Академический Документы
Профессиональный Документы
Культура Документы
Revision record
Date Revision Change Description Author
version
2004-01-07 1.00 Initial transmittal Jiang lihong
Table of Contents
1 Preparation for Indoor Distribution...............................................................................7
2 Types of Indoor Distribution.........................................................................................7
3 Selection of Indoor Distributed System Components..................................................8
4 Specifications of Components without BOM Numbers..............................................10
4.1 Specifications of Additional Power Splitters.....................................................10
4.2 Omni Antennas Used in the Indoor Distributed System...................................11
4.3 Directional Antennas Used in the Indoor Distributed System..........................12
4.4 High Gain Directional Antenna Used in Lifts....................................................12
4.5 Basic Specifications of the WLAN Trunk Amplifier of the YDI Company.........13
4.6 Filters Used when the Indoor Distributed System Is Shared with a GSM
System 14
4.7 Triplex Filter Used when the Indoor Distributed System Is Shared with a GSM
System and DCS System......................................................................................................14
5 Specifications for Customized Components..............................................................15
5.1 Specifications for the WCDMA Trunk Amplifier................................................15
5.2 Specifications for the Filter Used when the Indoor Distributed System Is
Shared with a WLAN.............................................................................................................16
6 Specifications of Some of These Components..........................................................17
6.1 Low-Power Signal Combiners..........................................................................17
6.2 Equipower Splitters...........................................................................................18
6.3 Couplers...........................................................................................................19
6.4 Leakage Cable.................................................................................................20
6.5 Feeder Cable....................................................................................................21
6.6 Load..................................................................................................................22
List of Tables
table 1 Indoor distributed system components with BOM numbers...............................8
table 2 Specifications of additional power splitters.......................................................10
table 3 Omni antennas used in the indoor distributed system.....................................11
table 4 Directional antennas used in the indoor distributed system.............................12
table 5 High gain directional antenna used in lifts........................................................13
table 6 Basic specifications of the WLAN trunk amplifier.............................................13
table 7 Duplex filters used when the indoor distributed system is shared with a GSM
system 14
table 8 Triplex filter used when the indoor distributed system is shared with a GSM
system and DCS system............................................................................................................14
table 9 Specifications for the trunk amplifier in a WCDMA indoor distributed system. 15
table 10 Specifications for the filter used when the indoor distributed system Is shared
with a WLAN 16
table 11 Technical specifications of the low-power signal combiner (2-to-1).................17
table 12 Technical specifications of the low-power signal combiner (3-to-1).................17
table 13 Technical specifications of the low-power signal combiner (4-to-1).................17
table 14 Technical specifications of the equipower splitter (1-to-2)...............................18
table 15 Technical specifications of the equipower splitter (1-to-3)...............................19
table 16 Technical specifications of the equipower splitter (1-to-4)...............................19
table 17 Technical specifications of the coupler (7dB)...................................................19
table 18 Technical specifications of the coupler (10dB).................................................20
table 19 Technical specifications of the coupler (15dB).................................................20
table 20 Technical specifications of the leakage cable..................................................20
table 21 Technical specifications of the feeder cable (7/8 LDF)....................................21
table 22 Technical specifications of the feeder cable (1/2’’ super flexible)....................21
table 23 Technical specifications of the load..................................................................22
List of Figures
figure 1 Flowchart of the network optimization acceptance.............................................8
figure 2 Appearance of an omni antenna used in an indoor distributed system...........12
figure 3 Appearance of a directional antenna used in an indoor distributed system.....12
figure 4 Appearance of a high gain directional antenna used in a lift............................13
figure 5 Appearance of a Duplex filter...........................................................................14
figure 6 Appearance of a triplex filter.............................................................................15
figure 7 Definitions of ports on the duplex filter used when the indoor distributed system
is shared with a WLAN...............................................................................................................16
figure 8 Appearances of lower-power signal combiners................................................18
figure 9 Appearance of a 1-to-2 power splitter..............................................................19
figure 10 Appearance of a 1-to-3 power splitter..............................................................19
figure 11 4 Appearance of a 1-to-4 power splitter...........................................................19
figure 12 Appearance of a coupler..................................................................................20
figure 13 Appearance of a leakage cable........................................................................21
WCDMA RNP
Key words: indoor distribution, material, cable, antenna, component, combiner, splitter
Abstract: This guides the list of material of the indoor distribution system in WCDMA RNP.
List of abbreviations:
Abbreviations Full spelling
Site acquisition
Preliminary survey
Building information (structure and
layout);
Surrounding network information;
Measure
ensure the min. level required to
Coverage;
Preliminary design.
System design
Identify the antenna connector EIRP (propagation
measurement and model calculation);
Design the distributed system (antenna installation
position, feeder cable route, power budget and propagation
loss);
Scheme Design
The equipower splitting is adopted when a NodeB is located on a floor in the middle of a building and
upward and downward cables are symmetrically distributed, while the non-equipower splitting is
adopted in the case of asymmetrical distribution.
3 3
1.3 3
3 6
3
Tx/Rx
0.5 3
10
3
3 3
0.5 10
3
Equipower splitting
Tx/Rx
Non-equipower splitting
a substitute for
27020069
SLPS-2204 (4-to-1) ---Sanshuishenglu 27020080 Used when the Section 6.1
power is less than
25W
Omni antenna TS-IAOMT-800/2400----Telestone N/A Section 4.2
TQJ-SA800/2500-3----Sanshuishenglu 27010210 Recommended Section 4.2
800 10137-----KATHREIN N/A Section 4.2
Directional N/A Section 4.3
742 149----KATHREIN
antenna
TDJ-SA800/2000-7-90-----Sanshuishenglu 27010209 Recommended Section 4.3
AVM0918-0857-00SF----ANDREW N/A Section 4.3
High gain 742192-----KATHREIN N/A Used in lifts Section 4.4
directional
antenna
Filter used when 27030055 Used when the Section 4.6
indoor distributed
the indoor
system is shared
distributed with a GSM 900M
793362---KATHREIN system
system is
shared with a
GSM system
Filter used when N/A Used when the Section 4.7
indoor distributed
the indoor
system is shared
distributed with a GSM 900M
system and a DCS
system is
FDGW5504/2S-1-----RFS system
shared with a
GSM system
and DCS
system
793425---KATHREIN N/A Section 4.7
WLAN trunk AMP2440-I------YDI N/A Section 4.5
amplifier
WCDMA trunk Customized based on specifications N/A Section 5.1
(section 5.1)
amplifier
Amplifier shared Customized based on specifications N/A Section 5.2
(section 5.2)
with a WLAN
7dB coupler Antenna feeder coupler-GSM- 27130004 Signal coupler Section 6.3
800~2200MHz-7dB-N/Female
10dB coupler Antenna feeder coupler-GSM- 27130002 Signal coupler Section 6.3
800~2200MHz-10dB-N/Female
15dB coupler Antenna feeder coupler-GSM- 27130003 Signal coupler Section 6.3
800~2200MHz-15dB-N/Female
Leakage cable 2.2 GHz, coupling degree 87dB 25070049 Used in tunnels and Section 6.4
lifts; high-cost
1/2" LDF cable
7/8" cable Coaxial cable-LDF5-50Ω-7/8" 25070017 Used as trunk cables Section 6.5
in long cable routes
Usually, Yagi high gain directional antennas are used in lifts. However, because in
an indoor distributed system, the antenna bandwidth is required to be broad enough
to accommodate all the frequency bands available, Yagi antennas are not the ideal
choice for such a system. Yagi antennas are used only when the carrier has a
WCDMA system only. In this case, log periodic antennas with an extremely broad
bandwidth are used in lifts.
table 5 High gain directional antenna used in lifts
4.5 Basic Specifications of the WLAN Trunk Amplifier of the YDI Company
If a WCDMA system and a WLAN system share the indoor distributed system, the WLAN trunk
amplifier of the YDI Company, AMP2440-I, should be used for the WLAN system. Its specifications are
listed in the table below.
table 6 Basic specifications of the WLAN trunk amplifier
4.6 Filters Used when the Indoor Distributed System Is Shared with a GSM
System
Duplex filters listed in table below are used when the indoor distributed system is
shared with a GSM system.
table 7 Duplex filters used when the indoor distributed system is shared with a GSM system
4.7 Triplex Filter Used when the Indoor Distributed System Is Shared with a GSM
System and DCS System
The triplex filter listed in table below is used when the indoor distributed system is
shared with a GSM system and DCS system.
table 8 Triplex filter used when the indoor distributed system is shared with a GSM system and DCS
system
table 9 Specifications for the trunk amplifier in a WCDMA indoor distributed system
5.2 Specifications for the Filter Used when the Indoor Distributed System Is
Shared with a WLAN
Specifications for the duplex filter used when the indoor distributed system is shared
with a WLAN are listed in table below.
figure 7 Definitions of ports on the duplex filter used when the indoor distributed system is shared with a WLAN
B(WLAN)
table 10 Specifications for the filter used when the indoor distributed system
Is shared with a WLAN
6.3 Couplers
6.6 Load
List of references: