Академический Документы
Профессиональный Документы
Культура Документы
7. Describe the ways in which the river processes are carried out.
Erosion
• Wearing down of the banks, river bed and the removal of eroded materials
by the action of gravity and flowing water.
• Vertical erosion results in the deepening of a river channel.
• Lateral erosion causes the river channel to widen.
• Occurs in all three courses
- Upper course is dominated by vertical erosion where volume of flow is small
but at a greater speed.
- In the middle course, erosion increases as the river discharge increases
when it moves downstream. With fewer big obstructing boulders, its speed
slows down.
- Lower course is dominated by lateral erosion as it experiences the largest
amount of discharge.
• Four Erosional processes
- Hydraulic action is a process by which loose materials are pushed away and
rocks in a river are broken down by the sheer force of water.
- Abrasion is a process by which the load carried by a river grinds against the
bed and banks of the river, it is also known as corrasion.
- Attrition is a process by which rock fragments carried in a river rub and knock
against each other.
- Solution is a process by which river water dissolves or reacts with the soluble
minerals in rocks. It is also known as corrosion.
Transportation
• It is a process whereby eroded materials are carried by moving water down
the river course.
• Occurs throughout the three courses.
• Load refers to the materials transported by river.
• Amount of load carried increases progressively towards the river mouth.
• Size of sediments transported decreases from upper to lower course.
• The distance the load is transported depends on the size of particles, the
speed of flow and volume of flow.
• Four transportation processes
- Traction is a process whereby large boulders roll or slide along the river bed
- Saltation is a process whereby larger particles in a river bounce and hop
along the river bed.
- Suspension is a process whereby flowing water transports insoluble fine
particles such as clay and silt in a river while keeping them afloat.
- Solution is a process whereby soluble minerals from rocks such as limestone
are carried in the river and transported downstream. In tropical areas with
dense vegetation cover, dissolved minerals and organic acids from decayed
vegetation are often transported by the river, resulting in the river water
becoming brackish.
Deposition
• Occurs when the volume of flow is reduced and/or the speed of flow is
decreased.
• Also occurs when the river no longer has enough energy to carry its load e.g.
in convex banks of a meandering river or when it flows into a course with
gentle gradient.
• Coarser and heavier loads are deposited first followed by finer materials,
including dissolved materials. These finer materials are usually deposited at
the mouth of the river e.g. the sea or lake.
• It is more prominent in lower course where the speed of flow is slow and the
load is at its maximum.
(b) Waterfalls are found in the upper course of a river when the gradient of a
river bed drops suddenly, the water plunges down from a great height to form
a waterfall.
There are two ways a waterfall can form.
- When a river flows over rocks with unequal resistance, the less resistant
rocks downstream will get eroded much faster than the resistant layer
• Processes of erosion like hydraulic action, abrasion and solution break down
the less resistant rock.
• Over time, this results in a sudden change in gradient and causes the water
to plunge.
• As water plunges and hits the bottom of the waterfall, the force of plunging
water together with the swirling rocks erode the river bed to form a plunge
pool.• An example is Iguazu Falls, at the border of Argentina and Brazil. - By
faulting
• During faulting, rocks are uplifted, causing a displacement of rocks where
one rock is higher than another.
• When a river flows across an area where faulting has occurred, the gradient
of the river bed drops suddenly and a waterfall is formed.
• An example is Victoria Falls along the Zambezi River.
(b)Deltas are found at river mouths, e.g. Mississippi Delta, USA, Nile Delta,
Egypt and Mekong Delta, Vietnam
• When a river enters a body of water e.g. a lake or sea, its velocity is
reduced.
• This results in a decrease in energy and deposition takes place.
• Sand is deposited close to the shore while fine silt and clay are carried
further out before being deposited.
• Over a period of time, layers of sediments will build up and eventually form
an extensive platform of river sediment called a delta at the river mouth.
• Conditions suitable for delta formation include:
- The river must carry sufficient amount of load when entering the sea.
- Weak tidal currents along the coast so that the sediments are not washed
out to sea or pushed along the coast much faster than the river can deposit it.
- Shallow coast to ensure that the sediments will not be dispersed into the sea
before it is deposited.
• As the river flows over a delta, the deposited sediment may become an
obstacle to the path of the river forcing the river to split into several streams to
find its way round the obstruction. These streams are called distributaries.
(c) Meanders are formed when a river twists and turns forming hoop-like
bends in the river.
• They are most prominent in the lower course but they can be found
anywhere along the course of a river.
• In the upper course, a river does not meander because at this stage, the
river has little volume and thus little energy so the river bends and turns to
avoid obstacles and find the easiest route down the slope.
• In the middle course, where the gradient has become less steep, the river
starts to slow down and the river begins to meander, eroding the concave
bank by undercutting it and depositing materials on its convex bank where the
speed of flow is slow and weak.·
As the water moves downstream and around a bend, it moves in a spiral
fashion.
The surface water moves across towards the concave bank and then moves
downwards. It then emerges further down along the convex bank.
Thus erosion tends to occur along concave bank and deposition along convex
bank.
The concave bank may be eroded to form a steep slope called river cliff.
The deposition of materials on the convex bank results in the formation of a
slip-off slope.
Oxbow lake
• In the lower course, erosion and deposition continue on the concave and
convex banks respectively and the meanders become more pronounced.
Soon a narrow meander neck is formed.
• Eventually the river breaks through the neck and flows through a straight
channel. The meander is gradually cut off from the channel forming an oxbow
lake.
Re-alignment:
· Refers to the straightening of the river channel
· Method removes meanders and reduces the length of the river channel in
order to increase the speed of the river.
· This resulted in the river being able to flow away from the region faster and
washes away sediments which have accumulated on the river bed, localized
flooding is thus minimized.
· The deepening of the river channel allows the river bed to hold more water
and thus reducing the occurrence of flood.
Re-sectioning:
· Refers to the widening and deepening of the river channel, sides of the river
bed is also smoothened by replacing soil of the river bed and banks with
cement and granite.
· Increases the river’s ability to hold more water, thus reduces the occurrence
of flood.
· Re-sectioning also increases the amount of surface run-off from the
surrounding areas into the river as more surface runoff can enter the river
without causing the place to flood.
· The smoothening of river bed and back by the use of cement and granite
reduces the friction between water and the river banks. This increases the
speed of the river and hence allowing water to flow away more quickly.
Bank protection
· It involves the building of artificial levees, dykes or embankments to prevent
river banks from collapsing during heavy rains when volume of rainwater
increases tremendously.
· It is an effective strategy in the short term.
· However it is ineffective in the long term.
· It requires a lot of resources (e.g. funds) and manpower.
· It is also aesthetically unappealing.
· The building of defence along one stretch will lead to increased erosion in
other parts of the river.