer or gns3. Best w ishes to all!
Y erla July 2nd,
2012
Alhamdulillah! Thanks to Great Allah! I have passed CCNA w ith score 933. This site is very useful!
Eng.shaymaa July 4th,
2012
hiiiiiii……i w ill pass ccna today al hamdo llah. thanks for god ..thanks for my family.. thanks 9tut. i got
920.
Jason July 11th,
2012
This w as a great help, but you do not explain the variance variable in the EIGRP tutorial. I am w orried that
9tut may be omitting details of certain subjects that may appear on the actual exam since the questions you offer use those
details…
iG July 23rd,
The file was converted using http://www.convertapi.com Please purchase credits to remove this text http://www.convertapi.com/prices
2012
@Mbw ana
@geedub
Variance defines a range of metrics that allow ed for balancing: metrics of this routes should be less then (FD of
successor)*variance. (Feasible condition should be satisfied too).
So if variance =1, only equal-cost paths are allow ed.
iG July 23rd,
2012
If variance >1 then unequal-cost paths are possible, but their number is no more then Maximum Path.
Correct me if I’m w rong.
q7
mobby August 1st,
2012
hi peeps..how many questions does this exam contains?
thanks
Anonymous August 2nd,
2012
If the Variance is = 1, then there w ill be 4 equal paths. But since the variance is = 3, w hich means
that the (3xAD)<FD principle converted the unequals to equals, now it can be up to 4 unequal paths. if the variance w as set
to 2 still there w ere 4 unequal paths, w ith diferente (VxAD)<AD. AD=Advertized Distance = Reported Distance.
Wally August 2nd,
2012
If the maximum path is changed to 5, and having a variance higher that 1, then there w ill be 5 unequal
paths. If variance is changed back to 1, then there w ill be 5 equal paths.
Add a Comment
Name
The file was converted using http://www.convertapi.com Please purchase credits to remove this text http://www.convertapi.com/prices