Академический Документы
Профессиональный Документы
Культура Документы
AWWA C203a-99
Addendum to
ANSI/AWWA C203-97
Standard
for
Coal-Tar Protective Coatings and Linings for
Steel Water Pipelines—Enamel and Tape—Hot Applied
(Approved by the AWWA Board of Directors on Jan. 24, 1999.)
22. If materials only are being purchased according to the requirements of Sec.
4.3 of this standard, then the purchaser shall specify quantities for the following
items: (1) primer by type (Sec. 4.3.2); (2) coal-tar enamel by type (Sec. 4.3.3.1 and
Table 1); (3) outerwrap (Sec. 4.3.4); and (4) glass-fiber inner mat (Sec. 4.7.3.1). The
purchaser should also specify if an affidavit of compliance is required (Sec. 6.3).
4.7.2.4.2 The construction of this exterior protection shall consist of (1) primer;
(2) coal-tar enamel, 3/32 in. ± 1/32 in. (2.4 mm ± 0.8 mm) thick; (3) glass-fiber inner
mat; (4) coal-tar enamel, 1/32 in. (0.8 mm) minimum; (5) bonded outerwrap; and (6)
whitewash, water-emulsion latex paint, or kraft-paper finish coat.
4.7.2.4.3 Glass-fiber inner mat shall conform to the material requirements set
forth in Sec. 4.7.3.1.