Академический Документы
Профессиональный Документы
Культура Документы
c2960-lanbasek9-mz.122-25.FX.bin
I have not heard of such a problem. I presume you do save your configurations (copy run
start) each time you do any changes?
Or do you perhaps configure from a TFTP server? Do you have service config anywhere
in your configuration?
Kevin Dorrell
Luxembourg
Postings may contain unverified user-created content and change frequently. The content is provided as-is and
is not warrantied by Cisco.
1
2960 switch configuration issues
Feb 26, 2007 2. Re: 2960 switch configuration issues Nov 27, 2007 7:22 AM
RE (fc1)
States and local country laws governing import, export, transfer and
compliance with U.S. and local country laws. By using this product you
Postings may contain unverified user-created content and change frequently. The content is provided as-is and
is not warrantied by Cisco.
2
2960 switch configuration issues
agree to comply with applicable laws and regulations. If you are unable
to comply with U.S. and A summary of U.S. laws governing Cisco cryptographic products
may be found at:
http://www.cisco.com/wwl/export/crypto/tool/stqrg.html
export@cisco.com.
es of memory.
24 FastEthernet interfaces
Postings may contain unverified user-created content and change frequently. The content is provided as-is and
is not warrantied by Cisco.
3
2960 switch configuration issues
Version ID : V02
Postings may contain unverified user-created content and change frequently. The content is provided as-is and
is not warrantied by Cisco.
4
2960 switch configuration issues
Hi Tom, I have a similar scenario. I have 2950's and 2960's that either lose their
configurations or simply stop responding to a ping although they continue to function as a
switch when that happens. Keep in mind the config could also be erased by holding in the
mode button for too long. I have not seen any remedy for a few months now on this forum as
to why they stop responding. A Cisco case may have to be opened to get the right attention,
unless someone can reply to this thread?
We have not seen this problem and we have a lot of 2950's but it rings a bell and I think it
was a code issue if the code is really old. We are running 12.1.22ea10 and have been for
some time and have not seen an issue , my reccomendation would be to upgrade the code
to the latest release. Have never seen a box lose the config unless you have unstable power
where it goes down , starts come back and then quickly goes down again , we have seen a
router or 2 where it loses the config in nvram.
Hi Tom,
I have an almost identical issue in that I am losing all configuration and going back to the
initial config dialogue.
Postings may contain unverified user-created content and change frequently. The content is provided as-is and
is not warrantied by Cisco.
5
2960 switch configuration issues
24 FastEthernet interfaces
Postings may contain unverified user-created content and change frequently. The content is provided as-is and
is not warrantied by Cisco.
6
2960 switch configuration issues
Version ID : V03
Postings may contain unverified user-created content and change frequently. The content is provided as-is and
is not warrantied by Cisco.
7
2960 switch configuration issues
Postings may contain unverified user-created content and change frequently. The content is provided as-is and
is not warrantied by Cisco.
8