Академический Документы
Профессиональный Документы
Культура Документы
. . . . . . required
Dimensions . . . . .for. internal
. . . . tracks Dimensions required for irregular stairs
Include all other dimensions relevant to fan, quarter and half landings and stairs
Please detail any intrusions above stringers , i.e. Handrails, pelmets , window cills etc.
Track usually follows angle of Specify the distance from A stooped start can be used This can be used when a
st
stairs to ground floor level the 1 riser to the furthest to avoid using of a hinged clear way is required for a
point that you require the track if space is restricted. doorway or a hall which is
arm of the chair to stop. located directly at the bottom
of the stairs.
A wrap around start offers A wrap around finish offers Footplate finishes as close as Specify the distance from the
less track intrusion at the an overrun without possible to the nose of the nose of the last tread to the
bottom of the stairs. obstructing part of the last step. furthest point that you require
stairway. the arm of the lift to stop.
1st Flight 2nd Flight 3rd Flight 4th Flight 5th Flight 6th Flight Totals
Add up total
Number of
Number of steps in each flight number of
Risers risers
Add up total
1st Riser
This is the single height of the first step in each flight of stairs. heights of all
Height st
1 risers
st
This is the vertical measurement from the surface of the 1 step at the bottom Add up total
Vertical st
of the stairs to the surface at the top of the flight (Do not include the 1 step Heights of all
Height (b) height.) flights
st
Horizontal This is the horizontal distance from the nose of the 1 step at the bottom of the
Length (a) flight to the last nose at the top of the flight. (Only for straight flights)
st
This is the diagonal length from the nose of the 1 riser to the nose of the last
Nose-Nose riser of the flight. (Only for straight flights)
Measure stair angle with a suitable device. The stair angle is the angle created
Angle between a horizontal line and a straight line created from stair tread nose to
nose. (Only for straight flights)
Measure minimum width of staircase taking into consideration any
Min Width handrails/newel posts etc which could affect the width of the staircase in
certain areas.
Stringer
Measure width of stringers.
Width
Stringer
Measure height of stringers.
Height
Calculated
Calculate Nose to Nose using Pythagoras to check measurements listed on the
Nose-Nose table above.
(c)
Ave Ave Add up total risers/treads divide that figure between the number
Riser Tread of steps/treads to average out the individual values.
If there is a bulkhead
measurements must be taken