Вы находитесь на странице: 1из 8

.....

II
II

..
II

....'"
....
'..."
II
....
II

......
II

..
II
II
II

I II
II
.
It

........
......
.
.
II

......
III

..
....
OIl

U T !II I .... I
......
....
...
THINGS YOU SHOULD KNOW STARTING ENGINE

WARRANTY

desirable
and have to
the manufacturer.
CONTACT YOUR LOCAL
ENGINE OR BATTERY SERVICE HEADQUARTERS.
CLUTCHING

NOTE: 90 DIlY Warranty for Commercial Use.

BEFORE YOU START

PARKING BRAKE

oil should be all as far


forward.
clutch-brake
located at the rear back.
and fill to level of hole
S.A.E. 90 Gear Lube ATTACHING TOOLS

transmission should be checked after


should be
bottom to
is a

All attachment
TIRES clutch side of the
tractor.
CARE OF TRACTOR
1. and oiled
the location
transmission and
air cleaner clean. This will add
3. Keep tires properly inflated. See previous in- FOR YOUR SAFETY
structions. A. Keep all guards on at all times.
4. Keep tractor covered and in a dry place B. Never abuse your tractor by improper handling.
when not in use.
C. Keep hands and feet from moving parts.
S. Keep grass and dirt out of engine cowling as
these will stop the flow of air and decrease en- D. Remove key when not in use.
gine life. E. Be careful on high uneven ground.
6. BRAKE ADJUSTMENT. The brake band, lo-
cated on the left side of the transmission, brakes WHEEL HORSE MODEL 603
the transmission and in turn stops the wheels. TRACTOR SPECIFICATIONS
To adjust first set the parking brake then adjust
(Specifications subject to change without notice.)
the nut on the brake rod until it locks the rear
wheels. Disengage pprking brake, remove cotter Length overall .. , . . . . . . . .. . . . .... 61 inches
pin from clutch rod at clutch brake pedal and by Wheelbase . . . ...... , ..... 41 % inches
turning in or. out adjust clutch brake pedal to Width overall .... . 30 inches
operators desired position. Width at front wheels . . . . .... , ....... 28};2 inches
7. When replacing belts or mounting drive im- Height .. . ... .... . . . . . ... . . ... . .... ...... 36};2 inches
plements make sure all pulleys are in line. Height to top of hood . ....... ................ 32 inches
S. Your tractor is only as good as the service Net weight . ... . . . . ............. . ....... 349 Ibs.
you give it. See your Wheel Horse Dealer for a Crop clearance ..... .. ... . . .. . .. . ......... ..... . 7% inches
through check-up after each season of use. Frame clearance , . .. . ..... . . ........... 13};2 inches
Engine (4-cycle, single cylinder, air cooled) ... . . 6 hp.
9. When replacing belts be sure to purchase Fuel capacity . ..... . . . . . . . .... , . , ... 4 quarts
them from your Wheel Horse Dealer, as these Tires (front) "" 4:00 x 8" pneumatic (16" wheel dia.)
belts are specifically designed for each application. Tires (rear) Cleat-type or All Purpose tread
(NOTE: Make sure all pulleys are in line.) 6:00 x 12" pneumatic (22" wheel dia.)

Figure 1
Frame
Transmission - see last page for Transmission break down and P"rts

Rllq'd.

Soc. 1
10 27 4413
28 933217
2
2 30 4412
908035·4
9
33 3917
34 933215
2

37

4447
40 4408

3949
6 3940 • Drog
Axle
47 4
48
49
50 1621
x 2
52 97 909484
53 98 1576
99 1786
55 100 1192
56 101 1217
57 102 2734 Throllie 8. Choke

1363 103 3328 1


58
59 104 2
60 2593 105 2
106 3329
107 4
62
3:9>!liI 108 2
63
64 109
65 306.2i
III 1385 2
66 4222
67 Manual
4438 2
68
4~39
3
116
17 1667 2
72
2
119 1662 2
120 1654 2
3 121 6
5 1709 2
1712 2
2
Tube 2
2
Wheel - Steering
Pin· x 1%
- Choke & Throlile
Decal Wheel Horse Emblem

EI.

2
No.

1
2
2
2
2

form No 127

Вам также может понравиться