Академический Документы
Профессиональный Документы
Культура Документы
0 INSTALLATION
2.1 NORMAL INSTALLATION PROCEDURE
1. Read this section and 3.1 to 3.6 on Operation and Configuration.
2. Remove the cabinet lid and cut the shipping strap that fastens the carriage to the rail on the
metal box. Save the packing material.
3. Install the ribbon cartridge (See 3.3).
4. Check that the label on the printer rear correctly indicates the input supply voltage. (Either
115 VAC for 100-130 VAC input or 230 VAC for 200-260 VAC). If it is incorrect, see
Changing Supply Voltage in 2.3.
CAUTION: CONNECTION OF A PRINTER WIRED FOR 115 VAC TO A 230 VAC INPUT
CAN PERMANENTLY DAMAGE THE PRINTER!
5. Check that the power switch on the printer rear is off ("0" side depressed). Connect the line
cord to the printer and then to an electrical outlet. If a suitable line cord was not supplied
with the printer, procure an IEC HAR (harmonized) line cord that has an IEC 320-C13 style
connector and the appropriate HAR plug for your country.
6. Connect and fasten the interface cable to the rear panel connector. (See 3.13.3 for cabling
information).
7. Documents longer than 8" will feed out the printer rear. Insure that space is available for
the longest document to be fed.
8. Turn on the power switch located on the rear of the printer. READY should be displayed.
9. Configure the printer by the procedure in 3.6. Default settings are:
LINES/INCH = 6 PROTOCOL = DTR
CHARS/INCH = 10 BAUD RATE = 9600
CHARS = SCRIPT WORD LENGTH = 8
PRINT = NORMAL PARITY = NONE
QUIET MODE = N STOP BITS = 1
DOCUMENT INSERT TOP EDGE INPUT BUFFER MULTIPLE LINE INSERT WITH
1 SEC PAUSE EMULATION MODE C
BEGIN PRINTING IMMEDIATELY RETURN ON FEED Y
LINE#1 =. 250 IN
In printers with the automatic alignment feature:
SKEW DETECTION CORRECT SKEW
SKEW DETECTION ALLOWED = .050
IF FORM SKEWED ENTER/EJECT KEYS
IF NARROW FORM PROCEED
Common variations are EMULATION MODE I for IBM Proprinter emulation and
PROTOCOL = XON/XOF for software that does not use DTR hardware handshaking.
Function 94 settings are factory selected for a specific printer mechanism and should not
usually be changed.
10. Perform a local print test using 95 FUNCT. (See 3.9)
11. If the host is unable to print correctly, check that the Communication Parameters selected
under 93 FUNCT match the host parameters and review all Printer Parameters selected
under 92 FUNCT.
3
2.2 RESHIPMENT
If possible, retain the original packing material for reshipment. In any event the following
precautions must be observed:
1. Fasten the carriage with a cable tie, string or wire passing around the top of the carriage
plate and through the hole in the front of the guide rail. Insure that the carriage can't move
horizontally or vertically.
2. If the original packing material is not used, insure that the cabinet lid will not move during
shipment and that the unit has sufficient protective padding on all sides.