Академический Документы
Профессиональный Документы
Культура Документы
AIM:
To design an Inverting Amplifier for the given specifications using Op-Amp IC 741.
1. Op-Amp
2. Resistors 3 Nos ( Ri = 1 KΩ, Rf =10 KΩ, RL = 100 KΩ
3. Power supply +/- 15V
4. Signal generator 1 KHz to 100 KHz
THEORY:
This is the one of the most popular op-amp circuits. The polarity of the input voltage gets
inverted at the output. If a sine wave is fed to the input of this amplifier, the output will be an
amplified sine wave with 180o phase shift. The gain of the inverting amplifier is given by the
expression :
A= -Rf/Ri
where Rf is the feedback resistance and R iis the input resistance. Inverting amplifier can be
used as a scaler because the amplitude of the output can be varied by varying either of the
resistors Rf or Ri.
CIRCUIT DIAGRAM:
DESIGN:
Then Rf/Ri=10
Let RL = 100 KΩ
MODEL GRAPH
PROCEDURE:
1. Connect the components as per the circuit diagram to obtain the schematic in
Multisim.
2. Set sweep generator to 2V p-p sine wave and observe the input and output
simultaneously. Verify the gain and phase inversion.
OBSERVATIONS:
RESULT:
The design and simulation of the inverting amplifier was done and the input and output
waveforms were recorded.
AIM:
To design a Non- Inverting Amplifier for the given specifications using Op-Amp IC 741.
1. Op-Amp
2. Resistors 3 Nos ( Ri = 1 KΩ, Rf =10 KΩ, R L = 100 KΩ
3. Power supply +/- 15V
4. Signal generator 1 KHz to 100 KHz
THEORY:
This circuit provides a gain to the input signal without any change in polarity. The gain of the
inverting amplifier is given by the expression A=1+R f/Ri where Rf is the feedback resistance
and Riis the input resistance. The input impedance of non-inverting amplifier is extremely
large, typically 100MΩ.
A= 1+ Rf/Ri
DESIGN:
i.e., 1+ Rf/Ri= 11
or Rf/Ri=10
Take Ri=1KΩ.
Then Rf = 10KΩ
MODEL GRAPH
PROCEDURE:
1. Connect the components as per the circuit diagram to obtain the schematic in
Multisim.
2. Set sweep generator to 2V p-p sine wave and observe the input and output
simultaneously. Verify the gain and phase inversion.
OBSERVATIONS:
The design and simulation of the non-inverting amplifier was done and the input and output
waveforms were recorded.