Вы находитесь на странице: 1из 3

Now with up to 25 watts output (802.

3at)

VoIP V2 Loudspeaker Amplifier


The new CyberData V2 SIP-enabled VoIP Loudspeaker

Amplifier provides an easy method for implementing an IP-based

overhead paging system for both new and legacy installations.

With up to 25 watts of driving power (802.3at), the Amplifier

provides direct drive of a standard Horn speaker and supports

a line-out connector for connection to an external amplifier.

The interface is compatible with most SIP-based IP PBX

servers that comply with the SIP RFC 3261. For non-SIP
Loudspeaker (part #011068) must be purchased separately.
environments, the Loudspeaker Amplifier can be configured to

listen to multicast address and port number combinations to VoIP V2 Loudspeaker Amplifier Specifications

Ethernet I/F 10/100 Mbps


form paging zones.
Power Input PoE 802.3at or 802.3af
Ringer Mode Operating Temperature -30 to 55 C (-22 to 131 F)

The VoIP V2 Loudspeaker Amplifier supports two SIP Protocol SIP RFC 3261

extensions. One extension can be assigned to a page group for Payload Types G711

auto answer paging. The second extension can be assigned to Regulatory Compliance FCC Class A
Warranty 2 Years Limited
a “First-to-Answer” ring group with IP phones. An audio ring file
Dimensions 14" x 10" x 4"
is activated when the second SIP extension of the ceiling
Output 802.3af - up to 8 watts
speaker is dialed. If any of the IP phones in the ring group is
answered (or if the caller hangs up), the Loudspeaker Amplifier 802.3at - up to 25 watts
Lineout:
stops ringing.
Output Signal Amplitudes 2.0 VPP maximum
Features Output Level +2dBm nominal
Total Harmonic Distortion 0.5% maximum
 SIP and Simultaneous Multicast
Boxed Weight 6.5 lbs.
 Dual-speed ethernet 10/100 Mbps
Part Number
 Web-based configuration Loudspeaker Amplifier, AC 011095
Loudspeaker Amplifier, Wireless 011096
 PoE 802.3at and 802.3af-enabled
Loudspeaker Amplifier, PoE 011097
 Line-in for background music
 Line-out connector
 DTMF controlled relay
 Direct 8 Ohm speaker drive
 User-uploadable tones and messages
 Digital and manual volume control
 Second SIP endpoint "Night Ringer"
 Autoprovisioning
 Auto-call voice message from input port sense 011097 011095 011096

CyberData Corporation  2555 Garden Road  Monterey, California 93940 930340D/100729


CyberData Corporation (831) 373-2601  (831) 373-4193  www.cyberdata.net
VoIP V2 Loudspeaker Amplifier

Typical Installation - PoE 802.3af (Part# 011097)


802.3af Generic PoE Switch or
802.3at High Power Switch
1 2 3 4 5 6

011097

VoIP V2 Loudspeaker Amplifiers – No AC Required IP Phone IP-PBX Server

Typical Installation - AC Version (Part# 011095)


Generic Ethernet Switch
1 2 3 4 5 6

011095

VoIP V2 Loudspeaker Amplifiers – AC Required IP Phone IP-PBX Server


High Power PoE Injector in Box

Typical Installation - Wireless 802.11g (Part# 011096)

Generic Wireless Ethernet Switch


1 2 3 4 5 6

011096

VoIP V2 Loudspeaker Amplifiers – AC Required IP Phone IP-PBX Server


High Power PoE Injector in Box

*For AC wiring, use a qualified electrician.

CyberData Corporation  2555 Garden Road  Monterey, California 93940


CyberData Corporation (831) 373-2601  (831) 373-4193  www.cyberdata.net
VoIP V2 Loudspeaker Amplifier

Configuring the V2 Loudspeaker Amplifier for Alarm Sensing


User can upload an audio message
to the Loudspeaker Amplifier.

When the “Sense-In” is activated, the stored


Audio file will play out the local speaker and
IP Phone
repeat until the condition is cleared.

The Loudspeaker Amplifier can also call a


pre-set phone number and when that phone
answers, the stored Audio message will
also be played to the phone. Window Reed switch is connected
to the “Sense-In” connection. Window Reed Switch

V2 Loudspeaker Amplifier with Strobe Alert


Alert Strobe
When the V2 Loudspeaker
High PIV UltraFast Amplifier is called from a remote
Solid State Switching Diode
or
Mechanical
phone, the relay on the paging
Relay amplifier can be programmed to
OUT IN
blink and drive an Alert Strobe.

Output Contacts
AC or DC rated
Depending Upon
Controlled Device
Requirements

AC or DC
Power Source
- DC
POWER SUPPLY +
( MAX.
)
30 VDC @ 1A
Loudspeaker Amplifier

V2 Loudspeaker Amplifier Connections

CLASS II WIRING
10-Spkr Out (-)
9-Spkr Out(+)
3-Relay COM

7-Line-Out(+)
8-Line-Out(-)
1-Sense (+)

4-Relay NO
5-Line-In(+)
6-Line-In(-)
2-GND

CyberData Corporation  2555 Garden Road  Monterey, California 93940


CyberData Corporation (831) 373-2601  (831) 373-4193  www.cyberdata.net

Вам также может понравиться