Академический Документы
Профессиональный Документы
Культура Документы
2. Scroll down to the web page to the TP-Link section and choose the correct model modem, your modems
model number will be written on the front of your modem.
3. Save the file to the desktop and wait for the file to finish downloading (4mb)
5. Log in with you’re the default username and password (this is not your gotalk username and password)
Username: admin
Password: admin
Click Ok
7. Click on browse and browse to the computers desktop where you saved the file that you downloaded
from the gotalk website, then select the file with the mouse and click open
Do not click anything else – Wait for the page to refresh on its own
This will disconnect your internet upgrade the firmware and reset your modem
Once complete the Internet Explorer page will refresh on its own and you will see the following in the
middle of the page
10. From the side menu select Management > Settings > Restore Defaults
11. You will be asked if you are sure you want to perform this step, click OK
Do not click anything else – Wait for the page to refresh on its own
12. This will restore the modem to factory defaults and reset the modem, the modem will start on its own
and the page will refresh on its own
You must now re-configure the modem with your gotalk ADSL
username and password to reconnect to the gotalk ADSL service
From the side menu select Advance Setup > WAN > then click Edit (do not select quick setup)
14. Select PPPoA connection type and VC/MUX Encapsulation then click Next
16. Change the MTU from 1492 to 1460 then click Next
17. Keep clicking Next until you see Save, click Save
You will now need to wait atleast 2 minutes for the ADSL to connect to gotalk.
The modem has now been upgraded and you can close all open pages and
begin using the gotalk internet service again.