Академический Документы
Профессиональный Документы
Культура Документы
Which Layer 4 protocol does EIGRP use to provide reliability for the transmission of routing information
DUAL
IP
PDM
RTP
TCP
UDP
Bottom of Form
Top of Form
What does a router that is running RIP use to determine the best path to take when forwarding data?
the host portion of the network address
What is the purpose of the network command when RIP is being configured as the routing protocol?
It identifies the networks connected to the neighboring router.
It identifies all of the destination networks that the router is allowed to install in its routing table.
It identifies the directly connected networks that will be included in the RIP routing updates.
Bottom of Form
Top of Form
A network administrator issues the command show ip route and observes this line of output:
What two pieces of information can be obtained from the output? (Choose two.)
RIP is the routing protocol that is configured.
every 45 seconds
every 60 seconds
every 90 seconds
Bottom of Form
Top of Form
What two statements are correct regarding EIGRP authentication? (Choose two.)
EIGRP authentication uses the MD5 algorithm.
EIGRP authentication requires that both routers have the same key chain name.
EIGRP authentication uses varying levels of WEP to encrypt data exchanged between routers.
EIGRP authentication can be configured on one router and updates from this router are protected;
whereas a neighbor router can be without the authentication configuration and its updates are
unprotected.
Bottom of Form
Refer to the exhibit. What three conclusions can be determined based on the exhibited commands?
(Choose three.)
A link-state routing protocol is used.
A distance vector routing protocol is used.
Bandwidth, load, delay, and reliability are metrics that are used for route selection.
70
90
100
110
120
255
Top of Form
The route must be confirmed by neighboring routers before it is put in the active state.
The route is a feasible successor and will be used if the active route fails.
a mismatch between the configured bandwidth and the actual bandwidth of a link
Bottom of Form
Top of Form
What three statements are true about routers that are configured for EIGRP? (Choose three.)
They can support multiple routed protocols.
Refer to the exhibit. The network is configured with RIP routing. Which mechanism
prevents R1 from sending an information update about network A to R3?
poisoned reverse
split horizon
holddown timers
TTL
Top of Form
Top of Form
Refer to the exhibit. Which statement is true about the output from the show ip
protocols command?
RIPv2 is configured on this router.
Auto summarization has been disabled.
Refer to the exhibit. Routers A and B have EIGRP configured, and automatic
summarization has been disabled on both routers. Which command applied on interface
S0/0/0 of router A manually summarizes the networks in EIGRP advertisements to
router B?
ip area-range eigrp 1 192.168.10.80 255.255.255.224
Top of Form
An enterprise network currently uses a star topology to connect the headquarters to four branch offices
The network administrator wants to make one of the branch offices a centralized connection for three n
local offices. What is the resulting topology?
full mesh
partial mesh
extended star
Refer to the exhibit. What is represented by the Null0 route for the 128.107.0.0
network?
a child route that is defined
a parent route that is defined and sourced from a physical interface
Top of Form
Which two features of EIGRP are different from RIPv2? (Choose two.)
routing metric
VLSM support
routing updates
classless routing
What is the maximum distance in hops that a remote router can be and still be considered reachable b
RIP?
14 hops
15 hops
16 hops
17 hops
Bottom of Form
Refer to the exhibit. The routers are configured with EIGRP and with default K values.
What is the routing path for a packet from network A to reach network B?
R1, R2, R5
R1, R3, R5